text
stringlengths 595
18.7k
| label
int64 0
1
| label_text
stringclasses 2
values |
|---|---|---|
===================== Product Identification =====================
Product ID:RUST FOIL 2675
CAGE:84591
CAGE:84591
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED LIGHT
NAPHTHENIC
CAS:64742-53-6
RTECS #:PY8036000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3 (OIL MIST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CAUSES IRRITATION: MAY BE SKIN
DEFATTER UPON PROLONGED OR REPEATED CONTACT.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:OIL MIST INHALATION MAY CAUSE DIZZINESS, NAUSEA
AND DIFFICULTY BREATHING.
Medical Cond Aggravated by Exposure:SENSITIVE DRY SKIN.
======================= First Aid Measures =======================
First Aid:SKIN CONTACT: WASH SKIN WITH WARM WATER, REMOVE FLUID SOAKED
CLOTHING & SHOES. LAUNDER BEFORE REUSE. EYE CONATCT: IMMEDIATELY
FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MIN, CALL A
PHYSICIAN. ING ESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION. INHALATION: REMOVE TO FRESH AIR. GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:275F,135C
Extinguishing Media:WATER FOG, DRY CHEMICAL, CARBON DIOXIDE OR FOAM.
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS. KEEP
FIRE EXPOSED CONTAINERS COOL WITH WATER.
Unusual Fire/Explosion Hazard:HOT VAPORS FORM EDXPLOSIVE MIXTURES WITH
AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:IN CASE OF SPILL, CONTAIN AND RECOVER BULK
LIQUID. SOAK UP RESIDUE WITH SAND, EARTH, OTHER INERT MATERIAL. PUT
IN A SUITABLE CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH EYES, SKIN AND
CLOTHING. REMOVE CONTAMINATED CLOTHING. LAUNDER BEFORE REUSE. WASH
THOROUGHLY AFTER HANDLING.
Other Precautions:SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE,
FOLLW WARNINGS EVEN AFTER CONTAINER IS EMPTIED. AVOID BREATHING
MISTS OR VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR IF ENGINEERING AND
OTHER CONTROLS ARE NOT ADEQUATE TO REDUCE AIRBORNE EXPOSURE TO
BELOW PERMISSIBLE EXPOSURE LIMITS.
Ventilation:LOCAL EXHAUST RECOMMENDED.
Other Protective Equipment:USE AS REQUIRED TO AVOID SKIN CONTACT.
Work Hygienic Practices:WASH AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>500F,>260C
Vapor Pres:<0.5
Vapor Density:>1
Spec Gravity:0.89
Evaporation Rate & Reference:<1 (BUTYL=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR AMBER LIQUID WITH MILD HYDROCARBON ODOR.
Percent Volatiles by Volume:<1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDANTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE AND
OXIDES OF SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:H0-2A LUBRIPLATE HYDRAULIC OIL
Preparer's Name:JAMES R KONTAK
CAGE:73219
CAGE:73219
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL OIL
Ingred Name:ADDITIVES
Ingred Name:ZINC COMPOUND
Fraction by Wt: <2%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN:
PROLONGED/REPEATED CONTACT MAY CAUSE IRRITATION. INGESTION: LOW
TOXIC. MINUTE AMOUNTS ASPIRATED INTO THE LUNGS DURING INGESTION MAY
CAUSE MILD TO SEVERE PULMONARY INJURY. IF IN JECTED BY HIGH
PRESSURE UNDER SKIN, DELAY OF MEDICAL ATTENTION MAY CAUSE LOSS OF
AFFECTED PART OF THE BODY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/CLEAR WATER FOR 15 MINS. SKIN: WASH W/SOAP &
WATER. INHALATION: IMMEDIATELY REMOVE FROM EXPOSURE. INGESTION:
DON'T INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:415-480F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:FOAM, DRY CHEMICAL, CO2/WATER SPRAY (FOG)
Fire Fighting Procedures:COOL EXPOSED CONTAINERS W/WATER. USE AIR
SUPPLIED BREATHING EQUIPMENT FOR ENCLOSED/CONFINED SPACES.
Unusual Fire/Explosion Hazard:DON'T STORE/MIX W/STRONG OXIDANTS. EMPTY
CONTAINERS RETAIN RESIDUE. DON'T CUT, DRILL, GRIND/WELD AS THEY MAY
EXPLODE.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER LIQUID, WASH REMAINDER W/SUITABLE
PETROLEUM SOLVENT/ADD ABSORBENT. KEEP PETROLEUM OUT OF SEWERS &
WATER COURSES.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE. DON'T HANDLE/STORE NEAR HEAT, SPARKS, FLAME/STRONG OXIDANTS.
Other Precautions:AVOID BREATHING OIL MIST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT NEEDED
Ventilation:LOCAL EXHAUST: USED TO CAPTURE FUMES & VAPORS.
Other Protective Equipment:OIL RESISTANT APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. CLEANS THOROUGHLY AFTER CONTACT.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>550F
Vapor Pres:<0.01
Vapor Density:>5
Spec Gravity:0.87-0.89
Evaporation Rate & Reference:(BUTYL ACETATE=1): <0.01
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TRANSPARENT AMBER LIQUID W/MINERAL OIL ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS; LIQUID CHLORINE, CONCENTRATED OXYGEN
Stability Condition to Avoid:HEAT, SPARKS, FLAME
Hazardous Decomposition Products:SULFUR DIOXIDE; CO
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ABSORBED MATERIAL AT AN APPROVED
WASTE DISPSOAL FACILITY/SITE IAW/LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PR 1440 B-1/2,1440 B 2,ACCELERATOR
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:HYDROGENATED TERPHENYLS
CAS:61788-32-7
RTECS #:WZ6535000
Fraction by Wt: 30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.5 PPM
ACGIH TLV:0.5 PPM; 9596
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9596
Ingred Name:MANGANESE DIOXIDE
CAS:1313-13-9
RTECS #:OP0350000
Fraction by Wt: 55%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG MN/M3 CEILING
ACGIH TLV:5 MG MN/M3
Ingred Name:1,3 DIPHENYL GUANIDINE,
CAS:102-06-7
RTECS #:MF0875000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- EYES:SEVERELY IRRITATING. SKIN:TOXIC BY SKIN
ABSORPTION. MAY BE A SENSITIZER. INHALE:DUST MAY IRRITATE & MAY BE
ABSORBED THROUGH LUNGS. ORAL:M AY BE HARMFUL IF SWALLOWED. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, REDNESS, SENSITIZATION
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUCCEPTIBLE TO THE EFFECTS FROM EXPOSURE TO
THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER.
ORAL:SEEK MEDI CAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:315F,157C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL.
WATER SPRAY MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY CAUSE DECOMPOSITION OF MANGANESE
DIOXIDE RESULTING IN OXIDIATION AND POSSIBLE IGNITION OF
HYDROCARBON VEHICLE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROTECTIVE EQUIPMENT. SCOOP SPILL INTO
CONTAINER FOR DISPOSAL. WASH SPILL AREA WITH A SUITABLE SOLVENT
AFTER PICK UP IS COMPLETE.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLES. KEEP
OUT OF REACH OF CHILDREN.
Other Precautions:AVOID BREATHING DUSTS. DO NOT GET IN EYES, ON SKIN OR
ON CLOTHING. WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. REMOVE CONTAMINATED CLOTHING PROMPTLY. LAUNDER BEFORE
REUSE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:GENERAL VENTILATION
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:N1. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS: ACCELERATOR AND
BASE COMPOUND.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:644F,340C
Spec Gravity:1.97
Evaporation Rate & Reference:NOT RELEVANT
Appearance and Odor:PASTE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
EASILY OXIDIZABLE MATERIALS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN AND MANGANESE COMPOUNDS
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT IS A NONHAZARDOUS WASTE. CONSULT
LOCAL AND STATE REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FOGPRUF LENS SOLUTION, MSA P/N12650
CAGE:55799
CAGE:55799
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 15%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:SUCCINIC ACID, SULFO-1,4-BIS(2-ETHYLHEXYL)ESTER, SODIUM
SALT;(DIOCTYL SODIUM SULFOSUCCINATE). LD50 ORAL (RAT):1900 MG/KG
CAS:577-11-7
RTECS #:WN0525000
Fraction by Wt: 2%
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >80%
===================== Hazards Identification =====================
LD50 LC50 Mixture:(SEE INGRED)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE AND MUCOUS MEMBRANE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:ISOPROPANOL: EYE:IRRITATION. INGEST:DIZZINESS,
INCOORDINATION, HEADACHE, CONFUSION, STUPOR, COMA, ABDOMINAL PAIN,
VOMITING, DIARRHEA. INHAL:IRRITATION OF EYES, NOSE, THROAT. DIOCTYL
SODIUM SULFOSUCCIN ATE: EYE:IRRITATION. INGEST:DIARRHEA. INHAL:NOT
APPLICABLE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:HOLD EYELIDS OPEN & FLUSH EYES W/LG AMTS OF H*2O FOR AT
LEAST 15 MIN. OCCASNLY LIFT UPPER & LOWER LIDS. GET IMMED TREATMENT
BY MD. INGEST:IF VICTIM IS CONSCIOUS & ALERT, GIVE TWO GLASSES OF
H*2O & ENCOURAGE VOM. HOLD VICTIM'S HEAD LOW TO AVOID ASPIRATION
OF VOM. GET IMMED TREATMENT BY MD. INHAL:OVEREXPOS BY THIS ROUTE IS
UNLIKELY. IF OVEREXP SOMEHOW OCCURS, REMOVE FROM EXPOS. GIVE (SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:110F,43C
Lower Limits:2.0%
Upper Limits:12.7%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WEAR NIOSH/MSHA
APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON SAND AND SCOOP TO CONTAINER FOR
PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:FOR USE ONLY AS DIRECTED ON LABEL INSTRUCTIONS.
Supplemental Safety and Health
VAP PRESS:18 MM HG/20C. FIRST AID:ARTIFICIAL RESPIRATION IF NEEDED.
PROVIDE OXYGEN IF BREATHING IS DIFFICULT. GET IMMEDIATE TREATMENT
BY A PHYSICIAN. SKIN:WASH WITH SOAP AND WATER.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:190F,88C
Vapor Pres:SUPP DATA
Vapor Density:>11
Spec Gravity:<1
Solubility in Water:COMPLETE
Appearance and Odor:BLUE-GREEN PERFUMED LIQUID.
Percent Volatiles by Volume:98%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF SURPLUS PRODUCT AS HAZARDOUS WASTE.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS
.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PROPYLENE GLYCOL INDUSTRIAL
Resp. Party Other MSDS Num.:HCR002107
CAGE:UO143
CAGE:UO143
Contract Num:SP0450-01-M-D388
CAGE:4N760
Contract Num:SP0450-01-M-D619
CAGE:4N760
============= Composition/Information on Ingredients =============
Ingred Name:PROPYLENE GLYCOL
CAS:57-55-6
RTECS #:TY2000000
= Wt:99.
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:NO DATA PROVIDED BY MANUFACTURER
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES- SLIGHT EYE IRRITANT.
INHALATION, SKIN AND INGESTION- NO SIGNIFIGANT SIGNS OR SYMPTOMS
INDICATIVE OF ANY ADVERSE HEALTH HAZARD ARE EXPECTED TO OCCUR AS A
RESULT OF EXPOSURE TO INHALATION/ SKIN CONTACT/SKIN
ABSORPTION/INGESTION. CHRONIC: NO CHRONIC HEALTH EFFECTS ARE
EXPECTED FROM NORMAL USE.
Explanation of Carcinogenicity:NOT APPLICABLE.
Effects of Overexposure:EYES- MAY CAUSE MINOR EYE IRRITATION.
Medical Cond Aggravated by Exposure:THIS MATERIAL OR ITS EMISSIONS MAY
AGGRAVATE PRE-EXISTING EYE DISEASE.
======================= First Aid Measures =======================
First Aid:EYES- IMMEDIATELY RINSE WITH CLEAN WATER FOR 20-30 MINUTES.
RETRACT EYELIDS OFTEN. OBTAIN EMERGENCY MEDICAL ATTENTION IF PAIN,
BLINKING, TEARS OR REDNESS PERSIST. INHALATION, SKIN AND
INGESTION- NOT EXPECTED TO PRESENT A SIGNIFICANT HAZARD UNDER
ANTICIPATED CONDITIONS OF NORMAL USE. AFTER ADEQUATE FIRST AID, NO
FURTHER TREATMENT IS REQUIRED UNLESS SYMPTOMS REAPPEAR.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:=99.4C, 211.F
Autoignition Temp:=371.1C, 700.F
Lower Limits:2.4
Upper Limits:17.4
Extinguishing Media:USE CARBON DIOXIDE, ALCOHOL TYPE FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:DO NOT ENTER FIRE AREA WITHOUT PROPER
PROTECTION. FIGHT FIRE FROM SAFE DISTANCE/PROTECTED LOCATION. HEAT
MAY BUILD PRESSURE/RUPTURE CLOSED CONTAINERS, SPREADING FIRE,
INCREASING RISK OF BURNS/INJURY. USE WATER SPRAY/FOG FOR COOLING.
AVOID FROTHING/STEAM EXPLOSION. BURNING LIQUID MAY FLOAT ON WATER.
(SUPP)
Unusual Fire/Explosion Hazard:HEAT FROM FIRE CAN GENERATE FLAMMABLE
VAPOR. WHEN MIXED WITH AIR AND EXPOSED TO IGNITION SOURCE. VAPORS
CAN EXPLOSDE IF CONFINED. VAPORS MAY TRAVEL LONG DISTANCES ALONG
GROUND BEFORE IGNITING/FLASHING BACK TO VAPOR SOURCE. FINE
SPRAYS/MISTS MAY BE COMBUSTIBLE AT TEMPERATURES BELOW NORMAL FLASH
POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:SPREAD GRANULAR COVER. IMPOUND/RECOVER LARGE
LAND SPILL. SOAK UP SMALL SPILL WITH INERT SOLIDS. USE SUITABLE
DISPOSAL CONTAINERS. ON WATER, MATERIAL SOULBLE/ MAY FLOAT OR SINK.
MAY BIODEGRADE. CONTAIN /MINIMIZE DISPERSION/COLLECT. DISPERSE
RESIDUE TO REDUCE AQUATIC HARM. REPORT PER REGULATORY REQUIREMENTS.
Neutralizing Agent:NO DATA PROVIDED BY MANUFACTURER
======================Handling and Storage ======================
Handling and Storage Precautions:HYGROSCOPIC. USE DRY NITROGEN OR LOW
DEW POINT AIR FOR TANK PADDING. KEEP DRUMS TIGHTLY CLOSED TO
PREVENT CONTAMINATION STORE AT 65-90 F.
Other Precautions:DECONTAMINATION PROCEDURES: CLEAN EQUIPMENT WITH
WATER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION EQUIPMENT IS
RECOMMENDED UNDER ANTICIPATED CONDITIONS OF NORMAL USE WITH
ADEQUATE VENTILATION.
Ventilation:NO SPECIAL VENTILATION IS RECOMMENDED UNDER ANTICIPATED
CONDITIONS OF NORMAL USE BEYOND THAT NEEDED FOR NORMAL COMFORT
CONTROL.
SHIELD
Other Protective Equipment:NO DATA PROVIDED BY MANUFACTURER
Work Hygienic Practices:USE GOOD PERSONAL HYGIENE. WASH HANDS BEFORE
EATING, DRINKING, SMOKING, OR USING TOILET FACILITIES. PROMPTLY
REMOVE SOILED CLOTHING/WASH THOROUGHLY BEFORE REUSE. SHOWER AFTER
WORK.
Supplemental Safety and Health
FIREFIGHTING CONTINUED: ALTHOUGH SOLUBLE, MAY NOT BE PRACTICAL TO
EXTINGUISH FIRE BY WATER DILUTION. NOTIFY AUTHORITIES IF LIQUID
ENTERS SEWER/PUBLIC WATERS.
================== Physical/Chemical Properties ==================
HCC:V5
Boiling Pt:=185.C, 365.F
Melt/Freeze Pt:=-60.C, -76.F
Vapor Pres:< 0.1 @ 77F
Vapor Density:2.6
Spec Gravity:1.04 @ 60-90F
Viscosity:46 CPS@ 77F
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS VISCOUS LIQUID. ALMOST ODORLESS.
Percent Volatiles by Volume:SLIGHT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURE AND SEVERE OXIDIZING
CONDITIONS
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER HAZARDOUS
VAPORS/GASES.
=================== Toxicological Information===================
Toxicological Information:NO DATA PROVIDED BY MANUFACTURER.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:LANDFILL SOLIDS AT PERMITTED SITES. USE
REGISTERED TRANSPORTERS. BURN CONCENTRATED LIQUIDS, DILUTING WITH
CLEAN, LOW VISCOSITY FUEL. AVOID FLAMEOUTS. COMPLY WITH ALL
APPLICABLE FEDERAL, STATE AND LOCA L REGULATIONS. AVOID OVERLOADING
PLANT BIOMASS. ASSURE EFFLUENT COMPLIES WITH APPLICABLE STANDARDS.
=================== MSDS Transport Information ===================
Transport Information:DOT HAZARDOUS MATERIAL PROPER SHIPPING NAME: NOT
REGULATED. DOT HAZARD CLASS: NOT REGULATED. UN/NA ID NO.: NOT
APPLICABLE.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 311/312 HAZARD CATAGORIES: NONE
KNOWN TO APPLY. SECTION 313: NO CHEMICALS IN THIS PRODUCT EXCEED
THE DE MINIMUS REPORTING LEVEL ESTABLISHED BY SARA TITLE III,
SECTION 313 AND 40 CFR 372.
Federal Regulatory Information:COMPREHENSIVE ENVIRONMENTAAL RESPONSE,
COMPENSATION AND LIABILITY ACT (CERCLA): NO CHEMICALS IN THIS
PRODUCT ARE SUBJECT TO THE REPORTING REQUIREMENTS OF CERCLA.
State Regulatory Information:CALIFORNIA SAFE DRINKING WATER AND TOXIC
ENFORCEMENT ACT OF 1986 - PROPOSITION 65: BASED ON INFORMATION
CURRENTLY AVAILABLE, THIS PRODUCT IS NOT KNOWN TO CONTAIN ANY
CHEMICALS CURRENTLY LISTED AS CARC INOGENS OR REPRODUCTIVE TOXINS
UNDER CALIFORNIA PROPOSITION 65 AT LEVELS WHICH WOULD BE SUBJECT TO
THE PROPOSITION. IF YOU REFORMULATE OR FURTHER PROCESS THIS
PRODUCT, YOU SHOULD FURTHER EVALUATE THIS PRODUCT BASED UPON SUCH
REFORMULATION OR PROCESSING, AS WELL AS UPON ITS FINAL COMPOSITION
AND USE.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AMMONIUM FLUORIDE 40 % SOLUTION
CAGE:62910
CAGE:62910
============= Composition/Information on Ingredients =============
Ingred Name:AMMONIUM FLUORIDE (SARA III)
CAS:12125-01-8
RTECS #:BQ6300000
Fraction by Wt: 40.0%
OSHA PEL:2.5 MG F/M3
ACGIH TLV:2.5 MG F/M3; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:WATER;CAS #7732-18-5
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 60.0%
===================== Hazards Identification =====================
Effects of Overexposure:INH:MAY IRRIT TO RESP TRACT;ING:MAY CAUSE
SALIVATION,VOMIT DIARRHEA;SKIN/EYES;MAY IRRITATE/BURN SEV.
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR.GIVE CPR/OXYGEN IF NEEDED.CALL
MD;INGEST:DO NOT INDUCE VOMIT.GIVE LG QTY OF MILK/WATER.IMMED
TRANSPRT TO HOSP;SKIN:FLUSH W/PLENTY WATER.COVR BURN W/50-50
WATER/MGSO*4 PASTE,UNIT L HELP ARRVS;EYES:FLUSH W/H*2O.IMMED GET
MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE ANY MEANS SUITABLE FOR EXTINGUISHING
SURROUNDING FIRE.
Fire Fighting Procedures:USE H*20 TO COOL EXPD CONTRS. USE SCBA & FULL
PROT.CLTHG.
Unusual Fire/Explosion Hazard:NOT CONSIDERED TO BE AN EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA.USE PROTECTV EQUIP & RESP
PROTECTION FM VAP.DIKE & COVER ACID SPILL W/SODA ASH/LIME.CONTAIN &
RECOVER LIQ IF POSS.ABSORB W/VERMCLT,SAND/EARTH.SCOOP UP
W/NON-SPARKING TOOLS & PLACE IN CL OSED CONTNRS PENDING DISPOSAL.DO
NOT FLUSH TO SEWR
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP IN TIGHTLY CLOSED CONTNRS AT
COOL,DRY,VENTAILATED PLACE.PROTECT AGAINST PHY DAMAGE.
Other Precautions:AVOID BREATHING DUST.USE W/ADEQUATE VENTILATION.KEEP
CONTAINRS CLOSED.WASH THOROUGHLY AFTER HANDLING.AVOID SKIN,EYES &
CLOTHING CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR RESPIR/SCBA; ESCAPE: GAS MASK
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:FULL PROTECTIVE CLOTHING,SAFETY SHOWER,EYE
WASH STATION
Supplemental Safety and Health
MSDS FM MFR DATED:10/24/85 CONFORMS TO OSHA HAZ COMM STD;FIRST AID
PROCEDURES-SKIN:WASH BURN AREA.COVER W/POULTICE OF 50-50-
WATER/MGSO*4 OR 2-1/2% CALCIUM GLUCONATE PASTE THEN TRNSP TO HOSP.
================== Physical/Chemical Properties ==================
HCC:T4
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=108.9C, 228.F
Spec Gravity:1.01
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR COLORLSS LIQUID,SLIGHT CHARACTRISTC ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE WASTE LIQUID OR SOLID IN RCRA APPROVED
FACILITY.ENSURE COMPLIANCE W/LOCAL,STATE & FEDERAL REGULATIONS.
CWA/CERCLA RQ: 100 LBS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:LEXMARK PRINT CARTRIDGE 140100A
Resp. Party Other MSDS Num.:140100A
Preparer's Name:NONE LISTED
CAGE:05487
Contract Num:SPO450-99-M-C412
CAGE:79775
CAGE:05487
============= Composition/Information on Ingredients =============
Ingred Name:STYRENE ACRYLATE COPOLYMER
Minumum % Wt:50.
Maxumum % Wt:60.
Ingred Name:IRON OXIDES
Minumum % Wt:35.
Maxumum % Wt:45.
Ingred Name:POLYPROPYLENE
CAS:9003-07-0
RTECS #:UD1842000
< Wt:5.
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR. SIGNIFIGANT EXPOSURE NOT PROBABLE WITH
INTENDED USE. SKIN: TONER IS NOT AN IRRITANT & HAS LOW DERMAL
TOXICITY. SIGNIFIGANT EXPOSURE NOT PROB ABLE WITH INTENDED USE.
EYES: TONER MAYACT AS A MECHANICAL IRRITANT. INGESTED: TONER IS OF
LOW ACUTE ORAL TOXICITY. SWALLOWING EXESSIVE AMOUNTS MAY CAUSE SAME
TOXIC EFFECTS OF INGESTING ANY INSOLUBLE IRON SALTS. CHRONIC:
INHALATION OF IRON OXIDE DUSTS MAY CAUSE SIDEROSIS. RARE
INDIVIDUALS MAY NOT A SKIN RASH WITH REPEATED CONTACT. CHRONIC
EXPOSURE BY INGESTION OF IRON OXIDES MAY CAUSE CARDIOVASCUL AR,
LIVER & BLOOD COMPONENT EFFECTS.
Explanation of Carcinogenicity:NO INGREDIENTS ARE LISTED AS OSHA, NTP
OT IARC KNOWN OR POTENTIAL CARCINOGENS
Effects of Overexposure:INHALAED-RESPIRATORY IRRITATION.
EYES-IRRITATION. INGESTED (LARGE DOSES): ABDOMINAL PAIN, SEIZURES,
INCREASED HEART & BREATHING RATES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEEK MEDICAL ATTENTION IF
BREATHING BECOMES DIFFICULT. SKIN: WASH WITH SOAP & WATER. SEEK
MEDICAL ATTENTION IF IRRITATION DEVELOPES & PERSISTS. EYES: DO NOT
RUB EYES. FLUSH IMMEDIATELY WITH WATER. REMOVE CONTACT & CONTINUE
FLUSHING FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION IF
IRRITATION DEVELOPS & PERSISTS. INGESTED: IMMEDIATELY RINSE MOUTH
OUT WITH WATER. IFWITHIN 30 MINUTES & CONSCIOUS, GIVE SMALL GLASS
WATER OR MILK. IF LARGE AMOUNT INGESTED, CONTACT PHYSICIAN OR
POISON CONTROL CENTER. DO NOT INDUCE VOMITING UNLESS DIRECTED BY
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point:NP
Extinguishing Media:WATER, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:FIRE MAY PRODUCE SMALL AMOUNTS OF HAZARDOUS
DECOMPOSITION PRODUCTS SUCH AS CARBON DIOXIDE, CARBON MONOIDE, AND
UNIDENTIFIED ORGANICS
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:OCCUPATIONAL SPILL: THE VOLUME OF TONER IN A
CARTRIDGE IS MINIMAL. IF A DUST CLOUD IS PRESENT DUE TO A SPILL
INVOLVING A LARGE NUMBER OF CARTRIDGES, REMOVE ALL SOURCES OF
IGNITION SUCH AS OPEN SPARKS, FLAMES OR STATIC DISCHARGE TO
PREVENT THE IGNITION OF THE DUST. MINIMIZE DUST GENERATON DURING
CLEAN UP. SWEEP UP SPILL WITH NON-METALLIC BROOM & DUST PAN.
CONTAIN FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:TO AVOID DAMAGE TO CARTRIDGE &
ACCIDENTAL CONTACT W/TONER-KEEP OUT OF REACH OF SMALL CHILDREN.
STORE IN A COOL, DRY PLACE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MECHANICAL ROOM VENTILATION IS RECOMMENED.
Ventilation:NONE REQUIRED WITH INTENDED USE.
Other Protective Equipment:NONE REQUIRED FOR INTENDED USE IN PRINTER
Work Hygienic Practices:NONE LISTED BY MANUFACTURER.
Supplemental Safety and Health
NONE LISTED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:SOLUBILITY IS NEGLIGIBLE
Appearance and Odor:TONER IS FINELY DIVIDED BLACK POWDER WITH FAINT
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:IGNITIION SOURCES IN COMBUSTIBLE
ATMOSPHERES OF TONER DUST. THROWING TONER INTO AN OPEN FIRE.
Hazardous Decomposition Products:OXIDES OF CARBON, ACID GASES, LOW
MOLECULAR WEIGHT ORGANICS.
Conditions to Avoid Polymerization:THIS PRODUCT WILL NOT POLYMERIZE.
=================== Toxicological Information===================
Toxicological Information:ACUTE TOXICITY: NOT ACUTELY TOXIC. CHRONIC
TOXICITY: NOT EXPECTED TO BE CHRONICALLY TOXIC. LONG TERM EXPOSURE
TO EXCESSIVE CONCEENTRATIONS OF IRON OXIDE-CONTAINING DUSTS HAS
RESULTED IN ACONDITION IDE NTIFIED AS SIDEROSIS, A RELATIVELY
PNEUMOCONIOSIS, CAUSED BY DEPOSITION OF IRON PARTICLES IN THE LUNG.
INGESTION OF HIGH DOSES OF INSOLUBLE IRON SALTS MAY RESULT IN
CARDIOVASCULAR, LIVER AND BLOOD COM PONENT EFFECTS.
===================== Ecological Information =====================
Ecological:NO DATA AVAILABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARDED IN ITS PURCHASED FORM, THIS PRODUCT
WOULD NOT BE A HAZARDOUS WASTE EITHER BY LISTING OR BY
CHARACTERISTIC. IT IS THE RESPONSIBILITY OF THE PRODUCT USER TO
DETERMINE A THE TIME OF DISPOSAL WH ETHER A MATERIAL HAS BEEN
CONTAIMINATED & SHOULD BE CLASSIFIED AS A HAZARDOUS WASTE. DISPOSAL
IS SUB JECT TO LOCAL, STATE & FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:THIS MATERIAL IS NOT REGULATED AS A HAZARDOUS
MATERIAL BY THE US DOT.
===================== Regulatory Information =====================
SARA Title III Information:NONE OF THE PRODUCT INGREDIENTS ARE LISTED
AS EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT
(EPCRA)-SECTION 302: EXTREMELY HAZARDOUS SUBSTANCES (EHS). NONE OF
THE PRODUCT COMPONENTS ARE PRESENT A BOVE THE MINIMUM QUANTITIES OF
LISTED CHEMICALS IN EPCRA SECTION 313 SUPPLIER NOTIFICATION.
Federal Regulatory Information:THIS PRODUCT IS NOT LISTED OR HAZARDOUS
WASTE IN ACCORDANCE WITH FEDERAL REGULATION 40 CFR PART 261. TSCA:
ALL INGREDIENTS ARE REGISTERED UNDER THE TOXIC SUBSTANCES CONTROL
ACT (TSCA) OR UNDER POLYMER EXEMPTION.
State Regulatory Information:THIS PRODUCT CONTAINS NO KNOWN MATERIALS
WHICH THE STATE OF CALIFORNIA HAS FOUND TO CAUSE CANCER, BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM: CALIFORNIA PROPOSITION 65.
======================= Other Information =======================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:MYERSON SPECIAL C & B MODELING LIQUID
Preparer's Name:JOHN C. CRINION
CAGE:EO702
CAGE:04586
CAGE:EO702
============= Composition/Information on Ingredients =============
Ingred Name:METHYL METHACRYLATE (SARA III)
CAS:80-62-6
RTECS #:OZ5075000
Fraction by Wt: <25%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HYDROQUINONE (SARA III)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: <55% PPM
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:UNKNOWN OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE DIZZINESS,
HEADACHE, NAUSEA & LOSS OF CONSCIOUSNESS, EYE, NOSE & THROAT
IRRITATION. SKIN: MAY CAUSE ALLERGIC RASH, IRRITATION, ITCHING &
SWELLING.
Explanation of Carcinogenicity:MUTAGENIC CHANGES HAVE BEEN OBSERVED.
Effects of Overexposure:INHALATION: MAY CAUSE DIZZINESS, HEADACHE,
NAUSEA & LOSS OF CONSCIOUSNESS, EYE, NOSE & THROAT IRRITATION.
SKIN: MAY CAUSE ALLERGIC RASH, IRRITATION, ITCHING & SWELLING.
======================= First Aid Measures =======================
First Aid:INGESTION: INDUCE VOMITING & GET MEDICAL ATTENTION.
INHALATION: REMOVE TO FRESH AIR. SKIN: FLUSH WITH PLENTY OF WATER.
CALL PHYSICIAN. SKIN: WASH WITH SOAP & WATER. IF IRRITATION OCCURS,
CONTACT PHYSI CIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45F
Lower Limits:2.1%
Upper Limits:12.5%
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL OR WATER SPRAY
Fire Fighting Procedures:WEAR MESA/NIOSH APPROVED SELF-CONTAINED
BREATHING APPARATUS. USE COLD WATER SPRAY TO COOL CONTAINERS.
VAPORS MAY TRAVEL TO SOURCE OF IGNITION & FLASH BACK.
Unusual Fire/Explosion Hazard:HEAT CAN CAUSE POLYMERIZATION. HEATED,
SEALED CONTAINERS CAN EXPLODE. FIGHT FIRE FROM PROTECTED LOCATION.
EXPLOSION HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE IGNITION SOURCES. ABSORB SPILL WITH
SAND OR VERMICULITE & PLACE IN A CLOSED CONTAINER FOR DISPOSAL.
VENTILATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:DON'T INCINERATE IN CLOSED CONTAINERS.
KEEP AWAY FROM HEAT, DIRECT SUNLIGHT, SPARKS & FLAMES. KEEP
CONTAINERS CLOSED AFTER EACH USE.
Other Precautions:AVOID BREATHING VAPORS & CONTACT W/SKIN. PERMIT AIR
SPACE TO EXIST INSIDE STORAGE CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY IF GOOD VENTILATION IS MAINTAINED
Ventilation:LOCAL EXHAUST: EXPLOSION PROOF EXHAUST VENTILATION.
MECHANICAL: PROVIDE MECHANICAL VENTILATION TO KEEP <TLV
Other Protective Equipment:SAFETY SHOWER & IMPERVIOUS CLOTHING
Work Hygienic Practices:KEEP CONTAINERS CLOSED AFTER EACH USE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:214F
Vapor Pres:29
Vapor Density:3.5
Spec Gravity:0.952
Evaporation Rate & Reference:(BU AC = 1): 3
Solubility in Water:SLIGHT
Appearance and Odor:WATER-CLEAR, COLORLES LIQUID HAVING AN ACRID
IRRITATING ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING & REDUCING AGENTS. ACIDS, BASES, UV LIGHT & CONTAMINATION
Stability Condition to Avoid:HEAT, AGING, CONTAMINATION, OXYGEN, FREE
ATMOSPHERE, DIRECT SUNLIGHT, SPARKS & FLAMES.
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISCARDED, THIS MATERIAL IS A HAZARDOUS
WASTE RCRA D-001. INCINERATE LIQUID & ABSORBANT IN ACCORDANCE WITH
STATE & LOCAL EPA REGULATIONS. DON'T INCINERATE IN CLOSED
CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:N5223 YELLOW A/D ENAMEL 13538
Preparer's Name:MIKE LICHATOWICH
CAGE:02388
CAGE:02388
============= Composition/Information on Ingredients =============
Ingred Name:ALKYD RESIN SOLUTION
CAS:68459-31-4
Fraction by Wt: 48%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/STEL 200 PPM
Ingred Name:BUTYL ACETATE (VAPOR PRESSURE 10 MM HG @ 20C)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 33%
Other REC Limits:NONE SPECIFIED
OSHA PEL:150 PPM/STEL 200 PPM
ACGIH TLV:150 PPM/STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:POLYESTER/POLYAMINE COPOLYMER
Fraction by Wt: 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:ORGANOPHYLIC CLAY
CAS:71011-25-1
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
Ingred Name:COBALT COMPOUNDS (AS CO)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: < 1%
Other REC Limits:NONE SPECIFIED
OSHA PEL:0.1 MG/M3;AS CO
ACGIH TLV:0.05 MG/M3;DUST 9293
Ingred Name:PROPIETARY INGREDIENTS
Other REC Limits:NONE SPECIFIED
Ingred Name:VOC: 3.08 LB/GAL
RTECS #:9999999VO
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: SEVERE IRRITATION,
LACRIMATION, REDNESS, BLURRED VISION. SKIN: REDNESS, IRRITATION.
DEFATTING OF SKIN LEADING TO DERMATITIS. INHALE: NASAL & RESP
IRRITATION, CNS DEPRESSION. DIZZINESS, DR OWSINESS, WEAKNESS,
FATIGUE, CONFUSION.NAUSEA, HEADACHE, VERTIGO, UNCONSCIOUSNESS,
ASPHYXIATION. CHRONIC: DERMATITIS.
Effects of Overexposure:INGESTION: GASTROINTESTINAL IRRITATION,
ABDOMINAL PAIN, NAUSEA, VOMITING, DIARRHEA. TARGET ORGANS: LIVER,
KIDNEYS, EYES, SKIN, RESPIRATORY SYSTEM, CENTRAL NERVOUS SYSTEM
(CNS).
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION IMMED. SKIN: IMMED FLUSH SKIN W/WATER. IF
MATERIAL PENETRATES CLOTHING REMOVE & WASH BEFORE REUSE. GET
MEDICAL ATTENTION. EYES : IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES LIFTING EYELIDS OCCASIONALLY. GET
MEDICAL ATTENTION IMMED. INGESTION: DO NOT INDUCE VOMITING, DRINK
WATER. GET MED AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:72.0F,22.2C
Lower Limits:0.8
Upper Limits:7.6
Extinguishing Media:DRY CHEMICAL, FOAM, CO2.
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN
POSITIVE PRESSURE MODE. WATER USED TO COOL CLSD CNTNRS TO PREVENT
BUILDUP & POSSIBLE AUTO IGNITION OR EXPLO EXPOS TO HEAT
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. VAPORS > AIR
TRAVEL ALONG GRND TO AN IGNITION SOURCE. ISOLATE FM ALL HEAT TYPES.
CLSD CNTNRS MAY EXPLODE EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. DON'T BREATHE
VAPORS. AVOID SKIN CONTACT. ABSORB WITH INERT MATERIAL. SHOVEL
RECLAIMED INTO DRUMS FOR DISPOSAL. DIKE TO PREVENT FURTHER MOVEMENT
& RECLAIM INTO RECOVERY OR SALVAGE DRUMS OR TANK TRUCK FOR
DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE (TYPE TC-23C-75) PROPERLY
FITTED HALF-MASK OF FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING &
AFTER APPLICATION UNLESS AIR MONITORING KEEPS VAPOR/MIST BELOW
APPLICABLE LEVELS. FOLL OW RESPIRATOR MANUFACTURER'S DIRECTIONS.
Ventilation:SUFFICIENT VENT IN VOLUME/PATTERN TO KEEP AIR CONCENTRATION
BELOW ACGIH'S TLV LIMIT.
Other Protective Equipment:CLOTHING AS NEEDED TO PREVENT SKIN CONTACT
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
RESTROOMS. REMOVE & WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:251 TO 398F
Vapor Density:> AIR
Spec Gravity:1.050
Viscosity:70-75 KU
Evaporation Rate & Reference:< ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:42.07
Corrosion Rate:MINIMAL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRATES, ALKALIES, ACIDS.
Stability Condition to Avoid:HIGH TEMPERATURES, SHOCK FROM DROPPING.
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TECTYL 275
CAGE:72527
CAGE:0XDH2
CAGE:72527
============= Composition/Information on Ingredients =============
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES
CAS:64742-88-7
Fraction by Wt: 32-42%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: 30-40%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYLENE GLYCOL MONOBUTYL ETHER
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 10-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYE: IRRIT, STINGING, TEARS, RED,
SWELLING. SKIN: IRRIT, RED, BURNING, DRY, CRACKED, DAMAGE. INHAL:
LOW TOXICITY, HARMFUL. NOSE/THROAT/RESP TRACT IRRIT, CNS DEPRESS,
DIZZY, DROWSY, WEAK, FATIGUE, NAUS EA, HEADACHE, UNCONSCIOUS,
DEATH. INGEST: LOW TOXICITY, GI IRRIT, NAUSEA, VOMIT, DIARRHEA.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS,
ASTHMA-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:EYE: GET FRESH AIR. FLUSH W/WATER FOR 15 MIN, LIFT LIDS.
SKIN: REMOVE CONTAM CLOTHES, WASH BEFORE REUSE. WASH W/SOAP &
WATER. INHAL: GET FRESH AIR. KEEP WARM/QUIET. ARTIF RESP/OXYGEN IF
NEEDED. INGEST : DONT INDUCE VOMIT. ASPIRATION HAZARD.IF
UNCONSCIOUS/DROWSY, PLACE ON LEFT SIDE, HEAD DOWN. DONT LEAVE
UNATTENDED. GET IMMED MED AID IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:148F,64C
Lower Limits:1.0
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WATER/FOAM MAY CAUSE FROTHING. USE POSITIVE
PRESSURE SCBA W/FULL FACE PIECE/TURN-OUT GEAR/CHEMICAL RESISTANT
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL TO IGNITS.
DONT WELD, CUT ON OR NEAR FULL/EMPTY DRUM. CAN IGNITE EXPLOSIVELY,
EVEN RESIDUE.
================== Accidental Release Measures ==================
Spill Release Procedures:SM: ABSORB LIQUID & TRANSFER TO HOOD. LG:
REMOVE IGNITS. STOP SPILL. PREVENT ENTERING BODIES WATER.
PUMP/VACUUM TRANSFERRED PRODUCT TO CONTAINERS FOR RECOVERY. ABSORB
UNRECOVERABLE MATERIAL. TRANSFER CONTAM ABSORBENT/SOIL TO
CONTAINER FOR DISPOSAL.
======================Handling and Storage ======================
Handling and Storage Precautions:BOND/GROUND ALL 5 GL PAILS OR LARGER
METAL CONTAINERS INCLUDING TANK TRUCKS/CARS WHEN TRANSFERING
Other Precautions:EMPTY CONTAINERS RETAIN RESIDUE, FOLLOW ALL HAZARD
PRECAUTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURE LIMITS EXCEEDED, USE NIOSH/MSHA
APPROVED AIR SUPPLIED RESPIRATOR. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA RESPIRATORS (NEGATIVE PRESSURE TYPE) UNDER SPECIFIC
CONDITIONS.
Ventilation:SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST) TO MAINTAIN
EXPOSURE BELOW TLV.
Other Protective Equipment:IMPERVIOUS CLOTHES/BOOTS.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:315 TO 398F
Vapor Pres:0.5 @ 68F
Vapor Density:>1 AIR=1
Spec Gravity:0.864 @ 60F
pH:NODATA
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:LIQUID, NO ODOR.
Percent Volatiles by Volume:55-70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CO, CO2, VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ACCORDING TO FEDERAL, STATE, LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WET OR DRY SILVER-ZINC BATTERY,17338
Kit Part:Y
CAGE:87362
Contract Num:SP0430-00-D-0322
CAGE:87362
============= Composition/Information on Ingredients =============
Ingred Name:ZINC (SARA 313) (CERCLA)
CAS:7440-66-6
RTECS #:ZG8600000
Other REC Limits:NONE RECOMMENDED
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SILVER (SARA 313) (CERCLA)
CAS:7440-22-4
RTECS #:VW3500000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:MERCURIC OXIDE (SARA 302/313) (CERCLA)
CAS:21908-53-2
RTECS #:OW8750000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.1 MG (HG)/M3; Z-2
ACGIH TLV:S,0.025 MG(HG)/M3;95
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE WHILE DRY.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:NONE. ACUTE- NO HAZARD
IS ANTICIPATED. AFTER ADDITION OF ELECTROLYTE, POTASSIUM HYDROXIDE
MIST CAN BURN UPPER RESPIRATORY TRACT. CAN BURN EYES AND SKIN ON
CONTACT. INGESTION MAY RESULT I N SEVERE OR PERMANENT INJURY.
CHRONIC- MERCURIC OXIDE, SILVER, ZINC BIOACCUMULATE IN HUMAN
TISSUE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:NONE IN DRY STAGE. IF ELECTROLYTE IS ADDED TO
THE BATTERY AND BATTERY LEAKS OR IN FIRE, CAN CAUSE EYES, SKIN,
RESPIRATORY TRACT, MOUTH, STOMACH BURNS AND SEVERE IRRITATION.
Medical Cond Aggravated by Exposure:NOT RELEVANT
======================= First Aid Measures =======================
First Aid:NONE FOR DRY BATTERY. FOR ELECTROLYTE, GET MEDICAL ATTENTION
IMMEDIATELY. EYE/SKIN:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15
MINUTES. HOLD EYELIDS OPEN. INHALED:REMOVE TO FRESH AIR & PROVIDE
OXYGEN /CPR IF NEEDED. ORAL:DO NOT INDUCE VOMITING. IF CONSCIOUS,
DRINK LARGE AMOUNT OF WATER/MILK. CALL A PHYSICIAN IMMEDIATELY.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NOT RELEVANT
Extinguishing Media:BATTERY CASE WILL BURN. USE DRY CHEMICAL
EXTINGUISHER.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:AFTER ELECTROLYTE IS ADDED AND BATTERY IS
BEING CHARGED, HYDROGEN GAS IS PRODUCED. BATTERY MAY EXPLODE IF
HYDROGEN GAS TRAPPED INSIDE THE BATTERY CASE.
================== Accidental Release Measures ==================
Spill Release Procedures:IF BROKEN, COLLECT FOR RECOVERY. DO NOT DRY
SWEEP OR USE FORCED AIR. IF BATTERY CONTAINING ELECTROLYTE SHOULD
BREAK OPEN, NEUTRALIZE POTASSIUM HYDROXIDE WITH BORIC ACID. DO NOT
FLUSH TO SANITARY SEWER . COLLECT FOR DISPOSAL.
Neutralizing Agent:FOR ELECTROLYTE, USE BORIC ACID.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE WITH CARE. AVOID FIRE OR
INTENSE HEAT. AVOID SHORT CIRCUITING TERMINALS OF WET CELLS AND
BATTERIES.
Other Precautions:WASH HANDS BEFORE EATING OR DRINKING. KEEP OUT OF
REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. FOR DUST, FUME OR MIST, WEAR
NIOSH-APPROVED RESPIRATOR OR SELF-CONTAINED BREATHING APPARATUS.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION, EMERGENCY SHOWER
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:N1. MANUFACTURER PROVIDED 2 MATERIAL SAFETY DATA SHEETS. ONE FOR
BATTERY FLUID, PNI C, AND ONE FOR DRY OR WET BATTERY, PNI B. UNDER
NORMAL CONDITIONS OF USE OR SERVICE, THIS BATTERY DOES NOT EXPO SE
THE USER TO TOXIC FUMES. PRIOR TO USE, CARE MUST BE TAKEN FILLING A
DRY CELL WITH ELECTROLYTE (POTASSIUM HYDROXE).
================== Physical/Chemical Properties ==================
HCC:B1
NRC/State Lic Num:NOT RELEVANT
Decomp Temp:Decomp Text:NOT KNOWN
Spec Gravity:NOT RELEVANT
Viscosity:NOT RELEVANT
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:NOT RELEVANT
Appearance and Odor:PRODUCT IS A DRY BATTERY - NO ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, SOLVENTS
Stability Condition to Avoid:SHORT CIRCUTING POSITIVE AND NEGATIVE
TERMINALS
Hazardous Decomposition Products:MERCURIC OXIDE FUMES, HYDROGEN GAS
==================== Disposal Considerations ====================
Waste Disposal Methods:CELLS AND BATTERIES CONTAIN SILVER AND SHOULD BE
RECYCLED IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALL PURPOSE INSULATION
CAGE:FO261
CAGE:FO261
CAGE:75165
============= Composition/Information on Ingredients =============
Ingred Name:GLASS OXIDE, FIBER GLASS WOOL, LEAD BOROSILICATE GLASS
ENAMEL FLUX
CAS:65997-17-3
Fraction by Wt: 85-98%
Ingred Name:PHENOL, UREA, FORMALDEHYDE RESIN
CAS:25104-55-6
Fraction by Wt: 2-15%
Ingred Name:KRAFT, FOIL/KRAFT, PSK, FSK, AND VARIOUS METAL BUILDING
FACINGS
Fraction by Wt: <1-6.7%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF THE UPPER
RESPIRATORY TRACT MAY OCCUR. SKIN/EYES: TEMPORARY IRRITATION.
INGESTION: MAY CAUSE TEMPORARY IRRITATION TO THE GI TRACT/STOMACH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, SCRATCHY THROAT, COUGHING,
CONGESTION, REDNESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING CHRONIC RESPIRATORY,
SKIN/EYE DISEASES/CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. DRINK WATER TO CLEAR THROAT
& BLOW NOSE TO REMOVE FIBERS & DUSTS. SKIN: WASH GENTLY W/SOAP &
WARM WATER TO REMOVE DUST & FIBERS. WASH HANDS BEFORE EATING/USING
THE RES TROOM. INGESTION: TREAT SYMPTOMATICALLY. RINSE MOUTH
W/WATER TO REMOVE FIBERS & DRINK PLENTY OF WATER. EYES: DON'T
RUB/SCRATCH. FLUSH W/LARGE AMOUNTS OF WATER FOR 5-15 MINS. (SEE
SUPP)
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, WATER, WATER FOG, DRY CHEMICAL
Fire Fighting Procedures:USE NORMAL FIRE FIGHTING PROCEDURES TO PREVENT
INHALATION OF SMOKE & GASES.
Unusual Fire/Explosion Hazard:NO POTENTIAL FOR FIRE/EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:PICKUP LARGE PIECES. VACUUM DUSTS. IF SWEEPING
IS NECESSARY, USE A DUST SUPPRESANT SUCH AS WATER. DON'T DRY SWEEP
DUST ACCUMULATION/USE COMPRESSED AIR FOR CLEAN-UP. THESE PROCEDURS
WILL HELP TO MINIMI ZE POTENTIAL EXPOSURES.
======================Handling and Storage ======================
Handling and Storage Precautions:USE PROTECTIVE EQUIPMENT WHEN HANDLING
UNCONTAMINATED MATERIAL. WAREHOUSE STORAGE SHOULD BE IAW/PACKAGE
DIRECTIONS, IF ANY.
Other Precautions:KEEP DRY & PROTECT FROM ELEMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED DUST/MIST RESPIRATOR(3M
9900 & MOLDEX 200)/EXPOSURE EXCEEDING TEN TIMES, A NIOSH APPROVED
HALF MASK RESPIRATOR W/HEPA FILTER CARTRIDGE(MSA COMFO II W/H
CARTRIDGES & THE SURVIVAIRHALF MASK W/#1090-00 CARTRIDGES.
Ventilation:LOCAL EXHAUST TO REMOVE AIRBORNE DUST & FIBERS. GENERAL
DILUTION: TO KEEP AIRBORNE DUST & FIBERS BELOW APPLICABLE LIMITS
Other Protective Equipment:BARRIER CREAMS, LOOSE FITTING, LONG SLEEVED
CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. USE A VACUUM CLEANER BEFORE REPAIR/MAINTENANCE TO REMOVE
DUST/FIBERS.
Supplemental Safety and Health
APPEARANCE CONT'D: GOLD TO YELLOW FIBROUS GLASS BOARD, BATT,
BLANKETT/LOOSE FILL INSULATION W/W/O KRAFT, FSK/OTHER FACINGS, NO
SIGNIFICANT ODOR. FIRST AID CONT'D: OBTAIN MEDICAL ATTENTION IN ALL
CASES .
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:1300F
Solubility in Water:INSOLUBLE
Appearance and Odor:(SEE SUPP)
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:PYROLYSIS/BURNING, OF THE RESIN
Hazardous Decomposition Products:CO2, CO, CARBON PARTICLES,
FORMALDEHYDE & TRACES OF HYDROGEN CYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: JET MELT, 3792-LM-TC
Cage: 1BY21
=======================================================
Contractor Summary
=======================================================
Cage: 76381
Cage: 1BY21
=======================================================
Ingredients
=======================================================
Cas: 24937-78-8
POLYMER)
% Wt: 60-70
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 68132-00-3
% Wt: 30-40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
WHEN EMISSIONS ARE PRESENT AT ELEVATED
-----------------------------
TO CHARACT VOLATS RELS DURING JET-MELT
-----------------------------
FROM SIMULATED BRTHG ZONE OF POLYGUN USER
-----------------------------
MEASURED IN PROD'S HEAD SPACE, CHEMS WERE NOT
-----------------------------
LOWER LIMS OF ANALYTICAL DETECTION). THESE
-----------------------------
PRACTICES ARE USED. HOWEVER, CUSTOMER
-----------------------------
OCCUR. FOR THIS REASON, PROD SHOULD BE USED IN
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: YE CONT:VAPS FROM HEATED MATL MAY CAUSE IRRIT. SINGLE
EXPOS MAY CAUSE MILD IRRIT: SIGNS/SYMPS CAN INCL REDNESS, SWELL, PAIN &
TEARING. SKIN: BURNS(FROM CONT W/MOLTEN MATL: SIGNS/SYMPS MAY INCL BURNING
PAIN, RED & SWOLLEN SKIN & BLISTERS. MILD IRRIT: SIGNS/SYMPS CAN INCL
REDNESS, SWELL & ITCH. INHAL: (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:IRRIT(UPPER RESP): SIGNS/SYMPS
CAN INCL SORENESS OF NOSE & THROAT, COUGH & SNEEZING. VAPS OF HEATED
MATL MAY CAUSE RESP SYS IRRIT. INGEST:NOT LIKELY RTE OF EXPOS TO THIS PROD.
IRRIT OF GI TIS S: SIGNS/SYMPS CAN INCL PAIN, VOMITUS, ABDOM TENDERNESS,
NAUS, BLOOD IN VOMITUS & BLOOD IN FECES. OTHER HLTH HAZ(SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:IMMEDIATELY FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. GET IMMEDIATE MEDICAL ATTENTION. SKIN:IMMEDIATELY FLUSH AFFECTED
AREA W/LARGE AMOUNTS OF WATER & COVER W/CLEAN DRESSING. DO NOT ATTEMPT
TO REMOVE ADHESIVE. HAVE BURN TREATED BY MD. INHAL:REMOVE PERSON TO FRESH
AIR. IF SIGNS/SYMPTOMS CONTINUE, CALL MD. INGEST:DO NOT INDUCE VOMITING.
DRINK 2 GLASSES OF WATER. CALL MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: OBSERVE PRECAUTIONS FROM OTHER SECTIONS. COLLECT
SPILLED MATERIAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF WASTE PRODUCT IN A SANITARY LANDFILL. SINCE
REGULATIONS VARY, CONSULT APPLICABLE LOCAL, STATE & FEDERAL REGULATIONS
OR AUTHORITIES BEFORE DISPOSAL.
Handling And Storage Precautions: AVOID EYE CONTACT W/VAPOR, SPRAY OR MIST.
AVOID SKIN CONTACT W/HOT ADHESIVE & APPLICATOR TIP. AVOID PROLONGED
BREATHING OF VAPORS. DO NOT INGEST.
Other Precautions: KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point Text: >450F,>232C
Extinguishing Media: WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: NO UNUSUAL FIRE OR EXPLOSION HAZARDS ARE
ANTICIPATED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: PROVIDE APPROPRIATE LOCAL EXHAUST FOR MOLTEN OR EXTRUDED MATERIAL.
USE IN A WELL-VENTILATED AREA.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: APPEAR/ODOR:PUNGENT RESINOUS ODOR). EFTS OF
OVEREXP:INFO:EXPOS TO THIS MATL IN NORMAL STOR & HNDLG HAS NOT BEEN
REPORTED TO CAUSE SIGNIFICANT ADVERSE HLTH EFTS. HOWEVER, UNDER NORMAL
PROCESSING CNDTNS , E.G., GRINDING/HEATING, THIS PROD MAYRELS FUMES &
VAPS OF VARIABLE COMPOSITION BASED ON SPECIFIC PROCESS
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Spec Gravity: 1.01 (H*2O=1)
Solubility in Water: NIL
Appearance and Odor: WAXY SOLID, TRANSLUCENT, SOLID ADHESIVE IN RODS; ODORLESS.
(WHEN MOLTEN:(SUPDAT
Percent Volatiles by Volume: 0 (WT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products: CARBON MONOXIDE & CARBON DIOXIDE. TOXIC
VAPORS, GASES OR PARTICULATES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: JET MELT, 3792-LM-TC
Cage: 1BY21
Company Name: MINNESOTA MINING AND MFG CO ENGINEERING DOCUMENT SYSTEMS DIV
Street: 3M CTR
Zipcode: 55144-1000
Label Required IND: Y
Date Of Label Review: 10/13/1994
Status Code: C
Label Date: 10/13/1994
Origination Code: G
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:EYE CONTACT:VAPORS FROM HEATED
MATERIAL MAY CAUSE IRRITATION. SINGLE EXPOSURE MAY CAUSE MILD IRRITATION:
SIGNS OR SYMPTOMS CAN INCLUDE REDNESS, SWELLING, PAIN & TEARING.
SKIN:BURNS (FROM CONTACT W/MOLTEN MATERIAL: SIGNS OR SYMPTOMS MAY INCLUDE
BURNING PAIN, RED & SWOLLEN SKIN & BLISTERS. MILD IRRITATION: SIGNS
OR SYMPTOMS CAN INCLUDE REDNESS, SWELLING & ITCHING. INHAL:IRRITATION .
INGEST:GASTROINTESTINAL IRRITATION. CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:03-W-40 CATALYST,WHITE 17875,ISOCYANATE
Kit Part:Y
CAGE:EO418
CAGE:EO418
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 40.0%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:XYLENES (O-,M-,P- ISOMERS)(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5.0%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)
CAS:111-15-9
RTECS #:KK8225000
Fraction by Wt: 20.0%
OSHA PEL:S,100 PPM
ACGIH TLV:S, 5 PPM; 9192
Ingred Name:1,6-DIISOCYANATOHEXANE (HEXAMETHYLENE DIISOCYANATE)
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.2%
ACGIH TLV:0.005 PPM; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:BIURET OF 1,6 HEXAMETHYLENE DIISOCYANATE (APPROX <35%)
Fraction by Wt: 34.8%
===================== Hazards Identification =====================
Effects of Overexposure:EYES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS
======================= First Aid Measures =======================
First Aid:SKIN:WIPE OFF WITH A RAG THEN THOROUGH RINSING W/H+2O &
WASHING W/MILD SOAP AND WATER,EYES:FLUSH W/WATER FOR AT LEAST 10
MIN & CONSULT AN EYE PHYSICIAN;INH:REMOVE TO FRESH AIR.GIVE
CPR/OXYGEN IF NEEDE D.
===================== Fire Fighting Measures =====================
Flash Point:28F(-2.2C)-TOC
Lower Limits:1.7
Extinguishing Media:CARBON DIOXIDE,FOAM OR DRY CHEMICALS
Fire Fighting Procedures:USE SELF-CNTND BRTHNG APP;CAN USE H*2O
SPRAY/FOG EFFECTIVLY.
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURFACES & USE IN AREAS WHERE SOURCES OF IGNITION MAY BE PRESENT.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTCTD PERSONS.ELIM IGN
SOURCES.USE SAFETY EQUIP.VENTLATE AREA.STOP LEAK W/O RISK;ABSORB SM
SPILL W/OIL ABSORBING COMPD/RAGS.PER MFR,FLUSH AREA W/LF AMT
H*2O;DIKE LG SPILL.PUMP LIQ TO SALV AGE TANK.SHOVEL UP RESIDUE INTO
COVEREDCONTNRS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA.KEEP CONTNRS TIGHTLY CLOSED.PROTCT FROM PHYSICAL
DAMAGE.
Other Precautions:AVOID PROLONGED INHALATION OF VAPORS.IF VENTILATION
IS POOR,A FRESH AIR SUPPLY MASK IS RECOMMENDED.AVOID PHYSICAL
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR
PAINT,LAQUER,ENAMEL & ORGANIC VAPOR.
Ventilation:ADEQUATE USING EXHAUST FAN.
Other Protective Equipment:USE CARTRIDE TYPE RESPIRATOR W/PARTICULATE
FILTERS.
Supplemental Safety and Health
TWO PART RESIN MODIFIED POLYURETHANE COATING;ITEM WAS UNDER
MIL-C-81773.EFFECTV 80232,SPEC CANCELLED.NOW UNDER
MIL-C-83286B,TYPE I;THIS DATA DESCRIBES CATALYST; SEE P/N IND "A"
FOR BASE DATA. KEY1:F3.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175-331F
Vapor Pres:29
Vapor Density:>1.0
Spec Gravity:0.933
Evaporation Rate & Reference:<1(SLWR THAN ETHR)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR THIN WATER WHITE ORGANIC LIQUID-ODOR OF MEK
Percent Volatiles by Volume:71.1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CORROSIVE OXIDIZING MATERIALS,WATER,ALCOHOLS,ETC.
Stability Condition to Avoid:SOURCES OF IGNITION
Hazardous Decomposition Products:CO,CO*2 &/OR OXIDES OF NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:KEEP IN CLOSED CONTNRS PENDING DISPOSAL.MFR
SUGGESTED,DISPOSE IN TIGHTLY CLOSED CONTAINERS & FINALLY DISPOSE BY
SANITARY LANDFILL IAW APPLICABLE REGS;HANDLE & DISPOSE IN FULL
COMPLIANCE W/ALL FED,STAT E,& LOCAL REGULATIONS CONCERNING WASTE
DISPOSAL
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KEATING CLEANSER
CAGE:JO370
CAGE:91694
CAGE:JO370
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ; (SILICON DIOXIDE)
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:THIS MATERIAL IS IDENTIFIED AS
AN IRRITANT TO EYES AND RESPIRATORY TRACT. SCOURING POWDER IS NOT
IRRITATING TO THE SKIN AND IS NOT HARMFUL IF SWALLOWED. SIGNS AND
SYMPTOMS:EYE AND MUCOUS MEMBRAN E IRRITATION.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP, VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT
ON CARCINS. (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:AVOID CONTACT WITH EYES. AVOID
BREATHING DUST.
======================= First Aid Measures =======================
First Aid:INGESTION:CALL MD IMMEDIATELY . SKIN:FLUSH W/COPIOUS AMOUNTS
OF WATER. CALL MD . EYES:WASH WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES. INHALATION:GET MEDICAL ATTENTION IF EXCESSIVE INHAL ATION
OCCURS. REMOVE VICTIM TO FRESH AIR.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE . NO FIRE OR
EXPLOSIVE HAZARD.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE. NO FIRE OR EXPLOSIVE HAZARD.
================== Accidental Release Measures ==================
Spill Release Procedures:NORMAL CLEAN-UP PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED AREA.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DUSTY, WEAR NIOSH APPROVED MASK.
Ventilation:LOCAL EXHAUST:NATURAL.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:1994:ANTICIPATED TO BE CARCINOGEN. ANIMAL:LUNG.
================== Physical/Chemical Properties ==================
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:WHITE POWDER-ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONFORM TO STATE, FEDERAL AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACE DRAIN CLEANER, 5070
CAGE:GURDP
CAGE:2Y663
CAGE:GURDP
============= Composition/Information on Ingredients =============
Ingred Name:HYPOCHLOROUS ACID, SODIUM SALT; (SODIUM HYPOCHLORITE)
(CERCLA)
CAS:7681-52-9
RTECS #:NH3486300
Fraction by Wt: 0-5%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:POTASSIUM HYDROXIDE (CERCLA)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 0-5%
OSHA PEL:2 MG/M3, C
ACGIH TLV:2 MG/M3, C
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT WITH SKIN, EYES OR MUCOUS
MEMBRANES CAN CAUSE BURNS. EXPOSURE TO VAPORS DURING USE MAY BE
IRRITATING. SWALLOWING MAY CAUSE BURNS TO MOUTH AND THROAT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MINUTES. SKIN:REMOVE CONTAMINATED CLOTHING, FLUSH SKIN THOROUGHLY
W/W ATER. INGEST:DO NOT INDUCE VOMITING! DRINK A GLASSFUL OF MILK
OR WATER. CALL MD, POISON CONTROL CENTER OR EMERGENCY ROOM.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . NONFLAMMABLE.
Unusual Fire/Explosion Hazard:MAY REACT W/ALUMINUM GENERATING HYDROGEN
WHICH IS FLAMMABLE &/OR EXPLOSIVE IF IGNITED.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL SPILLS MAY BE WASHED DOWN DRAIN.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE ONLY IN ORIGINAL CONTAINER. READ
ALL DIRECTIONS FOR USE & CAUTIONS ON LABEL BEFORE USING. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:DO NOT USE MISTER PLUMBER IN COMBINATION W/OTHER
HOUSEHOLD CLEANERS, TOILET BOWL CLEANERS OR DRAIN CLEANERS. DO NOT
USE A PLUNGER DURING USE W/MISTER PLUMBER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE NORMALLY NEEDED. DO NOT BREATHE FUMES
GENERATED DURING USE.
Ventilation:NONE NORMALLY NEEDED.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NONE NORMALLY NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EYE PROT:& FULL LENGTH FACESHIELD .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Density:HVR/AIR
Spec Gravity:1.1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
DO NOT MIX W/OTHER HOUSEHOLD CLEANERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CHLORINE/HYDROGEN
GAS IS POSS IF MIXED W/CERTAIN TOILET BOWL CLEANERS/IF CONTACTED
W/ALUMINUM CNTNRS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . SMALL SPILLS TO SEWER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SILICA GEL FOR DESSICANT CARTRIDGE
Preparer's Name:G. RUSSELL
CAGE:11426
CAGE:11426
============= Composition/Information on Ingredients =============
Ingred Name:SILICON DIOXIDE (AMORPHOUS)
CAS:67762-90-7
Fraction by Wt: 100%
ACGIH TLV:10 MG/M3 (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:CONTACT W/SKIN & EYES MAY RESULT IN
IRRITATION. IN THE FORM OF SILICA DUST, INHALATION MAY CAUSE
IRRITATION OF EYES, NOSE & THROAT. PROLONGED INHALATION MAY RESULT
IN PNEUMOCONIOSIS & IMPAIRED PULMONA RY FUNCTION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PERSONS W/LUNG PROBLEMS MAY BE MORE
SERIOUSLY AFFECTED.
======================= First Aid Measures =======================
First Aid:EYES/SKIN:FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
INHAL:REMOVE TO FRESH AIR. INGEST:CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS
.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SWEEP UP SMALL SPILL & DISCARD IN
SOLID WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED.
Other Precautions:AVOID CONTACT W/SKIN OR EYES & BREATHING OF DUST. DO
NOT INGEST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST RESPIRATOR IF DESIRED.
Ventilation:MECHANICAL (GENERAL) IS SATISFACTORY.
Other Protective Equipment:NONE.
Work Hygienic Practices:WASH AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
HCC:N1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:ODORLESS BLUE GRANULES.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:OXIDATION.
Hazardous Decomposition Products:NONE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCARD IN SOLID WASTE. DISPOSAL MUST BE IN
ACCORDANCE W/FEDERAL, STATE & LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: 7601 CROSSLINKER
Cage: 5D028
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 5D028
Box: 997
Cage: 71984
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE:DIRECT CONTACT IRRITATES SLIGHTLY WITH REDNESS AND
SWELLING. SKIN:A SINGLE SHORT EXPOSURE (LESS THAN 24 HOURS) MAY IRRITATE.
REPEATED PROLONGED CONTACT (24-48 HOURS) MAY IRRITATE MODERATELY. INHAL
:IRRITATES RESPIRATORY PASSAGES AND EYES VERY SLIGHTLY. INGEST:SMALL AMOUNTS
TRANSFERRED TO THE MOUTH (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:BY FINGERS DURING USE, ETC.
SHOULD NOT INJURE. SWALLOWING LARGE AMOUNTS MAY CAUSE DIGESTIVE DISCOMFORT.
COMMENTS:NO KNOWN ADVERSE CHRONIC HEALTH EFFECTS, BUT UNNECESSARY EXPOSURE TO
ANY CHEMI CAL SHOULD BE AVOIDED.
Medical Cond Aggravated By Exposure: MAY ENHANCE ALLERGIC CONDITIONS.
First Aid: EYE:FLUSH IMMEDIATELY WITH WATER FOR AT LEAST 15 MINUTES. SKIN:WIPE
OFF AND FLUSH WITH WATER. GET MD IF IRRITATION DEVELOPS. INHAL:REMOVE TO
FRESH AIR. SUPPORT BREATHING (GIVE O2/ARTF RESP) (FP N); IN GEST:CALL MD
IMMEDIATELY.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN FOR
SALVAGE OR DISPOSAL. REMOVE ALL SOURCES IF IGNITION AND WEAR PROPER
PROTECTION EQUIPMENT.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE IN ACCORDANCE WITH ALL LOCAL, STATE,
AND FEDERAL REGULATIONS. CONTACT DOW CORNING IF THERE ARE ANY DISPOSAL
QUESTIONS.
Handling And Storage Precautions: KEEP CONTAINER CLOSED AND AWAY FROM HEAT,
SPARKS, AND OPEN FLAME.
Other Precautions: PRODUCT EVOLVES MINUTE QUANTITIES OF FLAMMABLE HYDROGEN GAS.
DO NOT REPACKAGE OR STORE IN UNVENTED CONTAINERS. ADEQUATELY VENTILATE THE
WORK AREA TO MAINTAIN VAPORS WELL BELOW ESTABLISHED FLAMMABILITY LIMITS AND
EXPOSURE GUIDELINES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: CC
Flash Point Text: 150F,66C
Extinguishing Media: WATER FOG, CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: VAPORS ARE HEAVIER THAN AIR AND CAN TRAVEL ALONG
THE GROUND TO REMOTE IGNITION SOURCES.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N).
Ventilation: MECHANICAL EXHAUST RECOMMENDED.
Other Protective Equipment: NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices: WASHING AT MEALTIME AND END OF SHIFT IS ADEQUATE.
REMOVE CONTAM CLTHG & SHOES AS SOON AS PRACTICAL & CLEAN (SUPP DATA)
Supplemental Safety and Health: CNDTNS TO AVOID:FLAMMABLE HYDROGEN GAS, WHICH
CAN FORM EXPLOSIVE MIXTURES IN AIR. HYGIENE PRACT:THOROUGHLY BEFORE REUSE.
GOOD PRACTICE REQUIRES THAT GROSS AMOUNT OF ANY CHEMICAL BE REMOVED FROM THE
SK IN AS SOON AS PRACTICAL. ESPECIALLY BEFORE EATING OR SMOKING.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V4
Vapor Pres: <5
Spec Gravity: 0.97
Appearance and Odor: VERY LITTLE ODOR, LIQUID, SOME COLOR
Percent Volatiles by Volume: <5(WT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: WATER, ALCOHOLS, ACIDIC OR BASIC MATLS, & MANY
METALS OR METALLIC COMPOUNDS, WHEN IN CONTACT W/PROD,LIBERATE (SUPP DATA)
Materials To Avoid: OXIDIZING MATERIAL CAN CAUSE A REACTION.
Hazardous Decomposition Products: SOX, CO2 AND TRACES OF INCOMPLETELY BURNED CO
PRODUCTS.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 25799
Product ID: 7601 CROSSLINKER
Review Date: 01/13/1992
Multiple KIT Number: 0
Review IND: Y
Additional Data: NOT REGULATED FOR TRANSPORTATION
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: 7601 CROSSLINKER
Cage: 5D028
Company Name: DOW CORNING CORP
Street: 3901 S SAGINAW RD
PO Box: 997
Zipcode: 48686-0997
Label Required IND: Y
Date Of Label Review: 11/18/1991
Status Code: C
Label Date: 11/18/1991
Origination Code: G
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: ACUTE:COMBUSTIBLE. KEEP CONTAINER CLOSED AND AWAY FROM
HEAT, SPARKS AND OPEN FLAME. DIRECT EYE CONTACT IRRITATES SLIGHTLY WITH
REDNESS AND SWELLING. A SINGLE SHORT SKIN EXPOSURE (LESS THAN 24 HOURS) M AY
IRRITATE. REPEATED PROLONGED CONTACT(24-48 HOURS) MAY IRRITATE SKIN
MODERATELY. INHALATION IRRITATES RESPIRATORY PASSAGES SLIGHTLY. SWALLOWING
LARGE AMOUNTS MAY CAUSE DIGESTIVE DISCOMFORT.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & NATURAL/SYNTHETIC RUBBER & NICKEL & STEEL
COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-C-85285B, #17038 TYPE I, 03BK071 CAT PART 2 OF 2
Kit Part:Y
Preparer's Name:MIKE SMITH
CAGE:FO129
CAGE:FO129
CAGE:33461
============= Composition/Information on Ingredients =============
Ingred Name:C8&10 AROMATIC HYDROCARBON, VAPOR PRESSURE 3 @ 68F
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 15%
Other REC Limits:NOT RECOMMENED
Ingred Name:ALIPHATIC ISOCYANATE (NOTE: 3-6MTHS STORAGE, FREE MOMOMER
CONTENT MAY RISE, MAXIMUM OF 1.6%. MOBAY CEILING LEVEL 0.02)
CAS:28182-81-2
RTECS #:NQ9170000
Fraction by Wt: 50%
Other REC Limits:0.005PPM MFR RECOMED
Ingred Name:N-BUTYL ACETATE, VAPOR PRESSURE 13 @ 68F
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NOT RECOMMENED
OSHA PEL:150PPM; STEL 200PPM
ACGIH TLV:150PPM; STEL 200PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYL N-AMYL KETONE, VAPOR PRESSURE 2.1 @ 68F
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 35%
Other REC Limits:NOT RECOMMENED
OSHA PEL:50PPM
ACGIH TLV:100PPM
Ingred Name:VOC = 490 G/L
RTECS #:9999999VO
Other REC Limits:NOT RECOMMENED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESPIRATORY TRACT & NS
DEPRESSION (HEADACHE, DIZZY, STAGGERING GAIT, CONFUSION,
UNCONSCIOUS, COMA). EYE: IRRIT, TEARING, REDNESS, SWELLING,
STINGING. SKIN: SWELLING, REDNESS, RASH. INGEST: CORR OSIVE IN THE
MOUTH, STOMACH TISSUE, DIGESTIVE TRACT. VOMIT MAY CAUSE ASPIRATION
OF SOLVENT (CHEMICAL PNEUMONITIS).
Effects of Overexposure:SKIN: DRYING, DEFATTING, CRACKING. CHRONIC:
ISOCYANATE SENSITIZATION.
Medical Cond Aggravated by Exposure:ASTHMA & OTHER RESPIRATORY
DISORDERS, SKIN ALLERGIES, ECZEMA, DERMATITIS. ISOCYANATE
SENSITIZATION.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SKIN: WASH W/SOAP & WATER. EYE:
FLUSH W/LUKEWARM WATER FOR 15 MINS. INGEST: DONT INDUCE VOMIT.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:76.0F,24.4C
Lower Limits:1.00
Upper Limits:7.90
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE EQUIPMENT. USE
WATER TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT & OTHER IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
CONTAIN & REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID HIGH TEMP & OTHER IGNITION
SOURCES. STORE IN TIGHTLY CLOSED CONTAINERS & IN WELL VENTILATED
AREA.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT. SMOKE IN SMOKING
AREAS ONLY. DONT HANDLE UNTIL MANUFACTURERS SAFETY PRECAUTIONS HAVE
BEEN READ AND UNDERSTOOD.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN AN ORGANIC VAPOR ENVIRONMENT (AIR PURIFYING
OR FRESH AIR SUPPLIED). VAPOR PARTICULATE RESPIRATOR (TC23C
NIOSH/MSHA) MAY BE APPROPRIATE WHERE AIR MONITORING DEMONSTRATES
VAPOR LEVELS BELOW TEN TIMES EXPOSURE LIMITS.
Ventilation:EXHAUST VENTILATION.
Other Protective Equipment:USE LONG SLEEVE & LEG CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING,
SMOKING, DRINKING. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
NK
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:260-335F
Vapor Density:>AIR
Spec Gravity:0.97239
pH:NA
Evaporation Rate & Reference:0.27 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:58.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WATER, AMINES, STRONG BASES, ALCOHOLS, METAL COMPOUNDS & SURFACE ACTIVE
MATERIALS.
Stability Condition to Avoid:MOISTURE, MATERIAL WHICH REACT
W/ISOCYANATES & HIGH TEMPERATURES.
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN, TRACES OF
HYDROGEN CYANIDE, HEXAMETHYLENE DIISOCYANIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE &
LOCAL REGULATIONS. EMPTY CONTAINERS HAVE PRODUCT RESIDUE &
FLAMMABLE VAPORS. DONT INCINERATE CLOSED CONTAINERS. EPA CODE:
D001, F003, F005. WASTE CHARACTERI STICS: IGNITABLE, REACTIVE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PRESSURE CAR WASH
Preparer's Name:JOEL POCHRON
CAGE:19321
CAGE:19321
============= Composition/Information on Ingredients =============
Ingred Name:SILICIC ACID (H*2SIO*3), DISODIUM SALT; (SODIUM
METASILICATE)
CAS:6834-92-0
RTECS #:VV9275000
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: INGEST:LARGE AMOUNTS MAY CAUSE
NAUSEA, VOMITING, CRAMPS & DIARRHEA. EXTREME CASES MAY CAUSE
INTERNAL HEMORRHAGE OF INTESTINES. INHAL:MAY IRRITATE UPPER
RESPIRATORY TRACT. SKIN CONTACT:CORROSIVE . CAN CAUSE MILD TO
SEVERE IRRITATION. EYE CONTACT:CAN CAUSE CHEMICAL BURNS, TEARING,
REDNESS & BLURRED VISION.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:DO NOT INDUCE VOM. GIVE FLUIDS IMMED, IF VOM OCCURS,
GIVE FLUIDS AGAIN. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCON PERS.
SEEK IMMED MED ATTN. SKIN:RINSE AREA IMMED W/WATER. IF IRRIT
PERSISTS, CO NT MD IMMED. INHAL:REMOVE TO FRESH AIR.GIVE OXYGEN IF
BRTHG IS DFCLT. EYES:FLUSH IMMED W/CONSPICUOUS AMT OF WATER FOR A
MINIMUM OF 15 MINS, LIFTING UPPER/LOWER LIDS OCCASNLY. GET IMMED
MED ATTN.
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-COMBUSTIBLE. WILL NOT SUPPORT COMBUSTION. USE
MEDIA SUITABLE FOR SURROUNDING FIRE CONDITIONS .
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NOT APPLICABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP FOR REUSE. RINSE AREA W/WATER TO
LOCAL SEWER SYSTEM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED. NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERALLY NOT REQUIRED.
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
SPEC GRAV:DENSITY=60#.FT3, (7.188 ) (H2O=1)
================== Physical/Chemical Properties ==================
Spec Gravity:SUPP DATA
Solubility in Water:15% BY WEIGHT
Appearance and Odor:WHITE GRANULAR MIXTURE.
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL IS 100% BIODEGRADABLE. DISPOSE OF IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:130 THIN SPREAD FLOOR TILE ADHESIVE
CAGE:EO927
CAGE:11761
CAGE:EO927
============= Composition/Information on Ingredients =============
Ingred Name:ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Other REC Limits:5 MG/CUM
ACGIH TLV:5 MG/CUM
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Ingred Name:PETROLEUM OIL, HYDROTREATED HEAVY NAPHTHENIC DISTILLATE
(PETROLEUM), PETROLEUM DISTILLATES, MINERAL OIL (SEVERE)
CAS:64742-52-5
RTECS #:PY8035001
Ingred Name:ALUMINUM SILICATE, BENTONITE, MONTMORILLONITE, CLAY
CAS:1302-78-9
RTECS #:CT9450000
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:1,3-BUTADIENE POLYMER, STYRENE-BUTADIENE POLYMER, SBS, SBS
(BLOCK POLYMER)
CAS:9003-55-8
RTECS #:WL6478000
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: IRRITATION. INGESTION:
GASTRIC DISTURBANCES. CHRONIC: PROLONGED/REPEATED CONTACT MAY
PRODUCE SKIN IRRITATION & INFLAMMATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYES: IRRITATION. INGESTION: GASTRIC
DISTURBANCES. CHRONIC: PROLONGED/REPEATED CONTACT MAY PRODUCE SKIN
IRRITATION & INFLAMMATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS, REMOVE CONTACT LENSES IF
WORN. SKIN: WASH EXPOSED AREA W/SOAP & WATER. INGESTION: DON'T
INDUCE VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>200F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL
Fire Fighting Procedures:DON'T ENTER ANY ENCLOSED/CONFINED FIRE SPACE
W/OUT PROPER PROTECTIVE EQUIPMENT, WHICH MAY INCLUDE SCBA.
Unusual Fire/Explosion Hazard:MATERIAL CAN SPLATTER ABOVE 212F. DRY
PRODUCT CAN BURN. FROTHING MAY OCCUR W/EXTINGUISHING MEDIA.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, SCOOP MATERIAL INTO
CONTAINER & REMOVE TO SAFE PLACE TO DRY.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID EXTREME HEAT & COLD.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. USE ONLY AS DIRECTED
ON LABEL. CLOSE CONTAINER AFTER EACH USE. DON'T REUSE CONTAINER.
AVOID SKIN & EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Ventilation:OPEN DOORS & WINDOWS & UTILIZE OTHER MEANS TO ASSURE FRESH
AIR ENTRY & EXHAUST.
Other Protective Equipment:CLEAN WATER IN WORK AREA FOR FLUSHING EYES &
SKIN.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE
REUSE. WASH W/SOAP & WATER AFTER HANDLING.
Supplemental Safety and Health
PERCENT VOLATILE VOLUME: 25-30/WT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Density:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:DISPERSIBLE
Appearance and Odor:BLACK PASTE W/PINE ODOR
Percent Volatiles by Volume:SUPP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIES & OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME HEAT & COLD, TEMP >212F.
Hazardous Decomposition Products:FUMES & SMOKE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T FLUSH ADHESIVE DOWN DRAINS. NON-PHOTOCHEMICALLY
REACTIVE ADHESIVE. UN 1133
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SMOOTHIE
CAGE:10054
CAGE:10054
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHA PETROLEUM, HEAVY ALKYLATE C9-C12 BOILING PT
302-428F *92-4*
CAS:64741-65-7
Fraction by Wt: 15-60%
OSHA PEL:100 PPM TWA
Ingred Name:NON-HAZARDOUS FOR INGREDIENTS
Fraction by Wt: 40-85%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: DISCOMFORT. INGESTION: VOMITING,
ASPIRATION HAZARD WHICH CAN RESULT IN CHEMICAL PNEUMONITIS &
PULMONARY EDEMA/HEMORRAGE.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. USE OXYGEN OR ARTIFICIAL
RESPIRATION AS REQUIRED. INGESTION: AVOID ASPIRATION OF LIQUID INTO
THE LUNGS CAN RESULT IN CHEMICAL PNEUMONITIS & PULMONARY
EDEMA/HEMORRAGE. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:600F
Extinguishing Media:DRY CHEMICAL, CO2 OR FOAM
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SELF-CONTAINED
BREATHING APPARATUS & PROTECTIVE CLOTHING. FIGHT FIRE FROM A SAFE
DISTANCE.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL SUCH AS VERMICULITE,
SAND, ETC. SWEEP UP & COLLECT IN CONTAINERS TO BE DISPOSED OF AS
SOLID WASTE. WASH AREA W/SOAP & WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE REASONABLE CARE FROM
CONTAMINATION. KEEP OUT OF REACH OF CHILDREN, ISOLATED FROM FOOD &
DRINK.
Other Precautions:SPILLS SHOULD BE WIPED OFF COMPLETELY AS THE RESIDUE
COULD BE SLIPPERY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE A NIOSH APPROVED RESPIRATOR, USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR
ORGANIC VAPORS.
Ventilation:LOCAL EXHAUST/MECHANICAL: RECOMMENDED. USE EXPLOSION PROOF
AS REQUIRED TO CONTROL VAPOR CONCENTRATION.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>375F
Vapor Pres:1
Spec Gravity:0.98
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS W/VERY SLIGHT OILY ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HEAT & OPEN FLAME
Hazardous Decomposition Products:CO, CO2, LOW MOLECULAR WEIGHT
HYDROCARBON & SILICONE DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:USE APPROVED LANDFILL OR INCINERATION. DISPOSE
OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AEROSHELL GREASE 14
CAGE:27978
CAGE:27978
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE
CAS:64742-46-7
RTECS #:JN9379645
Fraction by Wt: 20-30%
Other REC Limits:NONE SPECIFIED
Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES, HYDROTREATED LIGHT
NAPHTHENIC
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: 20-30%
Other REC Limits:NONE SPECIFIED
ACGIH TLV:5 MG/M3 (OIL MIST)
Ingred Name:SOLVENT REFINED, HYDROTREATED LIGHT PARAFFINIC DISTILLATE
CAS:64742-55-8
RTECS #:PY8036500
Fraction by Wt: 35-40%
Other REC Limits:NONE SPECIFIED
Ingred Name:CALCIUM HYDROXYSTEARATE
CAS:3159-62-4
Fraction by Wt: 10-12%
Other REC Limits:NONE SPECIFIED
Ingred Name:OTHER COMPONENTS
Fraction by Wt: <2%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE-INGESTION:NOT EXPECTED TO CAUSE
ILL EFFECTS. INHALATION:NO ADVERSE HEALTH EFFECTS EXPECTED. EYE:
IRRITATION. SKIN: NOT NORMALLY EXPECTED TO CAUSE ILL EFFECTS.
CHRONIC-PROLONGED/REPEATED SKIN CO NTACT MAY CAUSE IRRITATION,
DERMATITIS,FOLLICULITIS OIL ACNE.
Explanation of Carcinogenicity:THE COMPONENTS OF THIS PRODUCT HAVE NOT
SHOWN ANY EVIDENCE OF BEING CARCINOGENIC.
Effects of Overexposure:PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE
SKIN IRRITATION. EYE CONTACT MAY CAUSE EYE IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
AVOID PROLONGED CONTACT WHEN HANDLING OR USING THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF
UNCONSCIOUS.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:590F,310C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:RECOVER FREE PRODUCT, OR ABSORB WITH
DIATOMACEOUS EARTH OR OTHER INERT MATERIAL. STORE IN APPROPRIATE
CONTAINER FOR DISPOSAL. KEEP PRODUCT OUT OF SEWERS AND
WATERCOURSES. MINIMIZE SKIN CONTACT AND BRE ATHING VAPORS.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID STORAGE NEAR OPEN FLAME OR OTHER
SOURCES OF IGNITION,AND STRONG OXIDANTS. KEEP CONTAINERS CLOSED.
Other Precautions:EMPTY CONTAINERS RETAIN RESIDUE. DO NOT PRESSURIZE,
CUT, WELD OR EXPOSE TO HEAT, FLAME, STATIC ELECTRICITY, OR OTHER
SOURCES OF IGNITION; THEY MAY EXPLODE AND CAUSE INJURY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE SUPPLIED-AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:SUFFICIENT TO MAINTAIN ATMOSPHERE BELOW TLV LIMIT.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER. CHEMICALLY
RESISTANT BOOTS AND APRONS RECOMMENDED.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
WASH OR TAKE SHOWER IF GENERAL CONTACT OCCURS. REMOVE GREASE-SOAKED
CLOTHING AND LAUNDER BEFORE REUSE. DISCARD CONTAMINATED LEATHER
GENERATE D, OBSERVE A TWA/PEL OF 5 MG/M3 FOR MINERAL OIL MIST.
================== Physical/Chemical Properties ==================
HCC:V6
Melt/Freeze Pt:M.P/F.P Text:284F,140C
Spec Gravity:7.3
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN, SMOOTH, SLIGHT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:FUMES,SMOKE, OXIDES OF CARBON, NITRGEN
AND SULFUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:P136F37010
CAGE:00656
CAGE:00656
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP IMMEDIATELY.
INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR. AS NEEDED.INGEST:GET
MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE VOMITING,BUT DO
NOT MAKE U NCONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:KAOGUN 30
CAGE:19740
CAGE:19740
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - CRISTOBALITE
CAS:14464-46-1
RTECS #:VV7325000
Fraction by Wt: 0-15%
Other REC Limits:0.05 MG/CUM NIOSH
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.05 MG/M3 RDUST9293
Ingred Name:SILICA, CRYSTALLINE - FUSED
CAS:60676-86-0
RTECS #:VV7328000
Fraction by Wt: 0-15%
Other REC Limits:30 MG/CUM TOTAL DUST
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:PARTICULATES NOT OTHERWISE REGULATED (NUISANCE DUST)
Fraction by Wt: >80%
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST; 8990
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE DELAYED LUNG
INJRY (SILICOSIS). EYES/SKIN: MAY CAUSE TEMPORARY IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION. NUSIANCE DUST CAUSE NASAL.
THROAT/LUNG IRRITATION/DISCOMFORT MAY AGGRAVATE BRONCHIAL.
Medical Cond Aggravated by Exposure:NO
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. INGESTION: DRINK PLENTY OF
WATER. SKIN: WASH W/MILD SOAP & WATER. EYES: FLUSH W/PLENTY OF
WATER. IF IRRITATION PLERSISTS, CALL A PHYSICIAN.
================== Accidental Release Measures ==================
Spill Release Procedures:FOLLOW ROUTINE HOUSEKEEPING PROCEDURES.
COLLECT SPILLED PRODUCT IN CLOSED CONTAINER.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVAL OF THIS PRODUCT AFTER USE MAY
RESULT IN THE GENERATION OF DUST.
Other Precautions:REPEATED INHALATION OF RESPIRABLE FREE CRYSTALLINE
SILICA DUST MAY CAUSE DELAYED LUNG INJURY (SILICOSIS).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FULL FACEPIECE RESPIRATOR W/APPROPRIATE FILTER
PAD OR CARTRIDGE(S)
Ventilation:LOCAL EXHAUST AND MECHANICAL
Other Protective Equipment:AS REQUIRED TO MEET APPLICABLE OSHA
STANDARDS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.9-3.1
Solubility in Water:INSOLUBLE
Appearance and Odor:COARSE AGGREGATE W/FINE POWDERED MATRIX.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTES ARE NOT HAZARDOUS WASTES AS DEFINED BY
RCRA (40 CFR 261). COMPLY W/FEDERAL, STATE & LOCAL REGULATIONS.
METHOD OF DISPOSAL IS LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:EPK 0151 HARDENER #AB0151
Kit Part:Y
Preparer's Name:KEN DECOSTA
CAGE:33564
CAGE:33564
============= Composition/Information on Ingredients =============
Ingred Name:TRIETHYLENETETRAMINE (LD50 800MG/KG RABBIT, ORAL LD50 4340
MG/KG RAT)
CAS:112-24-3
RTECS #:YE6650000
Fraction by Wt: 10-30%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:1 PPM
Ingred Name:REACTIVE POLYAMIDE
CAS:68410-23-1
Fraction by Wt: 60-100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: PAIN. SEVERE IRRIT W/CORNEAL
INJURY, BLINDNESS, BURNS. SKIN: SEVERE BURNS. ALLERGIC REACTIONS,
CORROSIVE. ABSORPTION. INHALATION: RESPIRATORY SENSITIZATION, UPPER
RESP TRACT IRRIT. INGEST: GI IR RIT, ULCERATION, MOUTH/THROAT
BURNS.
Medical Cond Aggravated by Exposure:SKIN & EYE DISORDERS. SKIN OR LUNG
ALLERGIES MAY INCREASE. EXPOSURE AGGRAVATES PRE-EXISTING ASTHMA.
======================= First Aid Measures =======================
First Aid:EYE: IRRIGATE W/WATER >30 MIN. GET MED AID ASAP. SKIN: IMMED
FLUSH W/PLENTY OF WATER 15 MIN WHILE REMOVING CONTAM CLOTHING &
SHOES. CALL DR. WASH CLOTHING BEFORE REUSE. DESTROY CONTAM LEATHER
& SHOES WHICH CANT BE DECONTAMINATED. INGEST: DONT INDUCE VOMIT.
GIVE LARGE AMOUNT WATER/MILK. TAKE TO DR. DONT GIVE ANYTHING TO
UNCONSCIOUS PERSON. INHAL: REMOVE TO FRESH AIR. CALL DR.
===================== Fire Fighting Measures =====================
Flash Point:265F,129C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL FOR SMALL FIRES, FOAM
FOR LARGE FIRES
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:CLEANUP AND DISPOSAL SHOULD BE IN ACCORDANCE
WITH FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED
Other Precautions:AVOID SKIN AND EYE CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FRESH AIR MASK IN CONFINED SPACES.
Ventilation:LOCAL EXHAUST PREFERRED, MECHANICAL EXHAUST ACCEPTABLE.
RESPIRATORS AVAILABLE IF VENTILATION FAILS.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH.
Supplemental Safety and Health
MORE INFORMATION ON FILE
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:500F,260C
Vapor Pres:<0.01
Vapor Density:5.0
Spec Gravity:0.97
Evaporation Rate & Reference:<0.01
Solubility in Water:20%
Appearance and Odor:TRANSLUCENT AMBER, MEDIUM VISCOSITY, SLIGHT AMMONIA
ODOR
Percent Volatiles by Volume:0.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND CHLORINATED COMPOUNDS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NITROGEN OXIDES, CARBON DIOXIDE, AND
CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:NA
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PYRIDINE FREE CHLOROFORM, H7972-6
Preparer's Name:MICHAEL J. SULLIVAN
CAGE:JO299
CAGE:47125
CAGE:JO299
============= Composition/Information on Ingredients =============
Ingred Name:CHLOROFORM (SARA 302/313) (CERCLA)
CAS:67-66-3
RTECS #:FS9100000
OSHA PEL:50 PPM, C
ACGIH TLV:10 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:HEADACHE, NAUSEA, DIZZINESS,
DRUNKENNESS. CHLOROCARBON MATLS HAVE PRODUCED SENSIT OF MYOCARDIUM
TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS.
ADRENOMIMETICS (E. G., EPINEPHRINE) MA Y BE CONTRAINDICATED EXCEPT
FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOS TO
CHLOROCARBONS .
Explanation of Carcinogenicity:CHLOROFORM:IARC MONOGRAPHS, SUPP, VOL 7,
PG 152, 1987:GRP 2B. NTP 7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO
BE (SUPDAT)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMED . INHAL:REMOVE TO FRESH AIR. SUPPORT
BRTHG (GIVE O*2/ARTF RESP) . EYES:IMMED & CONTINUOUSLY FLUSH
W/FLOWING WATER FOR AT LST 15 MINS. SKIN:IMMED & CONTINUOUSLY FLUSH
W /FLOWING WATER. NOTE TO MD:OVEREXP TO MANY OF CHLORINATED SOLVS,
ESP IF ACCOMPANIED BY ANOXIA, MAY TEMPORARILY INCR CARDIAC
IRRITABILITY. MAINTAIN ADEQ OXYGENATION UNTIL RECOVERY. AVOID (SUPP
DATA)
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD PRESS DEMAND SCBA & FULL
PROT EQUIP . SLIGHT FIRE HAZARD WHEN EXPOSED TO HIGH HEAT:
OTHERWISE PRACTICALLY NON-FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE W/REASONABLE CARE. AVOID
BREATHING VAPORS.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT &/OR UV
RADIATION MAY CAUSE FORMATION OF HCL &/OR PHOSGENE .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN AREAS OF HIGH CONCENTRATION, WEAR NIOSH/MSHA
APPROVED SELF CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST &/OR MECHANICAL (GENERAL).
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:CARCINOGEN. ANIMAL:LIVER/KIDNEY TUMORS, CNS EFTS.
FIRST AID PROC:SYMPTOMINETIC AMINES, SUCH AS EPINEPHRINE, WHICH MAY
PRECIPITATE ARRHYTHMIAS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:142F,61C
Melt/Freeze Pt:M.P/F.P Text:-82F,-64C
Vapor Pres:160 @ 20C
Vapor Density:4.13
Spec Gravity:1.49
Solubility in Water:INSOLUBLE
Appearance and Odor:COLORLESS LIQUID; ETHEREAL ODOR.
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CAUSTIC SODA ASH & OTHER STRONG BASES (VIOLENT EXOTHERMIC RXN),
ALUMINUM & HOT METALS.
Hazardous Decomposition Products:HCL, PHOSGENE .
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:AVESTA MANUAL METAL ARC WELDING ELECTRODES, -15
CAGE:54649
CAGE:54649
============= Composition/Information on Ingredients =============
Ingred Name:CHROMIUM (SARA 313) (CERCLA)
CAS:7440-47-3
RTECS #:GB4200000
Fraction by Wt: 2.35%
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (CU) (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 0-4%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:IRON (FE)
CAS:7439-89-6
RTECS #:NO4565500
Fraction by Wt: BALANCE
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:MANGANESE (MN) (SARA 313)
CAS:7439-96-5
RTECS #:OO9275000
Fraction by Wt: 1-10%
OSHA PEL:C 5 MG/M3 DUST
ACGIH TLV:5 MG/M3 DUST
Ingred Name:MOLYBDENUM (MO)
CAS:7439-98-7
RTECS #:QA4680000
Fraction by Wt: 1-16%
OSHA PEL:10 PPM
ACGIH TLV:10 PPM
Ingred Name:NICKEL (NI) (SARA 313) (CERCLA)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 0.1-0.5%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:NIOBIUM (NB) (ALSO CALLED COLUMBIUM)
CAS:7440-03-1
RTECS #:QT9900000
Fraction by Wt: 0.5-5%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:POTASSIUM (METAL (K))
CAS:7440-09-7
RTECS #:TS6460000
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SILICON (SI)
CAS:7440-21-3
RTECS #:VW0400000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:SODIUM (NA) (CERCLA)
CAS:7440-23-5
RTECS #:VY0686000
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 1-10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CALCIUM FLUORIDE (AS F)
CAS:7789-75-5
RTECS #:EW1760000
Fraction by Wt: 1-25%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SODIUM ALUMINUM FLUORIDE (NA*3ALF*6)
CAS:15096-52-3
RTECS #:WA9625000
Fraction by Wt: 1-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 1-20%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:CARBON DIOXIDE (CO2)
CAS:124-38-9
RTECS #:FF6400000
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL
Ingred Name:CARBON MONOXIDE (CO)
CAS:630-08-0
RTECS #:FG3500000
OSHA PEL:50 PPM
ACGIH TLV:25 PPM
Ingred Name:NITROGEN TETROXIDE; (NITROGEN DIOXIDE, DI) (CERCLA)
CAS:10544-72-6
RTECS #:QX1575000
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITROGEN MONOXIDE; (NITRIC OXIDE) (SARA 302)
CAS:10102-43-9
RTECS #:QX0525000
OSHA PEL:25 PPM
ACGIH TLV:25 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NITROGEN DIOXIDE (SARA 302)
CAS:10102-44-0
RTECS #:QW9800000
OSHA PEL:C 5 PPM
ACGIH TLV:3 PPM/5 STEL
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:HYDROFLUORIC ACID; (HYDROGEN FLUORIDE) (SARA 302/313)
(CERCLA)
CAS:7664-39-3
RTECS #:MW7875000
OSHA PEL:3 PPM (F)
ACGIH TLV:C 3 PPM(F)
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:OZONE (SARA 302)
CAS:10028-15-6
RTECS #:RS8225000
OSHA PEL:0.1 PPM
ACGIH TLV:C 0.1 PPM
Ingred Name:PHOSGENE (CARBONYL CHLORIDE) (SARA 302/313) (CERCLA)
CAS:75-44-5
RTECS #:SY5600000
OSHA PEL:0.1 PPM
ACGIH TLV:0.1 PPM
Ingred Name:PHOSPHITE
CAS:7803-81-2
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: ELEC ARC WELDING MAY CREATE
ONE/MORE OF THE FOLLOWING HLTH HAZ: FUMES & GASES CAN BE DANGEROUS
TO YOUR HLTH. SHORT-TERM OVEREXP TO WELDING FUMES MAY RSLT IN
DISCOMFORT SUCH AS DIZZ, NAUS/DRYNES S/IRRIT OF NOSE, THROAT/EYES.
CHRONIC: OVEREXP TO WELDING FUMES CAN LEAD TO SIDEROSIS (IRON PRODS
IN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL: IARC MONO ON EVAL OF CARCIN RISK
OF CHEMS TO MAN, VOL 49, PG 257, 1990: GROUP 2B. NTP 7TH ANNUAL RPT
ON(SUP DAT)
Effects of Overexposure:HLTH HAZ: LUNGS) & BELIEVED BY SOME INDIVIDUALS
TO AFFECT PULM FUNC. ARC RAYS CAN INJURE EYES & BURN SKIN. ELEC
SHOCK CAN KILL. CARBON MONOXIDE APPEARS ON THE NAVY OCCUP CHEM
REPRO HAZ LIST. SEEK CONS ULT FROM APPROP HLTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS .
Medical Cond Aggravated by Exposure:AGGRAVATION OF RESPIRATORY OR
ALLERGIC CONDITIONS MAY AFFECT SOME EXPOSED INDIVIDUALS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE AND CALL FOR MEDICAL AID.
EMPLOY FIRST AID TECHNIQUE RECOMMENDED BY THE AMERICAN RED CROSS.
EYES: FLUSH WITH POTABLE WATER FOR AT LEAST 15 MINUTES. SEE MD .
SKIN : FLUSH WITH COPIOUS AMOUNTS OF WATER. SEE MD . INGESTION:
CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Extinguishing Media:NON-FLAMMABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:WELDING ARC & SPKS CAN IGNITE COMBUSTS &
FLAMMS. REFER TO AMERICAN NATIONAL STANDARD Z49.1 FOR FIRE
PREVENTION DURING THE USE OF WELDING AND ALLIED PROCEDURES.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ AND UNDERSTAND THE MANUFACTURER'S
INSTRUCTIONS AND THE PRECAUTIONARY LABEL ON THE PRODUCT.
Other Precautions:TRAIN EACH WORKER TO KEEP HIS/HER HEAD OUT OF THE
FUMES. TRAIN EACH WELDER NOT TO TOUCH LIVE ELECTRICAL PARTS AND TO
INSULATE HIS/HER PERSON FROM WORK AND GROUND.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRABLE FUME RESPIRATOR OR
AIR-SUPPLIED RESPIRATOR WHEN WELDING IN CONFINED SPACE OR WHERE
LOCAL EXHAUST OR VENTILATION DOES NOT KEEP EXPOSURE BELOW TLV/PEL.
Ventilation:USE ENOUGH VENT, LOC EXHST AT ARC/BOTH, TO KEEP FUMES &
GASES BELOW TLV/PEL IN WORKER'S BRTHG ZONE & GEN AREA.
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
ARM PROTECTORS, APRONS, HATS, SHOULDER PROT, & DARK SUBSTANTIAL
CLTHG.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
APPEAR/ODOR: CONSUMIBLES CONSISTING OF SOLID CORE W/FLUX COATING.
EXPLAN OF CARCIN: CARCINS, 1994: ANTIC TO BE CARCIN. HUMAN: LUNGS.
HAZ DECOMP PROD: WELDED & PROCESS, PROC, & ELECTRODES USED. CONTACT
NEHC FOR MORE SPECIFIC INFORMATION
================== Physical/Chemical Properties ==================
Appearance and Odor:CHROMIUM-NICKEL & NICKEL ALLOY COATED ELECTRODES
ARE WELDING (SUP DAT)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:WELDING FUMES & GASES CANNOT BE
CLASSIFIED SIMPLY. COMPOSITION & QTY OF BOTH ARE DEPENDENT UPON
METAL BEING (SUP DAT)
==================== Disposal Considerations ====================
Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING THE SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSABLE CONTAINER OR
LINER IN AN ENVIRONMENTALLY ACCEPTABLE MANNER, IN FULL COMPLIANCE
WITH FEDERAL, STAT E AND LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEMAND CS - CALIFORNIA
Resp. Party Other MSDS Num.:US004666_01
CAGE:0X6X4
Contract Num:SP0450-00-M-D982
CAGE:64184
CAGE:0X6X4
============= Composition/Information on Ingredients =============
Ingred Name:LAMBDA-CYHALOTHRIN TECHNICAL
CAS:91465-08-6
= Wt:9.7
Ingred Name:OTHER INGREDIENTS
= Wt:90.3
Ingred Name:1,2,4-TRIMETHYLBENZENE
CAS:95-63-6
RTECS #:DC3325000
< Wt:5.
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50 >5000 MG.KG
Health Hazards Acute and Chronic:IRRITANT (EYE, SKIN, RESPIRATORY
PASSAGES, SKIN SENSITIZER). INHALATION (TLV) HARMFUL (ORAL) BASED
ON THE AROMATIC PETROLEUM SOLVENT - IRRITANT (SKIN), HARMFUL
(CENTRAL NERVOUS SYSTEM DEPRESSION, GAST ROINTESTINAL DISTURBANCE).
Explanation of Carcinogenicity:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Effects of Overexposure:INGESTION (HYDROCARBON SOLVENT WITHIN
MICROCAPSULE): SEVERE GASTROINTESTINAL DISTURBANCE, CNS DEPRESSION
(DROWSINESS, DIZZINESS, LOSS OF COORDINATION, FATIGUE); ASPIRATION
OF VOMITUS MAY CAUSE LUNG CO NGESTION, LABORED BREATHING, COMA,
POSSIBLE DEATH.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY RESPONSIBLE
PARTY.
======================= First Aid Measures =======================
First Aid:EYES:IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES.IF
REDNESS,ITCHING OR A BURNING SENSATION DEVELOPS,HAVE EYES EXAMINED
BY MEDICAL PERSONNEL.SKIN:WASH MATERIAL OFF WITH PLENTY OF SOAP &
WATER. IF REDNESS,ITCHING OR BURNING SENSATION DEVELOPS,GET MEDICAL
ATTENTION.INHALED:REMOVE VICTIM TO FRESH AIR.IF NOT BREATHING,GIVE
ARTIFICIAL RESPIRATION. IF BREATHING LABORED,GIVE OXYGEN.CONSULT
MEDICAL PERSONNEL.IF CONSCIOUS,WASH MOUTH WITH WATER.IMMEDIATELY
CONTACT ZENECA AT 1-800-327-8633.INDUCE VOMITING ONLY UNDER MEDICAL
GUIDANCE.IF VOMITING OCCURS,PUT HEAD DOWN BELOW WAIST. IMMEDIATELY
TRANSPO RT TO EMERGENCY MEDICAL FACILITY.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>100.C, 212.F
Autoignition Temp:Autoignition Temp Text:N/DATA
Lower Limits:NO DATA
Upper Limits:NO DATA
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, DRY
CHEMICAL, HALOGENATED AGENTS.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPRATUS WITH FULL
FACEPIECE AND PROTECTIVE CLOTHING. KEEP FIRE EXPOSED CONTAINER COOL
WITH WATER SPRAY TO PREVENT RUPTURE FOR EXCESSIVE HEAT. HIGH
PRESSURE WATER HOSE MAY SPR EAD PRODUCT INCREASING CONTAMINATION OR
FIRE HAZARD. CONTAIN RUN-OFF.
Unusual Fire/Explosion Hazard:PRODUCT MAY SUPPORT COMBUSTION AFTER
WATER CONTENT BOILED OFF (AS IN A FIRE). HEATING WILL GENERATE
TOXIC VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:WEAR SUITABLE PERSONAL PROTECTIVE CLOTHING &
MATERIAL TO ENTER STREAMS,SEWERS OR OTHER WATERWAYS. SPREAD
SUITABLE ABSORBENT ON THE SPILL & SHOVEL INTO OPEN DRUM.COVER
CONTAMINATED AREA WITH COMMON HOUSEHOLD DETERGENT.USE STIFF BRUSH &
WATER WATER,BRUSH AREA THEN LET STAND 2-3 MINUTES,SPREAD ABSORBENT
INTO SLURRY THEN SHOVEL INTO DRUM.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTAINERS SHOULD BE STORED IN A COOL,
DRY, WELL-VENTILATED AREA AWAY FROM FLAMMABLE MATERIALS AND SOURCES
OF HEAT OR FLAME. EXERCISE DUE CAUTION TO PREVENT DAMAGE TO OR
LEAKAGE FROM THE CONTAINER. DO NOT STORE NEAR FEED, FOOD, OR
WITHIN THE REACH OF CHILDREN.
Other Precautions:EMPTY CONTAINER RETAINS PRODUCT RESIDUE. OBSERVE ALL
HAZARD PRECAUTIONS. DO NOTREUSE EMPTY CONTAINER EXCEPT FOR
STORAGE OR SHIPMENT OF ORIGINAL PRODUCT. REMOVE ALL PRODUCT RESIDUE
FROM CONTAINER & P UNCTURE OR OTHERWISE DESTROY EMPTY CONTAINER AND
PUNCTURE OR OTHERWISE DESTROY EMPTY CONTAINER BEFOR E DISPOSAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF NEEDED, USE MSHA-NIOSH APPROVED RESPIRATOR
FOR PESTICIDES.
Ventilation:USE VENTILATION ADEQUATE TO MAINTAIN SAFE LEVELS. IF
NEEDED, USE LOCAL EXHAUST TO MAINTAIN AIRBORNE CONCENTRATIONS BELOW
THE TLV.
Other Protective Equipment:THIS PRODUCT IS FIFRA REGULATED. REFER TO
PRODUCT LABELING FOR END-USER PERSONAL PROTECTION REQUIREMENTS.
WEAR IMPERVIOUS FOOTWEAR, LONG-SLEEVED CLOTHING AND WIDE BRIMMED
HAT.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING AND WASH BEFORE
RE-WEARING. WASH SEPARATELY FROM OTHER LAUNDRY.
Supplemental Safety and Health
AN ADEQUATE SUPPLY OF CLEAN POTABLE WATER SHOULD BE AVAILABLE TO ALLOW
THOROUGH FLUSHING OF SKIN AND EYES IN THE EVENT OF CONTACT WITH
THIS COMPOUND.
================== Physical/Chemical Properties ==================
HCC:T5
Boiling Pt:>100.C, 212.F
Vapor Pres:1.5 X 10E-9 @ 20C
Vapor Density:NO DATA
pH:7.3
Solubility in Water:DISPERSIBLE
Appearance and Odor:OFF-WHITE LIQUID; SLIGHT ODOR TYPICAL OF AROMATIC
PETROLEUM SOLVENT
Percent Volatiles by Volume:NO DATA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
NITROGEN OXIDES, AMMONIA. TRACE AMOUNTS OF HYDROGEN CYANIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:LD 50 INGESTION RAT, > 5000 MG/KG, MATERIAL
IS CLASSIFIED AS "VERY LOW TOXICITY" BY INGESTION. IN HUMANS,
INGESTION OF SOLVENT MAY CAUSE SEVERE GASTROINTESTINAL DISTURBANCE,
CNS DEPRESSION (DROWSINESS , DIZZINESS, LOSS OF COORDINATION,
FATIGUE); ASPIRATION OF VOMITUS MAY CAUSE LUNG CONGESTION, LABORED
BREATHING, COMA, POSSIBLE DEATH.LC50 INHALATION RAT, > 4.62 MG/L,
THIS MATERIAL IS CLASSIFIED AS " MODERATELY TOXIC" BY INHALATION.
AT HIGH CONCENTRATIONS, VAPORS OR AEROSOLS OF THE SOLVENT CAN
PRODUCE RESPIRATORY AND CNS DEPRESSION, HEADACHE, DIZZINESS &
NAUSEA.
===================== Ecological Information =====================
Ecological:NO DATA PROVIDED BY RESPONSIBLE PARTY.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT CONTAMINATE WATERWAYS BY CLEANING OF
EQUIPMENT OR BY DISPOSAL OF WASTES. UNTREATED EFFLUENT SHOULD NOT
BE DISCHARGED WHERE IT WILL DRAIN INTO WATERWAYS. DISCARDED PRODUCT
IS NOT A HAZARDOUS WAS TE UNDER RCRA, 40 CFR 261.
=================== MSDS Transport Information ===================
Transport Information:ROAD TRANSPORT DOT: NOT REGULATED BY DOT.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 313 SUPPLIER NOTIFICATION: THIS
PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACTE O F 1986 (EPCRA) AND OF 40 CFR 372:
<5% 1,2,4-TRIMETHYLBENZENE (CAS# 95-63-6).
Federal Regulatory Information:EPA REGISTRATION NUMBER: 10182-361. TSCA
(TOXIC SUBSTANCE CONTROL ACT) REGULATIONS, 40 CFR 710: THIS PRODUCT
IS A PESTICIDE AND IS EXEMPT FROM TSCA REGULATION.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
CONTAINS A TRACE AMOUNT OF CRYSTALLINE SILICA, A COMPOUND WHICH IS
FOUND ON CALIFORNIA'S PROPOSITION 65 LIST. WHEN USED ACCORDING TO
LABEL DIRECTIONS, EXPOSUREIS BELOW THE LEVEL WHICH REQUIRES A
PROPOSITION 65 WARNING OR POSTING.
======================= Other Information =======================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:BUFFER POWDER PILLOWS, CITRATE TYPE, FOR MANGANESE
CAGE:91224
CAGE:91224
CAGE:4T252
CAGE:7Z016
CAGE:NO672
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM PHOSPHATE, DIBASIC (SARA III)
CAS:7558-79-4
RTECS #:WC4500000
Fraction by Wt: <55%
Other REC Limits:NONE SPECIFIED
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:CITRIC ACID,MONOHYDRATE
CAS:77-92-9
RTECS #:GE7350000
Fraction by Wt: <25%
Other REC Limits:NONE SPECIFIED
Ingred Name:SODIUM SULFATE,ANHYDROUS
CAS:7757-82-6
RTECS #:WE1650000
Fraction by Wt: <35%
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY BE IRRITATING TO EYES, SKIN &
RESPIRATORY TRACT. MAY CAUSE G/I IRRITATION, VOMITING, LETHERGY,
DIARRHEA, FEVER, FLUID LOSS, FALL IN BLOOD PRESSURE AND MAY IMPAIR
THE BODY'S ABILITY TO ABSORB CALCI UM.
Explanation of Carcinogenicity:MANUFACTURER GAVE NO INFORMATION ABOUT
CARCINOGENICITY. HMIS FOUND NO LISTING & DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, RESPIRATORY
TRACT IRRITATION, VOMITING, LETHERGY, DIARRHEA, FEVER, FLUID LOSS,
FALL IN BLOOD PRESSURE.
Medical Cond Aggravated by Exposure:NONE REPORTED
======================= First Aid Measures =======================
First Aid:EYES & SKIN:IMMEDIATELY FLUSH EYES W/WATER FOR 15 MINUTES.
CALL PHYSICIAN. FLUSH SKIN W/PLENTY OF WATER. INGESTION:GIVE LARGE
QUANTITIES OF WATER. CALL PHYSICIAN IMMEDIATELY. INHALATION:REMOVE
TO FRES H AIR.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:N/A.
Lower Limits:N/A.
Upper Limits:N/A.
Extinguishing Media:WATER
Fire Fighting Procedures:MFR GAVE NO INFORMATION OF MSDS.
Unusual Fire/Explosion Hazard:MAY EMIT TOXIC FUMES IN FIRE. CLOSED
CONTAINERS MAY EXPLODE IF EXPOSED TO HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP POWDER. AVOID BREATHING MATERIAL.
DISSOLVE IN WATER. FLUSH DOWN THE DRAIN W/EXCESS WATER.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:PROTECT FROM LIGHT.
Other Precautions:AVOID CONTACT W/EYES & SKIN. DO NOT BREATHE DUST.
WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MFR GAVE NO INFORMATION OF MSDS.
Ventilation:ADEQUATE VENTILATION
Other Protective Equipment:EMERGENCY EYEWASH STATION AND SHOWER
Work Hygienic Practices:MFR GAVE NO INFORMATION OF MSDS.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:N/A.
Melt/Freeze Pt:M.P/F.P Text:320F,160C
Vapor Pres:N/A.
Vapor Density:N/A.
Spec Gravity:2.3
pH:6.35
Evaporation Rate & Reference:N/A.
Solubility in Water:SOLUBLE
Appearance and Odor:WHITE CRYSTALLINE POWDER, NO ODOR
Corrosion Rate:0.022 AL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR GAVE NO INFORMATION OF MSDS.
Stability Condition to Avoid:HEAT, FLAMES, EXPOSURE TO MOISTURE
Hazardous Decomposition Products:TOXIC SUMES OF PHOSPHORUS, SULFUR,
CARBON AND SODIUM OXIDES
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE & LOCAL
REGULATIONS.
======================================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Preparer's Name:DOD HMIS/DGSC-SSH
CAGE:JO772
CAGE:14153
CAGE:JO772
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9192
Ingred Name:ASBESTOS & SYNTHETIC RUBBER COMPOSITION
RTECS #:9999999ZZ
Ingred Name:GENERIC "MSDS". SPECIFIC ASBESTOS TYPE NOT KNOWN. ONE
CITED IS ASSUMED. INFORMATION BASED ON SEGMENT "M" OF "DLSC TIR"
RTECS #:9999999ZZ
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: NO ACUTE EFFECTS ARE KNOWN;
CHRONIC: DUST FROM ABRASIVE ACTIONS(EG. CUTTING, MACHINING,
FILING, ETC.) MAYCONTAIN ASBESTOS FIBERS. CHRONIC OVEREXPOSURE
TO AIRBORNE FIBERS MAY LEAD TO ASBESTOSIS & MESOTHELIOMA.
SMOKINGCOMBINED W/FIBER INHALATION GREATLY INCREASES LUNG
CANCER RISK!
Explanation of Carcinogenicity:OVEREXPOSURE TO AIRBORNE CONCENTRATIONS
OF ASBESTOS MAY LEAD TO ASBESTOSIS AND MESOTHELIOMA.
Effects of Overexposure:INHAL: INHALATION OF AIRBORNE DUST CONTAINING
ASBESTOS FIBERS ON REPEATED EXPOSURE MAY CAUSE OR CAN LEAD TO
ASBESTOSIS/ MESOTHELIOMA; SKIN: N/K; EYE: POTENTIAL IRRITATION
FROM AIRBORNE DUST; INGEST: N/K.
Medical Cond Aggravated by Exposure:RESPIRATORY DEFICIENCIES DUE TO
REPEATED INHALATION OF AIRBORNE FIBERS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. OBTAIN MEDICAL ADVICE; SKIN:
WASH EXPOSED AREA WITH SOAP & WATER; EYE: FLOOD W/ WATER. IF
IRRITATION OCCURS, GET MEDICAL ATTN; INGEST: CONSULT A
PHYSICIAN; OTHER: CHANGE CLOTHING AS REQUIRED TO AVOIDCARRYING
DUST PARTICLES INTO OTHER AREAS
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:MATERIAL IS NOT FLAMMABLE ; USE MEDIA APPROPRIATE
FOR SURROUNDING FIRE.
Fire Fighting Procedures:COMBUSTION PRODUCTS OF THIS MATERIAL MAY BE
TOXIC. USE A SELF-CONTAINED BREATHING APPARATUS WHEN FIGHTING FIRES
INVOLVING CHEMICAL PRODUCTS.
Unusual Fire/Explosion Hazard:NONE KNOWN
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION. VACUUM OR WET
CLEAN IF DUST IS INVOLVED. ANY VACUUM SYSTEM SHOULD BE EQUIPPED W/
AN OUTLET "HEPA" FILTER TO PREVENT REINTRODUCING ASBESTOS FIBERS TO
THE ATMOSPHERE.
======================Handling and Storage ======================
Handling and Storage Precautions:HANDLE IN A MATTER TO MINIMIZE
FORMATION OR RETENTION OF AIRBORNE DUST. USE PROPER PERSONAL
PROTECTION FOR TASK AT HAND. CHECK W/YOUR SAFETY OFFICE!!!
Other Precautions:AS MANUFACTURED, LOCKED-IN ASBESTOS DOES NOT PRESENT
A HAZARD. ONLY WHEN THE ITEM IS SUBJECTED TO ABRASIVE ACTIONS &
DUST IS GENERATED, THEN ASBESTOS FIBERS MAY BE RELEASED & BECOME
AIRBORNE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF EXPOSURES EXCEED ESTABLISHED LIMITS, A
NIOSH/MSHA APPROVED RESPIRATOR FOR ASBESTOS SHOULD BE USED.
CONSULT YOUR SAFETY OFFICE/IH PERSONNEL FOR GUIDANCE FOR THE TASK
AT HAND.
Ventilation:LOCAL EXHAUST IS RECOMMENDED IN SITUATIONS WHERE DUST IS
GENERATED BY ABRASIVE ACTIONS, ABRASION OR OTHER MEANS.
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND, AND THE
GUIDANCE SET FORTH BY YOUR SAFETY OFFICE OR IH PERSONNEL
Work Hygienic Practices:DONOT INHALE DUST CREATED BY ABRADING ACTIONS.
USE FULL PROTECTION AGAINST AIRBORNE FIBERS. AVOID AIRBORNE DUST
CREATION
Supplemental Safety and Health
GENERIC "MSDS" CREATED FOR "NSN" IDENTIFIED BY "DISC" AS CONTAINING
ASBESTOS.WHEN A MANUFACTURER'S SPECIFIC "MSDS" IS PROVIDED FOR
MATERIAL PROCURED UNDER THIS NSN, THIS GENERIC "MSDS" WILL BE
REMOVED.
================== Physical/Chemical Properties ==================
HCC:T6
Evaporation Rate & Reference:NONE
Solubility in Water:NOT SOLUBLE
Appearance and Odor:MANUFACTURED COMMODITY DESCRIBED BY LOGISTICS:
"ITEM-NAME"
Percent Volatiles by Volume:NONE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN
Stability Condition to Avoid:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:DUST SHOULD BE HANDLED AS A HAZARDOUS AIR
POLLUTANT I/A/W 40CFR61 SUBPART "M" PERTAINING TO ASBESTOS. USE
LANDFILLS APPROVED FOR ASBESTOS DISPOSAL. NOTE IF ITEM UNDER
CONSIDERATION FOR DISPOSAL IS "FRIABLE OR NON-FRIABLE".
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ICRONIBSI 13 (PWA-996) BRAZE ALLOYS
CAGE:UO704
CAGE:UO704
============= Composition/Information on Ingredients =============
Ingred Name:BORON
CAS:7440-42-8
RTECS #:ED7350000
= Wt:2.9
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:CHROMIUM
CAS:7440-47-3
RTECS #:GB4200000
= Wt:13.
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:IRON
CAS:7439-89-6
RTECS #:NO4565500
= Wt:4.
Ingred Name:NICKEL
CAS:7440-02-0
RTECS #:QR5950000
= Wt:75.6
OSHA PEL:1 MG/M3
ACGIH TLV:0.5 MG/M3
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:SILICON
CAS:7440-21-3
RTECS #:VW0400000
= Wt:4.5
ACGIH TLV:15 MG/M3
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:THE ALLOYS IN SOLID FORM ARE GENERALLY
NOT CONSIDERED HAZARDOUS. HOWEVER, IF YOUR PROCESS INVOLVES
GRINDING, MELTING, WELDING, CUTTING, OR OTHER PROCESSES THAT CAUSE
A RELEASE OF DUST OR FUME, THEN HA ZARDOUS LEVELS OF DUST OR FUME
OF CONSTITUENTS OF THESE ALLOYS CAN CAUSE ACUTE TOXICITY. TARGET
ORGANS: EYE, SKIN AND RESPIRATORY SYSTEM.
Explanation of Carcinogenicity:SOME OF THE PRODUCT'S INGREDIENTS ARE
FOUND ON THE FEDERAL OSHA Z LIST, NTP, CAL/OSHA OR IARC. CHROMIUM,
COBALT-CHROMIUM ALLOYS, & NICKEL HAVE BEEN IDENTIFIED BY IARC &/OR
NTP AS POTENTIAL CANCER CAUS ING AGENTS.
Effects of Overexposure:USER GENERATED DUST & FUMES MAY ON CONTACT WITH
THE SKIN OR EYES PRODUCE MECHANICAL IRRITATION. CHRONIC EXPOSURES
COULD CAUSE DERMATITIS (SKIN) OR CONJUNCTIVITIS (EYES). EXCESSIVE
INHALATION OF USER G ENERATED FUMES FROM WELDING/BRAZING WITH THESE
PRODUCTS MAY, DEPENDING ON THE SPECIFIC FEATURES OF THE PROCESS
USED, POSE A LONG-TERM HEALTH HAZARD.
Medical Cond Aggravated by Exposure:CAUSING ALLERGIC REACTIONS IN
INDIVIDUALS SENSITIVE TO THE METAL(S) CONTAINED IN THESE PRODUCTS.
======================= First Aid Measures =======================
First Aid:INHALATION: IF LARGE AMOUNTS ARE INHALED, REMOVE TO FRESH
AIR. SUPPORT RESPIRATION AS NEEDED. SEEK MEDICAL ATTENTION FOR
TREATMENT, OBSERVATION AND SUPPORT AS NEEDED. SKIN CONTACT: WASH
AFFECTED AREA WITH MILD DETERGENT AND WATER. EYE CONTACT: FLUSH
EYES THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES. INGESTION: SEEK
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:DRY CHEMICAL OR SAND. DO NOT USE WATER ON METAL
DUST FIRE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS SHOULD BE
WORN WHEN FIGHTING METAL DUST FIRES.
Unusual Fire/Explosion Hazard:MAY OCCUR WITH CERTAIN METAL DUST FIRES.
THIS MATERIAL IS NONCOMBUSTIBLE UNDER NORMAL CIRCUMSTANCES.
HOWEVER, FINE POWDERS OR DUSTS (PRODUCED UPON GRINDING, CUTTING,
ETC.) OF CERTAIN METALS CAN PRODUC E FIRE & EXPLOSION HAZARDS,
UNDER CERTAIN CONDITIONS. DO NOT CREATE DUST CLOUDS.
================== Accidental Release Measures ==================
Spill Release Procedures:IN CASE OF A SPILL, CLEAR THE AFFECTED AREA,
PROTECT PEOPLE, & RESPOND WITH TRAINED PERSONNEL. FOR EXPOSURE TO
PURIFYING RESPIRATOR WITH A HEPA FILTER. SWEEP UP THE SPILLED SOLID
& PLACE ALL SPILL RESIDUE IN A DOUBLE PLASTIC BAG & SEAL.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID GETTING CHEMICAL ON YOU OR IN
YOU. WASH HANDS AFTER HANDLING CHEMICALS. DO NOT EAT OR DRINK WHILE
HANDLING CHEMICALS. ALL EMPLOYEES WHO HANDLE THIS MATERIAL SHOULD
BE TRAINED TO HANDLE IT SAFELY . (SEE BELOW)
Other Precautions:ALWAYS USE THIS PRODUCT IN AREAS WHERE ADEQUATE
VENTILATION IS PROVIDED. DECONTAMINATE EQUIPMENT USING SOAPY WATER
BEFORE MAINTENANCE BEGINS. XOLLECT ALL RINSATES AND DISPOSE OF
ACCORDING TO APPLICABL E FEDERAL, STATE, OR LOCAL PROCEDURES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE AN APPROPRIATE NIOSH APPROVED RESPIRATOR (IN
ACCORDANCE WITH 29 CFR 1910.134) IF AIRBORNE DUST/FUME
CONCENTRATIONS EXCEED THE APPLICABLE PEL OR TLV. ALL APPROPRIATE
REQUIREMENTS IN 29 CFR 1910.134 SHOULD BE MET. USE AIR-SUPPLIED
RESPIRATOR IN CONFINED SPACES.
Ventilation:PROVIDE SUFFICIENT GENERAL AND LOCAL EXHAUST VENTILATION TO
MAINTAIN AIR CONCENTRATIONS OF FUME OR DUST BELOW THE PEL AND TLV.
Other Protective Equipment:EYEWASH FOUNTAINS SHOULD BE READILY
AVAILABLE TO AREAS OF USE AND HANDLING. DEPENDING ON ENVEIRONMENT,
Work Hygienic Practices:DO NOT TAKE CLOTHING HOME.
Supplemental Safety and Health
SPILL OR LEAK: USE NORMAL CLEAN-UP PROCEDURES, WET USING SWEEPING
TAKING CARE TO AVOID CREATING DUST. VACUUM ONLY WITH HEPA FILTERED
EQUIPMENT. DO NOT USE COMPRESSED AIR FOR CLEAN-UP. SOME FINE METAL
POWDERS MAY IGNITE OR EXPLODE UNDER SPECIFIC CONDITIONS. TRAINED
PERSONNEL USING PRE=PLANNED PROCEDURES SHOULD RESPOND.
================== Physical/Chemical Properties ==================
HCC:N1
Melt/Freeze Pt:>450.C, 842.F
M.P/F.P Text:450-1800 C
Spec Gravity:6-9
Solubility in Water:INSOLUBLE
Appearance and Odor:METALLIC, NO ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE RESONABLY FORESEEABLE: COPPER IS EXPLOSIVELY INCOMPATIBLE WITH
SODIUM OZIDE. COPPER DUST MAY REACT WITH ACETYLENE GAS TO FORM
COPPER-ACETYLIDES, WHICH IS SENSITIVE TO SHOCK.
Stability Condition to Avoid:OPEN FLAME FOR SOME FINE POWDERS.
Hazardous Decomposition Products:METAL (OXIDE) FUME OR DUST.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:AS SHIPPED, THESE ALLOYS HAVE NO KNOWN
(UNLESS INGESTED) TOXICOLOGICAL PROPERTIES OTHER THAN CAUSING
ALLERGIC REACTIONS IN INDIVIDUALS SENSITIVE TO THE METAL(S)
CONTAINED IN THESE PRODUCTS. USER GENER ATED DUST & FUMES MAY ON
CONTACT WITH THE SKIN OR EYES PRODUCE MECHANICAL IRRITATION.
CHRONIC EXPOSURES COULD CAUSE DERMATITIS (SKIN) OR CONJUNCTIVITIS
(EYES). EXCESSIVE INHALATION OF USER GENERATED F UMES FROM
WELDING/BRAZING WITH THESE PRODUCTS MAY, DEPENDING ON THE SPECIFIC
FEATURES OF THE PROCESS USED, POSE A LONG-TERM HEALTH HAZARD. THE
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) HAS CO NCLUDED
THAT WELDING FUMES ARE POSSIBL
===================== Ecological Information =====================
Ecological:ENVIRONMENTAL STABILITY: MOST OF THE METALS ELEMENTS ARE
NATURALLY PRESENT IN THE SOIL & WATER. INDIVIDUAL METAL'S TRANSPORT
IN THE ENVIRONMENT DEPENDS UPON THE EXACT COMPOUND, THE PH, THE
SOIL TYPE,& THE SALINITY. ALL WORK PRACTICES SHOULD BE AIMED AT
ELIMINATING ENVIRONMENTAL CONTAMINATION.
==================== Disposal Considerations ====================
Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE PRODUCT USER TO
DETERMINE AT THE TIME OF DISPOSAL WHETHER A MATERIAL CONTAIN THE
PRODUCT OR DERIVED FROM THE PRODUCT SHOULD BE CLASSIFIED AS
HAZARDOUS WASTE (40 CFR 261 .20). ALWAYS DISPOSE OF IN ACCORDANCE
WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS. WHER EVER
POSSIBLE TRY TO RECYCLE AND RECLAIM THE METAL
=================== MSDS Transport Information ===================
Transport Information:THIS ALLOYS ARE NOT CONSIDERED HAZARDOUS AS
DEFINED BY 49 CFR 172.101 BY THE US DEPARTMENT OF TRANSPORTATION AT
THE QUANTITY NORMALLY SHIPPED. FOR BULK SHIPMENT OF MORE THAN 1000
LBS SOME METALS MAY B E CONSIDERED HAZARDOUS.
===================== Regulatory Information =====================
SARA Title III Information:SARA 311/312: ACUTE-NO. CHRONIC-YES.
FIRE-NO. PRESSURE-NO. REACTIVITY-NO (PURE/SOLI). SARA 313: THIS
PRODUCT CONTAINS THE FOLLOWING CHEMICALS, WHICH ARE SUBJECT TO
REPORTING REQUIREMENTS OF SECTION 31 3 OF THE EMERGENCY PLANNING &
COMMUNITY RIGHTTO-KNOW ACT OF 1986. CONSUMER MUST REVIEW THEIR
SPECIFIC ALLOYS TO DETERMINE THE AMOUNT OF EACH ELEMENT USED:
NICKEL, COPPER, SILVER, COBALT, MANGANESE, CH ROMIUM, MOLYBDENUM
(TRIOXIDE ONLY), VANADIUM (FUME/DUST ONLY).
Federal Regulatory Information:OSHA-COMPLY WITH HAZARD COMMUNICATION
STANDARDS 29CFR1910.1200 & 1926.59 & RESPIRATORY PROTECTION
STANDARD 29CFR 1910.134 & 1926.103. SOME COMPONENTS OF THIS PRODUCT
ARE CONSIDERED TO BE HAZARDOUS AS DEFINED BY OSHA. TSCA-THESE ARE
MIXTURE OF VARIOUS METALS COMPONENTS. THE CAS NUMBERS OF ALL
INDIVIDUAL CHEMICALS ARE LISTED TSCA CHEMICAL INVENTORY.
CERCLA-CHROMIUM & COMPOUNDS, COPPER AND COMPOUNDS,NICKEL & ITS
COMPOUNDS, SILVER & ITS COMPOUNDS, VANADIUM (OXIDES & PENTAOXIDE),
ZINC & COMPOUNDS.
State Regulatory Information:PROPOSITION 65-THIS PRODUCT CONTAINS THE
FOLLOWING "CHEMICALS KNOWN TO THE STATE OF CALIFORNIA" TO CAUSE
CANCER AND/OR REPRODUCTIVE TOXICITY: COBALT AND COBALT COMPOUNDS,
CHROMIUM VI AND ITS COMPOUNDS , NICKEL AND NICKEL COMPOUNDS.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:TECTYL 2423 NST BLACK
CAGE:IO754
CAGE:IO754
CAGE:72527
============= Composition/Information on Ingredients =============
Ingred Name:RESIN EMULSION
Fraction by Wt: 36-46%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:RESIN EMULSION
Fraction by Wt: 9-19%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BARIUM SULFATE
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 5-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:ZINC PHOSPHATE; (ZINC PHOSPHATE DIHYDRATE)
CAS:7779-90-0
RTECS #:TD0590000
Fraction by Wt: 5-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 1.3-11%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:2-PROPANOL, 1-PROPOXY-; (PROPYLENE GLYCOL MONOPROPYL ETHER)
CAS:1569-01-3
RTECS #:UB9351000
Fraction by Wt: 1-11%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBON BLACK; (PIGMENT DISPERSION)
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1-9%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PHTHALIC ACID, BENZYL BUTYL ESTER; (BUTYL BENZYL PHTHALATE)
(SARA 313) (CERCLA)
CAS:85-68-7
RTECS #:TH9990000
Fraction by Wt: 3.2%
OSHA PEL:N/K
ACGIH TLV:N/K
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:BENZOIC ACID, AMMONIUM SALT; (AMMONIUM BENZOATE) (CERCLA)
CAS:1863-63-4
RTECS #:DG3378000
Fraction by Wt: 1-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
2,2,4-TRIMETHYL-1,3-PENTANEDIOL; (TRIME-1,3-PENTANEDIOL,
MONOISOBUTYRATE)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: 1-7%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:SUPDAT: DMG. THIS MATL (OR COMPONENT) HAS BEEN SHOWN TO
CAUSE HARM TO FETUS IN LAB ANIMAL STUDIES. HARM TO (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: FETUS OCCURS ONLY AT EXPOS LEVELS THAT HARM
PREGNANT ANIMAL. RELEVANCE OF THESE FINDINGS TO HUMANS IS
UNCERTAIN.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: IF CONSCIOUS & ALERT, INDUCE VOMIT BY
GIVING SYRUP OF IPECAC OR BY GENTLY PLACING TWO FINGERS (ING 15)
RTECS #:9999999ZZ
Ingred Name:ING 14: AT THE BACK OF THROAT. IF POSS, DO NOT LEAVE
INDIVIDUAL UNATTENDED. INHAL: IF SYMPS DEVELOP, MOVE AWAY (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: FROM EXPOS & INTO FRESH AIR. IF SYMPS PERSIST, SEEK
MED ATTN. IF BRTHG IS DFCLT, ADMIN OXYGEN. KEEP (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16: PERSON WARM & QUIET; SEEK IMMED MED ATTN.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: STOP SPILL AT SOURCE. PVNT FROM ENTERING DRAIN,
SEWERS, STREAMS OR OTHER BODIES OF WATER. PVNT FROM (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: SPREADING. IF RUNOFF OCCURS, NOTIFY AUTHS AS REQD.
PUMP/VACUUM TRANSFER SPILLED PROD TO CLEAN CNTNRS (ING 20)
RTECS #:9999999ZZ
Ingred Name:ING 19: FOR RECOVERY. ABSORB UNRECOVERABLE PROD. TRANSFER
CONTAMD ABSORB, SOIL & OTHER MATLS TO CNTNRS FOR (ING 21)
RTECS #:9999999ZZ
Ingred Name:ING 20: DISP. PVNT RUNOFF TO SEWERS, STREAMS OR OTHER
BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER AUTHS (ING 22)
RTECS #:9999999ZZ
Ingred Name:ING 21: AS REQUIRED, THAT A SPILL HAS OCCURED.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: (CONSULT YOUR INDUSTRIAL HYGIENIST). ENGINEERING
OR ADMIN CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
RTECS #:9999999ZZ
Ingred Name:VENT: (FROM KNOWN, SUSPECTED OR APPARENT ADVERSE EFFECTS).
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE: EXPOS MAY CAUSE MILD IRRIT. SYMPS
MAY INCL STINGING, TEARING & REDNESS. SKIN: EXPOS CAUSES IRRIT.
PRLNGD/RPTD EXPOS MAY DRY SKIN. SYMPS MAY INCL REDNESS, BURNING,
DRYING & CRACKING, SKIN BURNS & SKIN DMG. SKIN ABSORPTION IS POSS
& MAYCONTRIBUTE TO SYMPS OF TOX FROM OTHER ROUTES OF EXPOS. INGEST:
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS, VOL 65,
PG 24-27, 1995:GROUP 2B.
Effects of Overexposure:HLTH HAZ: SINGLE DOSE ORAL TOX IS LOW.
SWALLOWING SM AMTS DURING NORM HNDLG IS NOT LIKELY TO CAUSE HARMFUL
EFTS; SWALLOWING LARGE AMTS MAY BE HARMFUL W/GI IRRIT (NAUS, VOMIT,
DIARR). INHAL: EXPOS TO V AP/MIST IS POSS W/IRRIT (NOSE, THROAT,
RESP TRACT). TARGET ORGAN EFTS: OVEREXP TO THIS MATL (OR ITS
COMPONENTS) (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN & LUNG DISORDERS,
EG ASTHMA-LIKE CNDTNS; BLOOD ABNORMALITIES, LIVER ABNORMALITIES,
ANEMIA, SPLEEN DAMAGE, TESTIS DAMAGE, EYE DAMAGE, KIDNEY DAMAGE,
LUNG DAMAGE.
======================= First Aid Measures =======================
First Aid:EYES: IF SYMPS DEVELOP, MOVE AWAY FROM EXPOS & INTO FRESH
AIR. FLUSH EYES GENTLY W/WATER WHILE HOLDING LIDS APART. IF SYMPS
PERSIST/IF VISUAL DFCLTY, SEEK MED ATTN. SKIN: REMOVE CONTAMD
CLTHG. WASH EX POS AREA W/SOAP & WATER. IF SYMPS PERSIST, SEEK MED
ATTN. LAUNDER CLTHG BEFORE REUSE. INGEST: SEEK MED ATTN. IF
DROWSY/UNCON, DO NOT GIVE ANYTHING BY MOUTH; PLACE ON LEFT SIDE
W/HEAD DOWN. (ING 14)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:150F,66C
Lower Limits:1.3%
Upper Limits:25.0%
Extinguishing Media:ALCOHOL FOAM, WATER FOG.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . REFER TO
PERSONAL PROT EQUIP SECTION OF MSDS. COMBUST MAY FORM CARBON
DIOXIDE & CARBON MONOXIDE, VARIOUS HYDROCARBS.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND OR BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER
FLAMES & IGNIT SOURCES AT LOCATIONS DISTANT FROM (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILL:ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL. LG SPILL: ELIM ALL IGNIT SOURCES
(FLARES,FLAMES INCL PILOT LIGHTS, ELEC SPKS). PERS NOT WEARING PROT
EQUIP SHOULD BE EXCLUDED FROM A REA OF SPILL UNTIL CLEAN-UP
COMPLETED. (ING 18)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:ALL FIVE GALLON PAILS & LARGER METAL
CONTAINERS INCLUDING TANK CARS & TANK TRUCKS SHOULD BE GROUNDED
&/OR BONDED WHEN MATERIAL IS TRANSFERRED.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN DATA SHEET
MUST BE OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, NIOSH APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRONMENTAL CTL. OSHA REGS ALSO PERMIT OTHER NIOSH
RESPS (NEG PRESS TYPE) UNDER SPECIFIED CNDTNS (ING 23)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENT TO MAINTAIN EXPOS BELOW LEVEL OF OVEREXPOSURE (ING 24)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: MATL HNDLG POINT. NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM (EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE
EXPLOSIVELY. EFTS OF OVEREXP: HAS BEEN SUGGESTED AS CAUSE OF
FOLLOWIN G EFTS IN LAB ANIMALS: BLOOD ABNORMS, LIVER ABNORMS,
ANEMIA, SPLEEN DMG, TESTIS DMG, EYE DMG, KIDNEY DMG, LUNG (ING 12)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>97F,>36C
Vapor Pres:28.28 @68F
Spec Gravity:1.210
pH:9-10
VOC Grams/Liter:1.7
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:BLACK LIQUID.
Percent Volatiles by Volume:57-63
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG MINERAL ACIDS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM: CARBON DIOXIDE AND CARBON
MONOXIDE, VARIOUS HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: TECHNOVIT 4000 POWDER
Cage: KULZR
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: KULZR
=======================================================
Contractor Summary
=======================================================
Cage: KULZR
=======================================================
Ingredients
=======================================================
% Wt: 0-5
-----------------------------
Cas: 14808-60-7
RTECS #: VV7330000
CARC IARC-GROUP 2A; SUSPECTED CARC NTP) *95-3*
% Wt: >90
Other REC Limits: 0.05 MG/CUM NIOSH
OSHA PEL: 0.1 MG/CUM RESP DUST
ACGIH TLV: 0.1 MG/CUM RESP DUST
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: SKIN: MAY CAUSE SENSITIZATION BY CONTACT.
Explanation Of Carcinogenicity: SEE INGREDIENTS.
Signs And Symptions Of Overexposure: SKIN: MAY CAUSE SENSITIZATION BY CONTACT.
First Aid: SKIN: INSTANTLY WASH W/WATER & SOAP & RINSE THOROUGHLY.
EYES: RINSE FOR SEVERAL MINS UNDER RUNNING WATER. INGESTION: INITIATE
VOMITING & CONSULT A DOCTOR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: COLLECT MECHANICALLY. DON'T ALLOW UNDILUTED
PRODUCT/LARGE QUANTITIES OF IT TO REACH GROUND WATER, WATER BODIES/SEWAGE
SYSTEM.
Waste Disposal Methods: MUST NOT BE DISPOSED OF TOGETHER W/HOUSEHOLD GARBAGE.
DON'T ALLOW PRODUCT TO REACH SEWAGE SYSTEM. DISPOSE OF IAW/FEDERAL, STATE
& LOCAL REGULATIONS. NO:31442. PACKAGING CAN BE REUSED/RECYCLED AFTER CL
EANING.
Handling And Storage Precautions: STORE IN COOL, DRY PLACE IN TIGHTLY CLOSED
CONTAINERS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CO2, EXTINGUISHING POWDER/WATER JET/ALCOHOL-RESISTANT
FOAM.
Fire Fighting Procedures: FIGHT LARGER FIRES W/WATER JET/ALCOHOL RESISTANT
FOAM.
Unusual Fire/Explosion Hazard: FORMATION OF TOXIC GASES IS POSSIBLE DURING
HEATING/IN CASE OF FIRE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED
Other Protective Equipment: PERSONAL PROTECTIVE EQUIPMENT.
Work Hygienic Practices: GENERAL PROTECTIVE & HYGIENIC MEASURES. INSTANTLY
REMOVE ANY SOILED & IMPREGNATED GARMENTS.
Supplemental Safety and Health: WASH HANDS DURING BREAKS & AT THE END OF
THE WORK DAY.
=======================================================
Physical/Chemical Properties
=======================================================
Solubility in Water: INSOLUBLE
Appearance and Odor: WHITE POWDER ODORLESS
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: NONE
Hazardous Decomposition Products: IF USED & STORED ACCORDING TO SPECIFICATIONS.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TECHNOVIT 4000 POWDER
Cage: KULZR
Company Name: HERAEUS KULZER GMBH
Zipcode: 00000
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: SKIN: MAY CAUSE SENSITIZATION BY CONTACT.
SKIN: MAY
CAUSE SENSITIZATION BY CONTACT.
=======================================================
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:KVX23P156Q
CAGE:14655
CAGE:14655
============= Composition/Information on Ingredients =============
Ingred Name:POLYCHLORINATED BIPHENYLS (PCBS) (SARA III)
CAS:1336-36-3
RTECS #:TQ1350000
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:ABSORBED THRU SKIN,LUNGS,INTESTINE.CAUSES
CANCER,LIVER,KIDNEY,STOMACH,EYE,HEARING DISORDER(SUP DATA)
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER IMMEDIATELY.SKIN:WASH W/SOAP
IMMEDIATELY.INHAL:REMOVE TO FRESH AIR,GIVE ART.RESPIR.AS
NEEDED.INGEST:GET MEDICAL ATTN.GIVE LARGE QTY OF SALT WATER,INDUCE
VOMITING,BUT DO NOT MAKE UNC ONSCIOUS PERSON VOMIT.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT & DIKES TO PREVENT
RUNOFF.ISOLATE & NOTIFY PROPER AUTHORITIES.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE MUST FOLLOW RCRA REQUIREMENTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SUPPLIED AIR W/FULL FACEPIECE,HELMET OR HOOD
Ventilation:LOCAL EXHAUST
Other Protective Equipment:FULL CLOTHING TO PREVENT SKIN CONTACT
Supplemental Safety and Health
OVEREXPOS:CAN CAUSE FORMATION OF CYSTS,CAUSES STILLBIRTHS.IRRITATES
EYES,NOSE THROAT.
================== Physical/Chemical Properties ==================
HCC:Z3
Appearance and Odor:LIGHT STRAW-COLORED LIQUID,AROMATIC ODOR
================= Stability and Reactivity Data =================
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTROLLED DISPOSAL REQUIRED-GENERALLY HIGH
TEMPERATURE INCINERATION.ONLY APPROVED DISPOSAL OPERATOR PERMITTED.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MA 3800 + 3802 EPOXY ADHESIVE PREPREG
CAGE:5X358
CAGE:5X358
============= Composition/Information on Ingredients =============
Ingred Name:DGEBA EPOXY RESINS
CAS:25068-38-6
RTECS #:SL6475000
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:DGEBA BROMINATED EPOXY RESIN
CAS:40039-93-8
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CARBOXY TERMINATED BUTYL NITRILE
CAS:68891-50-9
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:CYANOGUANIDINE.
CAS:461-58-5
RTECS #:ME9950000
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ANTIMONY TRIOXIDE (SARA III)
CAS:1309-64-4
RTECS #:CC5650000
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:0.5 MG/M3 (SB)
ACGIH TLV:0.5 MG SB/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIMETHYLAMINO METHYL =PHENOL.
CAS:25338-55-0
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:1-CYANOETHYL 2-ETHYL 4-METHYL IMDAZOLE
CAS:23996-25-0
Fraction by Wt:
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:POSSIBLE MINOR SKIN IRRITATION
RESULTING FROM EXCESSIVE CONTACT WITH ADHESIVE.
Explanation of Carcinogenicity:N/A
Effects of Overexposure:POSSIBLE ITCHING & REDNESS OF HANDS.
Medical Cond Aggravated by Exposure:SENSITIVE SKIN, ALLERGIES.
======================= First Aid Measures =======================
First Aid:INHALATION:N/A, EYES;FLUSH EYES WITH WATER FOR AT LEAST 15
MINUTES & GET MEDICAL ATTENTION. SKIN:WASH SKIN WITH SOAP & WATER,
REMOVE CONTAMINATED CLOTHING & WASH. INGESTION:NOT A PROBABLE ROUTE
OF ENT RY.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:>200F (>93C)
Lower Limits:NOT DETERMIN
Upper Limits:NOT DETERMIN
Extinguishing Media:FOAM CO:2, DRY CHEMICAL
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:N/A- FILM ADHESIVE.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AT 0F (-18C) FOR LONG SHELF
LIFE.
Other Precautions:N/K
============= Exposure Controls/Personal Protection =============
Respiratory Protection:N/A - SOLID FILM
Ventilation:SUGGESTED MECHANICAL(GENERAL) IS OK.
Other Protective Equipment:CLEAN LONG SLEEVE &LONG LEG CLOTHING.
Work Hygienic Practices:NORMAL GOOD INDUSTRIAL HOUSE KEEPING.
Supplemental Safety and Health
N/A:NOT APPLICABLE. PCT VOLT-VOL & PH.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES
Melt/Freeze Pt:M.P/F.P Text:>140F(>60C)
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/A-SOLID
Spec Gravity:1.2
Evaporation Rate & Reference:N/K
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CREAM COLORED FILM ON GLASS CARRIER.
Corrosion Rate:
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
N/K
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN,
ALDEHYDES, & OTHER ORGANICS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE & LOCAL REGULATIONS . BURY IN AN APPROVED LANDFILL.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:CY-CYP ACTIVATED CARBON
CAGE:HO835
CAGE:4U654
CAGE:HO835
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS NON-TOXIC THROUGH
INGESTION AND SKIN ABSORPTION. ACTIVATED CARBON IS NOT A PRIMARY
SKIN IRRITANT. NO SENSITIZATION EFFECTS ARE KNOWN. THE PHYSICAL
NATURE OF THIS PRODUCT MAY IRRITATE T HE RESPIRATORY SYSTEM. THE
PHYSICAL NATURE OF THIS PRODUCT MAY PRODUCE EYE IRRITATION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INGESTION:CALL MD IMMEDIATELY . INHALATION:REMOVE TO FRESH
AIR. SUPPORT BREATHING (GIVE O*2/ARTF RESP) . EYES:FLUSH WITH WATER
FOR AT LEAST 15 MINUTES. CONTACT A DOCTOR IMMEDIATELY. INHALA
TION:THE PERSON SHOULD BE REMOVED FROM THE AREA.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM, CO*2, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTACT WITH STRONG OXIDIZERS MAY RESULT
IN FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:UNUSED PRODUCT SHOULD BE SWEPT UP AND
DISCARDED OR REPACKAGED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CAUTION! WET ACTIVATED CARBON REMOVES
OXYGEN FROM THE AIR CAUSING A SEVERE HAZARD TO WORKERS IN CONFINED
SPACES.
Other Precautions:SAMPLING AND WORK PROCEDURES FOR LOW OXYGEN LEVELS
SHOULD BE TAKEN WHENEVER WORKERS MAY BE ENTERING CARBON VESSELS,
ENCLOSED OR CONFINED SPACES. ALL FEDERAL, STATE AND LOCAL
REGULATIONS SHOULD BE OBSE RVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH/MSHA APPROVED HIGH EFFECIENCY
PARTICULATE FILTER IS RECOMMENDED WHENEVER EXCESSIVE DUST MAY BE
GENERATED.
Ventilation:LOCAL EXAUST IS RECOMMENDED, SUFFICIENT TO CONTROL DUST.
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER WHICH
MEET ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:0.3-0.7
Solubility in Water:NOT SOLUBLE
Appearance and Odor:ODORLESS BLACK SOLID FLAKE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CARBON MONOXIDE MAY BE FORMED IN THE
EVENT OF A FIRE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . UNUSED CARBON MAY BE DISPOSED OF BY ANY APPROPRIATE
MEANS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: LIQUID ROC 300 POLYESTER PUMP, PART A
Kit Part: Y
Cage: GUNNE
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 79038
Box: UNKNOW
Cage: GUNNE
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: CAUSES EYE BURNS. SKIN IRRITANT. CAN HAVE A NARCOTIC
EFFECT IF INHALED. CAN CAUSE ALLERGIC SKIN AND RESPIRATORY CONDITION.
"STYRENE SICKNESS" CONSISTING OF DROWSINESS, NAUSEA, HEADACHE, FATIGUE AND DI
ZZINESS HAS BEEN MENTIONED IN WORKERS EXPOSED AT 200-700 PPM. CRYSTALLINE
SILICA IS CONSIDERED BY IARC (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: STYRENE:IARC MONOGRAPHS, SUPPLEMENT, VOL 7, PG
345, 1987:GROUP 2B. ANIMAL:NERVOUS SYSTEM.
Signs And Symptions Of Overexposure: HLTH HAZ:TO BE AN ANIMAL CARCINOGEN. THE
NATURE AND USE OF THIS PRODUCT SHOULD NOT POSE A CANCER RISK TO HUMANS.
Medical Cond Aggravated By Exposure: SKIN & EYE CONDITIONS.
First Aid: EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS. CALL MD.
SKIN:WASH W/SOAP & WATER. REMOVE CONTAM CLTHG & LAUNDER BEFORE REUSE.
INHAL:MOVE VICTIM TO FRESH AIR. GIVE OXYG &/OR ARTF RESP IF NEEDED . CALL
MD. INGEST:GIVE PLENTY OF WATER TO DRINK. DO NOT INDUCE VOMIT. CALL MD. NEVER
GIVE ANYTHING BY MOUTH TO UNCON PERS. OTHER:REFERRAL TO MD IS REC IF THERE IS
ANY QUESTIONS ABOUT THE SERIOUSNESS O F THE INJURY/EXPOSURE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION. COVER W/ABSORBENT
MATERIAL & PLACE IN SALVAGE CONTAINER FOR PROPER DISPOSAL.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: CONSULT W/LOCAL REGULATORY AGENCIES OR CORPORATE
PERSONNEL FOR DISPOSAL METHODS THAT COMPLY W/LOCAL, STATE & FEDERAL
HEALTH & ENVIRONMENTAL REGULATIONS.
Handling And Storage Precautions: KEEP IN COOL, DRY PLACE OUT OF DIRECT RAYS OF
SUN. STORE <100F. KEEP AWAY FROM IGNIT SOURCES SUCH AS EXCESS HEAT, SPKS
& OPEN FLAME. FLAMMABLE.
Other Precautions: WARNING! CAUSES EYE BURNS & SKIN IRRIT. CAN HAVE
ANESTHETIC EFT IN INHALED. CAN CAUSE ALLERGIC SKIN & RESP RXNS. AVOID
CONTACT W/EYES, SKIN & CLTHG. AVOID BREATHING IN VAPOR. AVOID PROLONGED
OR REPEAT ED CONTACT W/SKIN. USE W/ADEQUATE VENT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 93.0F,33.9C
Lower Limits: 1.1%
Upper Limits: 6.1%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard: OSHA CLASS IC - FLAMMABLE LIQUID. ISOLATE FROM
HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME. DECOMPOSITION &
COMBUSTION PRODUCTS, MAY BE TOXIC.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED ORGANIC VAPOR RESPIRATOR WHEN VAPOR
CONCENTRATIONS EXCEED RECOMMENDED EXPOSURE LIMITS.
Ventilation: GENERAL - NATURAL OR MECHANICALLY INDUCED FRESH AIR MOVEMENTS THAT
MAINTAIN VAPOR CONCS BELOW REC EXPOSURE LIMITS.
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N).
Work Hygienic Practices: WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health: NOTE: USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). APPEARANCE/ODOR: PLASTIC CAULKING
TUBE. PART A IS THE LARGE TUBE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >248F,>120C
Vapor Pres: SEE ING 3
Vapor Density: SEE ING 3
Spec Gravity: 0.89
Solubility in Water: NIL
Appearance and Odor: LIGHT GREY PASTE; STYRENE ODOR.POLYESTER SYS PACKAGED IN
DUAL COMPONENT(SUPDAT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STABLE AT TEMPERATURES
Materials To Avoid: STRONG ACIDS, PEROXIDES & OTHER OXIDIZING AGENTS.
Hazardous Decomposition Products: CARBON DIOXIDE, CARBON MONOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: LIQUID ROC 300 POLYESTER PUMP, PART A
Cage: GUNNE
Company Name: GUNNEBO FASTENING CORP
Street: 180 SOUTH HARTMAN STREET
Zipcode: 17405
Label Required IND: Y
Date Of Label Review: 12/20/1996
Status Code: C
Label Date: 12/20/1996
Origination Code: G
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE:CAUSES EYE BURNS. SKIN IRRITANT. CAN
HAVE A NARCOTIC EFFECT IF INHALED. CAN CAUSE ALLERGIC SKIN AND RESPIRATORY
CONDITION. "STYRENE SICKNESS" CONSISTING OF DROWSINESS, NAUSEA, HEADACH E,
FATIGUE AND DIZZINESS HAS BEEN MENTIONED IN WORKERS EXPOSED AT 200-700 PPM.
CHRONIC:CANCER HAZARD. CONTAINS MATERIAL WHICH IS LISTED AS AN ANIMAL NERVOUS
SYSTEM CARCINOGEN (FP N). CRYSTALLINE SILIC A IS CONSIDERED BY IARC TO BE AN
ANIMAL CARCINOGEN. THE NATURE AND USE OF THIS PRODUCT SHOULD NOT POSE A
CANCER RISK TO HUMANS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RUST PREVENTATIVE TM-1822
CAGE:FO810
CAGE:2F853
CAGE:FO810
CAGE:NO710
============= Composition/Information on Ingredients =============
Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 62%
Other REC Limits:N/K
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:N/K
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9192
Ingred Name:ALIPHATIC PETROLEUM DISTILLATES (HYDROTREATED LIGHT
NAPHTHENIC DISTILLATE).
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: 15%
Other REC Limits:5 MG/M3
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:LONG TERM EXPOSURE (YEARS):VAPOR MAY
CAUSE LUNG,LIVER OR KIDNEY DAMAGE.
Explanation of Carcinogenicity:ALIPHATIC PETROLEUM DISTILLATES
(64742-53-6):SUFF EVID FOR CARC IN ANIM,SUFF EVID FOR CARC IN
HUMANS (IARC,1984).
Effects of Overexposure:EYES:N/K .SKIN:REDNESS.WILL CAUSE DEFAT.EFTS
ARE REVERSIBLE.INGEST:VOMIT.INHAL:DFCLT BREATHING,MAY CAUSE
DIZZINESS OR NARCOSIS IN HIGH VAPOR CONCENTRATIONS.LONG TERM
EXPOSURE (YEARS):VAPOR MAY CAUSE LUNG,LIVER OR KIDNEY DAMAGE.THE
SOLVENTS LISTED HAVE BEEN REPORTED TO AFFECT THE CENTRAL NERVOUS
SYSTEM.
Medical Cond Aggravated by Exposure:GENERALLY AGGRAVATED BY
EXPOSURE:HEART DISEASE,RESPIRATORY DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES:WASH WITH WATER FOR AT LEAST 15 MINUTES.SKIN:WASH WITH
WATER.INGESTION:DO NOT INDUCE VOMITING,GASTRIC
LAVAGE.INHALATION:GIVE OXYGEN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-40F,-40C
Lower Limits:12.0%
Upper Limits:1.8%
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE.
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA AND FULL PROTECTIVE
EQUIPMENT .AEROSOL CANS MAY RUPTURE WHEN HEATED.
Unusual Fire/Explosion Hazard:HEATED CANS MAY BURST.HAZARDOUS
DECOMPOSITION PRODUCTS:HCL ,PHOSGENE,HALOGEN ACIDS,CARBON
DIOXIDE,WATER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ABSORBENT SWEEPING COMPOUND TO SOAK UP
MATERIAL.PUT INTO CONTAINER.DISPOSE AS HAZARDOUS WASTE.
Neutralizing Agent:N/K
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT,SPARKS,OPEN
FLAME.STORE AT TEMP <120F,48.89C.
Other Precautions:NO SMKNG IN AREA OF USE.DO NOT USE IN GEN VICIN OF
ARC WELDING,OPEN FLAMES,HOT SURF.HEAT &/OR UV RADIA MAY CAUSE THE
FORMATION OF HCL &/OR PHOSGENE .USE NIOSH/MSHA APPRVD RESP WHEN
SPRAYING MORE THAN ONE HALF CAN CONTINUOUSLY,(SUP DA)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .USE SCBA ABOVE TLV LIMIT.
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Other Protective Equipment:LONG SLEEVES,LONG PANTS.
Work Hygienic Practices:DO NOT SMOKE WHILE USING.WASH HANDS AFTER USE.
Supplemental Safety and Health
BP RANGE:-40F,-40C TO UNKNOWN.VP:63 PSIG @ 70F,21.11C.OTHER PREC:MORE
THAN ONE CAN CONSECUTIVELY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP
Melt/Freeze Pt:M.P/F.P Text:N/A (LIQ)
Decomp Temp:Decomp Text:N/K
Vapor Pres:SEE SUPP
Vapor Density:4.0,AIR=1
Spec Gravity:0.8 (WATER=1)
Evaporation Rate & Reference:<3 (BUTYL ACETATE=1)
Solubility in Water:NIL
Appearance and Odor:BROWN LIQUID WITH SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
THE SOLVENTS ARE INCOMPATIBLE WITH STRONG OXIDIZERS.NOT COMPATIBLE WITH
ACTIVE METALS.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:HCL,PHOSGENE .IN FIRE WILL DECOMPOSE
TO WATER,CARBON DIOXIDE,HALOGEN ACIDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACETYLENE, ETHYNE, ETHINE
CAGE:00742
CAGE:00742
CAGE:5H199
============= Composition/Information on Ingredients =============
Ingred Name:ACETYLENE, ETHYNE, ETHINE
CAS:74-86-2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DO NOT ENTER AREAS WITHIN THE
FLAMMABLE RANGE DUE TO THE IMMEDIATE FIRE AND EXPLHAZARD.
ACETYLENE IS A SIMPLE ASPHYXIANT, IRRITANT, AND ANESTHETIC.
Effects of Overexposure:SYMPTOMS SUCH AS HEADACHES, DIZZINESS,
SHORTNESS OF BREATH, & LOSS OF CONSCIOUS-NESS MAY OCCUR IF THE GAS
IS PRESENT IN QUANTITIES SUFFICIENT TO DILUTE THE OXY CONCENTRATION
IN AIR. SYMPTOMS OF ANOXIAOCCUR ONLY WHEN THE GAS
CONCENTRATIONSARE WITH THE FLAMMABLE RANGE AND THE MIXTURE HAS NOT
IGNITED.
======================= First Aid Measures =======================
First Aid:FIRST DEGREE & MINOR SECOND DEGREE THERMAL BURNS FROM FIRES
SHOULD BE IMMERSEDIN COOL WATER FOR 30 MIN. MAJOR SEC & THIRD
DEGREE BURNS SHOULD BE COVERED INTHE CLEANEST MATERIAL AVEIL.
SEEK IMMEDI ATE PHYSICIAN AID. PERSONS SUFFERINGFROM LACK OF OXY
SHOULD BE MOVED TO AREAS WITH NORMAL ATMOS. CPR SHOULD BE GIVENIF
VICTIM IS NOT BREATHING.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:0F/-18C
Autoignition Temp:Autoignition Temp Text:581F
Lower Limits:100%
Upper Limits:2.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, HALON
Fire Fighting Procedures:TOP GAS FLOW. USE WATER SPRAY TO KEEP CYL.
COOL IF EXPOSED TO FIRE. KEEP PERSONSWAY SINCE CONTAINERS CAN
RUPTURE VIOLENTLY. SEE CGA SAFETY BULLETIN SB-4.
Unusual Fire/Explosion Hazard:ACETYLENE IS EXTREMELY FLAMMABLE &
EXPLOSIVE.IT BURNS WITH INTENSELY HOT FLAME. IGNITES VERY
EASILY.VERY WIDE FLAMMABLE LIMITS. POCKETS RATHER THAN DISSIPATES.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA TO PREVENT FLAMMABLE MIXTURE
FORM FORMING. REMOVE SOURCES OF IGNITION, HEAT, SPARKS,ETC. AVOID
ENTERING AREA OF FLAMMABLE ATMOS. CARE-FULLY REMOVE CYLINDERS WITH
SLOW LEAKS TO A REMOTE OUTDOOR LOCATION.CONTACT AIR PRODUCTS FOR
ASSISTAN
======================Handling and Storage ======================
Handling and Storage Precautions:USE IN WELL VENTILATED AREA.KEEP
ACETYLENE CYLINDEUPRIGHT & SECURE.NEVER EXPOSE TO HEAT. SEGREGATE
FULL/EMPTY CYL. ALWAYS OPEN/CLOSE VALVES SLOWLY.
Other Precautions:AVOID EXPOSURE TO AREAS WHERE SALT OR OTHER CORROSIVE
CHEMICALS ARE PRESENT.KEEPACETYLENE CYL. STORAGE AREAS AWAY FROM
STORAGE OF OXY & OTHER OXIDIZERS. AVOID HAZARDOUS MIXTURES &
SOURCES OF IGNITION .DO NOT REFILL COMPRESSED GAS CYLINDERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OXYGEN-DEFICIENT ATMOSPHERES ARE IN THE
FLAMMABLE RANGE. DO NOT ENTER! RESPIRATORS WILL NOT
FUNCTION.
Ventilation:NATURAL OR MECHANICAL WHERE GAS IS PRESENT.
Other Protective Equipment:LEATHER SLEEVES, LEATHER APRON AND OTHER
STANDARD PROTECTIVEEQUIPMENT FOR CUTTING AND WELDING.
Supplemental Safety and Health
MECHANICAL VENTILATION FOR ENCLOSED STORAGE AREAS MUST MEET NATIONAL
ELECTRICAL CODE REQUIREMENTS FOR CLASS 1, GROUP A.FORMATION OF
EXPLOSIVE COPPER ACETYLIDECAN BE AVOIDED BY USING COPPER ALLOYS PR
OVED SUCCESSFUL THROUGH USE IN INDUSTRY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-119F/-84C
Vapor Pres:*SEE BELOW
Vapor Density:*SEE BELOW
Spec Gravity:68F20C1ATM0.906
Solubility in Water:1ATM 1. CUFT/CUFTH20
Appearance and Odor:PURE ACETYLENE IS COLORLESS & ODORLESS. IMPURITIES
GENERATE GARLIC-LIKE ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
OXIDIZERS SUCH AS OXYGEN & HALOGENS. FORMS EXPLOSIVE
COMPNDSW/COPPER,BRASS,COPPER SALT,HG/HG SALTS,K,AG/AG SALTS,& HNO3.
Stability Condition to Avoid:NEVER UTILIZE FREE GAS OUTSIDE CYL. AVOID
MECH. SHOCKS TO CONTAINERS. NEVER EXPOSE CYLINDERS TO SOURCES OF
HEAT.
Hazardous Decomposition Products:ACETYLENE WILL DECOMPOSE INTO
ELEMENTAL CARBON & HYDROGEN UNDER THE ABOVE CONDITIONS IN
MATERIALS TO AVOID.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF RESIDUAL GASEOUS
ACETYLENE IN CYLINDERS. RETURN TO AIR PRODUCTS INCFOR DISPOSAL.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: DA 6960 KRYOLIUM BULLDOG RED
Cage: 64557
=======================================================
Contractor Summary
=======================================================
Cage: 64557
=======================================================
Ingredients
=======================================================
Cas: 74-98-6
RTECS #: TX2275000
Percent by Wt: 15.
OSHA PEL: 1800 MG/M3;1000 PPM
ACGIH TLV: 1800 MG/M3
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
Percent by Wt: 11.7
OSHA PEL: 100 PPM
OSHA STEL: 150 PPM
ACGIH TLV: 434 MG/M3; 100 PPM
ACGIH STEL: 651 MG/M3;150 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 67-64-1
RTECS #: AL3150000
Percent by Wt: 17.8
OSHA PEL: 750 PPM
OSHA STEL: 1000 PPM
ACGIH TLV: 1780 MG/M3;750 PPM
ACGIH STEL: 2380 MG/M3;1000 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
Percent by Wt: 2.9
OSHA PEL: 435 MG/M3;100 PPM
ACGIH TLV: 434 MG/M3;100 PPM
ACGIH STEL: 543 MG/M3;125 PPM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
Percent by Wt: 3.6
OSHA PEL: 410 MG/M3;50 PPM
ACGIH TLV: 205 MG/M3;50 PPM
ACGIH STEL: 307 MG/M3;75 PPM
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Percent by Wt: .4
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 8032-32-4
RTECS #: OI6180000
Percent by Wt: .6
OSHA PEL: 300 PPM
OSHA STEL: 400 PPM
ACGIH TLV: 1370 MG/M3;300 PPM
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 2807-30-9
RTECS #: KM2800000
Percent by Wt: 3.1
------------------------------
Cas: 75-28-5
RTECS #: TI4300000
Percent by Wt: 10.
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM/ 1800 MG/M3
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: IRRITATION OR RESPIRATORY SYSTEM, EYES AND SKIN, ORGANS
EFFECTED: EYE, SKIN IRRITATION, DERMATITIS.
Medical Cond Aggravated By Exposure: EXISTING EYE, SKIN OR UPPER RESPIRATORY
CONDITION
First Aid: EYE: FLUSH W/ WATER FOR 15 MINS. SKIN: WASH WITH SOAP AND WATER.
EXCESSIVE INHALATION: REMOVE TO FRESH AIR. INGESTION: DO NOT INDUCE VOMITING
- SEEK A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: VENTILATE AREA. REMOVE OPEN FLAMES AND SOURCES OF
IGNITION. PICK UP WITH INERT ABSORBANTS.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS. DO NOT PUNCTURE OR INCINERATE. DO NOT REUSE CONTAINER. WRAP
CONTAINER AND PLACE IN TRASH COLLECTION.
Handling And Storage Precautions: KEEP AWAY FROM HEAT, SPARKS, OR OPEN FLAME.
STORE AT TEMPERATURES BELOW 120F.
Other Precautions: USE ONLY AS DIRECTED. INTENTIONAL MISUSE BY DELIBERATLEY
CONCENTRATING VAPORS AND INHALING CONTENTS CAN BE HARMFUL OR FATAL.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TOC
Flash Point: =-23.3C, -10.F
Lower Limits: 0.7
Extinguishing Media: DRY CHEMICAL, FOAM, CARBON DIOXIDE
Fire Fighting Procedures: EXPOSURE TO HEAT MAY CAUSE BURSTING OF AEROSOL CAN.
Unusual Fire/Explosion Hazard: TREAT AS CYLINDER OF COMPRESSED GAS. WATER SPRAY
MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CONTAINERS TO PREVENT BURSTING.
IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WEAR A NIOSH APPROVED RESPIRATOR IF NECESSARY
Ventilation: MAINTAIN ADEQUATE VENTILATION
Other Protective Equipment: LONG SLEEVES, LONG PANTS AND/OR APRON IMPERVIOUS TO
THE INGREDIENTS IN THIS PRODUCT.
Work Hygienic Practices: WASH HANDS BEFORE EATING OR USING THE WASHROOM SMOKE
IN DESIGNATED AREAS ONLY.
Supplemental Safety and Health: FLAMMABILITY CLASSIFICATION: 1A. WT/GAL = 6.94
LBS.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: 40 PSI
Vapor Density: >AIR
Evaporation Rate & Reference: FASTER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: RED COLOR; PAINT SOLVENT ODOR
Percent Volatiles by Volume: 85.000
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: DO NOT STORE ABOVE 120F. KEEP FROM SPARKS, PILOT
LIGHTS OR OPEN FLAME.
Materials To Avoid: NONE
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE
Hazardous Polymerization Indicator: NO
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SECTION 313: XYLENE, ACETONE, ETHYL BENZENE, METHYL
ISO-BUTYL KETONE, ETHYLENE GLYCOL MONOPROPYL ETHER
=======================================================
Other Information
=======================================================
Other Information: HEALTH:1 FIRE:4 REACTIVITY: 1
=======================================================
HAZCOM Label
=======================================================
Product ID: DA 6960 KRYOLIUM BULLDOG RED
Cage: 64557
Company Name: DRUMMOND AMERICAN CORPORATION
Street: 600 CORPORATE WOODS PKWY.
Zipcode: 60061
Label Required IND: Y
Date Of Label Review: 04/20/2001
Status Code: A
Origination Code: G
Hazard And Precautions: IRRITATION OR RESPIRATORY SYSTEM, EYES AND SKIN,
ORGANS EFFECTED: EYE, SKIN IRRITATION, DERMATITIS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ASBESTOS FILLED SPIRAL WOUND GASKET
CAGE:58156
CAGE:4A760
CAGE:58156
============= Composition/Information on Ingredients =============
Ingred Name:ASBESTOS, CHRYSOTILE
CAS:12001-29-5
RTECS #:CI6478500
Other REC Limits:NONE RECOMMENDED
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:2 FIBERS/CC; A1;9293
Ingred Name:NATURAL LATEX
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE:MINOR EYS/SKIN IRRITATION.
INGESTION- IRRITATION OF GI TRACT. INHALATION-IRRITATION OF
RESPIRATORY TRACT. CHRONIC: ASBESTOSIS, LUNG CANCER, &
MESOTHELIOMA, ALL OF WHICH ARE DISABLING AND FATAL D ISEASES OF THE
LUNG. INHALATION AND INGESTION OF ASBESTOS FIBERS MAY CAUSE CANCER
OF THE BOWEL.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS ASBESTOS
[12001-29-5], AN OSHA REGULATED CARCINOGEN.
Effects of Overexposure:INHALATION: FATIGUE AND SHORTNESS OF BREATH
THAT GETS WORSE WITH TIME AND EVENTUALLY BECOMES DISABLING. EYES:
IRRITATION. SKIN: IRRITATION. INGESTION: MILD STOMACH DISTRESS.
DIARRHEA, VOMITING, AND NA USEA.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND TUBERCULOSIS
ARE ALL GENERALLY AGGRAVATED BY EXPOSURE TO ASBESTOS FIBERS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. SEE DOCTOR. EYES: RINSE
THOROUGHLY WITH WATER FOR 15 MINUTES. SEE DOCTOR. SKIN: WASH
THOROUGHLY WITH SOAP AND WATER. IF IRRITATION PERSISTS, SEE DOCTOR.
INGESTION: DIL UTE WITH WATER. DO NOT INDUCE VOMITING.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Flash Point:NOT REQUIRED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM THE MATERIAL WITH A HEPA FILTERED
VACUUM. THE EQUIPMENT SHALL BE USED & EMPTIED SO AS TO MINIMIZE THE
RE-ENTRY OF ASBESTOS INTO THE WORKPLACE. OTHERWISE, WET THE
MATERIAL WITH WATER & SURFACTAN T AND THEN SHOVEL OR MOP UP
CONTAMINATION.
======================Handling and Storage ======================
Handling and Storage Precautions:ITEM IS NONFRIABLE & WILL NOT SHED
FIBERS IN NORMAL USE AND STORAGE. USED ITEMS SHALL BE WETTED
BEFORE, DURING & AFTER DISASSEMBLY.
Other Precautions:IF IT IS NECESSARY TO CUT OR IMPACT THE ITEM WHILE
INSTALLING IT, WEAR A RESPIRATOR AND PROTECTIVE CLOTHING. USED
ITEMS SHALL BE IDENTIFIED AND DISPOSED OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDE RAL REGULATIONS FOR ASBESTOS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR A NIOSH/MSHA APPROVED HEPA RESPIRATOR IF
REQUIRED. WEAR SELF-CONTAINED BREATHING APPARATUS IF REQUIRED FOR
HIGH LEVELS OF CONTAMINATES.
Ventilation:LOCAL EXHAUST SUFFICIENT TO ENTRAIN ALL PARTICULATE
EMISSIONS. HEPA FILTER REQUIRED. NO LEAKS ON PRESSURE SIDE OF FAN.
Other Protective Equipment:USE COVERALLS OR DISPOSABLE CLOTHING.
Work Hygienic Practices:WET WORK TO THE DEGREE POSSIBLE. WASH HANDS
AFTER HANDLING ITEM. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:T6
Spec Gravity:2.5 (WATER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT BLUE, NO ODOR
Percent Volatiles by Volume:0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG MINERAL ACIDS, AND STRONG ALKALIS
Stability Condition to Avoid:ACCUMULATIONS OF DUST
Hazardous Decomposition Products:ASBESTOS DUST
==================== Disposal Considerations ====================
Waste Disposal Methods:WET THE MATERIAL WITH WATER AND SURFACTANT.
PLACE IN 6 MIL THICK POLYETHYLENE PLASTIC BAG. PLACE THESE BAGS
INTO ANOTHER POLY BAG OR A SAFE PLACE UNTIL IT CAN BE SHIPPED TO AN
APPROVED DISPOSAL SITE. IDENTIFY WITH ASBESTOS CANCER WARNING
LABEL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:JERIS HAIR TONIC WITHOUT OIL
CAGE:ACLUB
CAGE:ACLUB
============= Composition/Information on Ingredients =============
Ingred Name:ETHYL ALCOHOL (MFR CAS # 61-17-5)
CAS:64-17-5
RTECS #:KQ6300000
Fraction by Wt: 70%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION AND SLIGHT TO MODERATE CNS
DEPRESSION MAY BE EVIDENCED BY GIDDINESS, HEADACHE AND NAUSEA.
PRE-EXISTING EYE, SKIN AND RESPIRATORY DISORDERS MAY BE AGGRAVATED
BY EXPOSURE. IMPAIRED LIVER FUNC TION FROM PRE-EXISTING DISORDERS
ALSO MAY BE AGGRAVATED.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE. IMPAIRED LIVER
FUNCTION FROM PRE-EXISTING DISORDERS ALSO MAY BE AGGRAVATED.
======================= First Aid Measures =======================
First Aid:INGEST: CALL MD IMMEDIATELY . EYES: FLUSH EYES WITH PLENTY OF
WATER FOR AT LEAST 15 MINUTES. SKIN: FLUSH SKIN WITH WATER. INHAL:
MOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS DIFFI
CULT. GIVE ARTIFICIAL RESPIRATION.
===================== Fire Fighting Measures =====================
Flash Point:78.0F,25.6C
Extinguishing Media:USE WATER, "ALCOHOL" FOAM, DRY CHEMICAL OR CARBON
DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . FLAMMABLE.
Unusual Fire/Explosion Hazard:NONE LISTED.
================== Accidental Release Measures ==================
Spill Release Procedures:LG SPILL: EVAC AREA. WEAR PROT CLTHG. SHUT OFF
SOURCE OF LEAK. DIKE & CONTAIN. IF VAP CLOUD FORMS, WATER FOG MAY
BE USED. CONTAIN RUN-OFF. REMOVE W/VACUUM TRUCK OR PUMP. SOAK UP
REST WITH CLAY/SAND. F LUSH AREA W/WATER. STORE IN
NON-LEAKINGCNTNR.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREAS.
FLAMMABLE LIQUID, KEEP AWAY FROM HEAT.
Other Precautions:AVOID EXCESSIVE EXPOSURE. KEEP CONTAINERS IN COOL
AREAS. DO NOT PUNCTURE OR CRUSH CONTAINER. DO NOT WELD OR DRILL ON
OR NEAR CONTAINERS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:USE EXPLOSIVE-PROOF VENTILATION.
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:AVOID EXCESSIVE EXPOSURE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:172F,78C
Spec Gravity:0.89
Solubility in Water:YES
Appearance and Odor:BRIGHT YELLOW LIQUID; FLORAL AND ALCOHOL ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE LISTED.
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . PLACE IN NON-LEAK CONTAINER. PLACE
CONTAINER IN APPROVED RCRA FACILITY FOR HAZARDOUS WASTE. SEAL
TIGHTLY AND LABEL PROP ERLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:NPM-101, PESTICIDES MIXTURE #1 FOR METHOD 507
CAGE:0MU35
CAGE:0MU35
============= Composition/Information on Ingredients =============
Ingred Name:METHYL TERT BUTYL ETHER (MTBE), 2-METHOXY-2-METHYL PROPANE
CAS:1634-04-4
RTECS #:KN5250000
Fraction by Wt: 99.21%
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:AMETRYNE
CAS:834-12-8
RTECS #:XY9100000
Fraction by Wt: 0.132%
Ingred Name:CYCLOATE
CAS:1134-23-2
RTECS #:GU7200000
Fraction by Wt: 0.132%
Ingred Name:FENAMIPHOS
CAS:22224-92-6
RTECS #:TB3675000
Fraction by Wt: 0.132%
ACGIH TLV:0.1 MG/CUM (SKIN)
Ingred Name:MERPHOS
CAS:150-50-5
RTECS #:TG5600000
Fraction by Wt: 0.132%
Ingred Name:DISULFOTON
CAS:298-04-4
RTECS #:TD9275000
Fraction by Wt: 0.132%
ACGIH TLV:0.1 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:PROMETON; 2-METHOXY-4,6-BIS ISOPROPYLAMINO!-S-TRIAZINE
CAS:1610-18-0
RTECS #:XY4200000
Fraction by Wt: 0.132%
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DIRECT PHYSICAL CONTACT SHOULD BE
AVOIDED. TOXIC, IRRITANT.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:EYES & SKIN: FLUSH W/WATER. INHALATION: REMOVE TO FRESH AIR,
GIVE OXYGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER, WATER SPRAY
Fire Fighting Procedures:COMBUSTIBLE LIQUID
================== Accidental Release Measures ==================
Spill Release Procedures:LEAKING BOTTLE MAY BE PLACED IN PLASTIC BAG.
LIQUID MAY BE ABSORBED ON VERMICULITE OR SAND.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED IN A COOL, DRY
PLACE.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:WEAR OSHA/MSMA APPROVED SAFETY EQUIPMENT
INCLUDING CHEMICAL RESISTANT CLOTHING, LABORATORY COAT, RUBBER
APRON.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Appearance and Odor:COLORLESS LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
==================== Disposal Considerations ====================
Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED
W/AFTERBURNER & SCRUBBER I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HUMISORB
CAGE:84066
CAGE:84066
============= Composition/Information on Ingredients =============
Ingred Name:BENTONITE (AS NUISANCE DUST OR PARTICULATES NOT OTHERWISE
REGULATED)
CAS:1302-78-9
RTECS #:CT9450000
Fraction by Wt: 100%
Other REC Limits:NONE
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST;8990
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MAY GENERATE SMALL AMOUNTS OF
RESPIRABLE CRYSTALLINE QUARTZ IF PACKAGES ARE TORN AND MATERIAL
CRUSHED,CREATING DUST.
Effects of Overexposure:INHALATION:COUGH,DYSPNEA,WHEEZ,IMPAIRED
PULMONARY FUNCTION;EYES:IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH RESPIRATORY ILLNESS.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH PLENTY OF WATER;INHALATION:REMOVE TO FRESH
AIR,GIVE OXYGEN/CPR IF NEEDED.SEE DOCTOR.
===================== Fire Fighting Measures =====================
Extinguishing Media:APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM LOOSE MATERIAL FROM TORN BAGS TO AVOID
GENERATING AIRBORNE DUST. WEAR RESPIRATOR. DO NOT ADD WATER.PRODUCT
WILL BECOME SLIPPERY WHEN MOISTENED.
======================Handling and Storage ======================
Handling and Storage Precautions:NO SPECIAL PRECAUTIONS FOR NORMAL
HANDLING. KEEP CONTAINERS CLOSED. PRODUCT ABSORBS WATER.
Other Precautions:NONE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED DUST RESPIRATOR FOR EXPOSURE
OF CONCERN.
Ventilation:NO SPECIAL REQUIREMENTS.(LOCAL EXHAUST,OPTIONAL IF DUSTING
IS ANTICIPATED).
Other Protective Equipment:NONE.
Work Hygienic Practices:DO NOT BREATHE DUST.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:2.5
Solubility in Water:3%
Appearance and Odor:BAGS CONTAINING BENTONITE CLAY.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE
==================== Disposal Considerations ====================
Waste Disposal Methods:BURY IN APPROVED SANITARY LANDFILL I/A/W ALL
APPLICABLE FEDERAL,STATE & LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DRI-KLEAN
CAGE:49310
CAGE:49310
============= Composition/Information on Ingredients =============
Ingred Name:VM&P NAPHTHA (LIGROINE)
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 96%
Other REC Limits:STEL 400 PPM
OSHA PEL:300 PPM/400 STEL
ACGIH TLV:300 PPM; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, DEFATTING, &
DERMATITIS. EYE: IRRITATION, REDNESS, TEARING, & BLURRED VISION.
INGESTION: ASPIRATION INTO LUNGS CAN BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION, DEFATTING, & DERMATITIS. EYE:
IRRITATION, REDNESS, TEARING, & BLURRED VISION. INGESTION:
ASPIRATION INTO LUNGS IS FATAL.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
WASH THOROUGHLY W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:105F
Extinguishing Media:CO2, FOAM, WATER SPRAY, & DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS W/A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM EVEN IF EMPTY BECAUSE PRODUCT OR RESIDUE CAN IGNITE
EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH W/WATER INTO A RETAINING AREA OR
CONTAINER. AVOID EXPOSURE TO SPARKS, HEAT, & OPEN FLAME. FOR SMALL
SPILLS: MOP UP.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS, & OPEN
FLAMES. USE W/ADEQUATE VENTILATION. AVOID CONTACT W/SKIN. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:NEVER USE WELDING OR CUTTING TORCH NEAR OR ON DRUM,
EMPTY OR NOT. DON'T GIVE AWAY EMPTY DRUMS TO INDIVIDUALS, USE
PROPER DISPOSAL METHODS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF >TLV, A NIOSH/MSHA JOINTLY APPROVED AIR
SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL
CONTROL.
Ventilation:PROVIDE SUFFICIENT MECHANICAL/LOCAL EXHAUST VENTILATION TO
KEEP <TLV.
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F
Vapor Pres:2.0
Vapor Density:4.9
Spec Gravity:0.785
Evaporation Rate & Reference:(ETHER = 1): 70
Solubility in Water:EMULSIFIES
Appearance and Odor:COLORLESS THIN LIQUID W/A FAINT WINTER GREEN ODOR.
Percent Volatiles by Volume:96%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, & OPEN FLAME
Hazardous Decomposition Products:CO
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE OR DISPOSE OF IN ACCORDANCE W/LOCAL,
STATE, & FEDERAL REGULATIONS. DON'T GIVE AWAY EMPTY DRUM TO
INDIVIDUAL, USE PROPER DISPOSAL METHODS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CPS294831, ASPHALT EMULSION RS-1
CAGE:0AHD1
CAGE:0AHD1
============= Composition/Information on Ingredients =============
Ingred Name:ING 5:OF PETRO HYDROCARBONS CALLED MID-DISTILS. TOXICOLOGY
DATA DEVEL FOR SIMILAR MID-DISTILS SUPPORT CONCLUSION (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:THAT MATL MAY POSE INCR RISK OF SKIN CANCER FOLLOWING
PRLNG/RPTD SKIN CONTACT.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC:IF MED ADVICE CANNOT BE OBTAINED, THEN TAKE
PERS & PROD CNTNR TO NEAREST MED EMER TREATMENT CTR/HOSPITAL.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC:APPROP, REMOVE CONTAM SOIL. FOLLOW PRESCRIBED
PROCS FOR REPORTING & RESPONDING TO LARGER RELEASES.
RTECS #:9999999ZZ
Ingred Name:OTHER PREC:CNTNR. REPLACE CAP/BUNG. EMPTIED CNTNR STILL
CONTAINS HAZ MATL WHICH MAY IGNITE W/EXPLO VIOLENCE IF (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:HEATED SUFFICIENTLY. CAUTION! DO NOT USE PRESS TO
EMPTY DRUM/EXPLO MAY RESULT.
RTECS #:9999999ZZ
Ingred Name:ASPHALT
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 60%
ACGIH TLV:5 MG/M3 FUME
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 38%
Ingred Name:NAPHTHA (PETROLEUM), LIGHT STRAIGHT-RUN; (NAPHTHA, LIGHT
STRAIGHT RUN)
CAS:64741-46-4
RTECS #:QK8000300
Fraction by Wt: 2%
Ingred Name:SUPDAT:SKIN CONT W/ASPHALT PROD IS NOT EXPECTED TO PRDCE
ANY DELAYED EFTS. WHILE NORM HNDLG OF PROD IS NOT LIKELY(ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4:TO CAUSE CANCER IN HUMANS, SKIN CONT & BRTHG OF
MISTS/FUMES/VAPS SHLD BE REDUCED TO MIN. PROD CONTAINS MIXT(ING 6)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HAZARDS BASED ON EVALUATION OF SIMILAR
MATERIALS. EYE:NOT EXPECTED TO CAUSE PRLNG/SIGNIFICANT IRRIT.
SKIN:EXPECTED TO CAUSE NO MORE THAN MINOR IRRIT, BUT
PRLNG/FREQUENTLY RPTD CONTACT MAY BE HARMFUL. SHOULD BE
PRACTICALLY NON-TOXIC IF IT GETS ON SKIN. INHAL:SUBSTANCE
CONSIDERED PRACTICALLY NON-TOXIC (EFT OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TO INTERNAL ORGANS. INGEST:SYSTEMIC
TOX OF SUBSTANCE HAS NOT BEEN DETERMINED. HOWEVER, SHLD BE
PRACTICALLY NON-TOX TO INTERNAL ORGANS IF SWALLOWED. IARC CONCLUDED
ONLY LTD EVID THAT STEAM-REF INED ASPHALTS WERE CARCIN TO ANIMALS.
MICE EXPOSED TO ASPHALTS DILUTED W/HYDROCARBON SOLVS HAD INCR
INCIDENCE OF(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/FRESH WATER FOR @ LST 15 MIN. REMOVE CONTACT
LENSES IF WORN. SKIN:REMOVE CONTAM CLTHG & WASH THORO W/SOAP &
WATER. DO NOT USE SOLVS/THINNERS TO REMOVE MATLS FROM SKIN. ASPHALT
CAN BE REMOV ED W/VEGETABLE OIL/MINERAL OIL. INHAL:REMOVE TO FRESH
AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) . INGEST:GIVE WATER/MILK TO
DRINK & CALL FOR MED ADVICE. CONSULT MD BEFORE INDUCING VOMIT. (ING
8)
===================== Fire Fighting Measures =====================
Flash Point:>212F,>100C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM & WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. PROD IS EMULSION CNTNG ASPHALT & PETRO DISTILS DISPERSED IN H*2O.
TESTS ON EMULSIONS MAY INDICATE (SUPDAT)
Unusual Fire/Explosion Hazard:MATL NORMALLY WILL NOT BURN. HOWEVER,
DEHYDRATED RESIDUE WILL BURN. NORMAL COMBUST FORMS CO*2, WATER VAP
& MAY PRODUCE SO*X. INCOMPLETE COMBUST CAN PRODUCE CO.
================== Accidental Release Measures ==================
Spill Release Procedures:MATL MAY BE TOX TO AQUATIC ORGANISMS & SHLD BE
KEPT OUT OF SEWAGE & DRAINAGE SYS & ALL BODIES OF WATER. ELIM ALL
OPEN FLAME IN VICIN OF SPILL/RELS VAP. CLEAN UP SM SPILLS USING
APPROP TECHNIQUES SUCH AS SORBENT MATLS/PUMPING. WHERE FEASIBLE &
(ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:READ & OBSERVE ALL PRECS ON PROD LBL.
DO NOT USE/STORE NEAR FLAME, SPKS/HOT SURFS. USE ONLY IN WELL
VENTED AREA. KEEP CNTNR CLSD.
Other Precautions:AVOID CONT W/SKIN/CLTHG. PRLNG/RPTD SKIN CONT CAN BE
HARMFUL. MAY EMIT COMBUST HYDROCARBON VAPS. KEEP OUT OF REACH OF
CHILDREN. HYDROCARBON SOLV IN PROD MAY ACCUM @ EXPLO LEVELS IN
HEADSPACE OF STOR C NTNRS. DO NOT WELD, HEAT/DRILL (ING 10)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:THIS MATERIAL MAY BE INHALATION HAZARD & UNLESS
VENTILATION IS ADEQUATE, USE OF NIOSH/MSHA APPROVED RESPIRATORY
PROTECTION IS RECOMMENDED.
Ventilation:USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS.
Other Protective Equipment:MINIMIZE CONTACT BY WEARING PROTECTIVE
CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:NO FLASH UP TO 212F WHERE WATER BOILS & TEST IS
TERMINATED. DISTILS, HOWEVER, CAN SEPARATE FROM EMULSION, FLOAT TO
SURF, VAPORIZE & THEREBY CREATE HAZ. EFTS OF OVEREXP:CERTAIN TYPES
OFCANCER. PETRO SOLV CNTND IN PROD MAY INCR POTNTL FOR CANCER
FOLLOWING PRLNG & RPTD SKIN CONT. BRIEF/INTERMITTENT(ING 4)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:30.0F,-1.1C
Vapor Pres:60 @ 100F
Spec Gravity:1.01
pH:7-10
Solubility in Water:READILY DISPERSIBLE
Appearance and Odor:DARK TO TAN LIQUID.
Percent Volatiles by Volume:40
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:COMBUSTION MAY FORM:CO*2, WATER VAPOR,
SO*X, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE CONTAM MATLS IN DISPOSABLE CNTNRS &
DISPOSE OF IN A MANNER CONSISTENT W/APPLIC FEDERAL, STATE & LOCAL
REGULATIONS. CONTACT LOC ENVIRON/HLTH AUTHORITIES FOR APPRVD DISP
OF THIS MATL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:RIFLE BORE CLEANER
CAGE:KO679
CAGE:KO679
CAGE:74438
============= Composition/Information on Ingredients =============
Ingred Name:PETROLEUM SOLVENT
Fraction by Wt: 60.0%
ACGIH TLV:200PPM(PER MFR)
Ingred Name:LIGHTWEIGHT OIL
Fraction by Wt: 35.0%
Ingred Name:CORROSION INHIBITOR
Fraction by Wt: 5.0%
===================== Hazards Identification =====================
Effects of Overexposure:SKIN:IRRITATION,DERMATITIS ON PROLNGD
CONTCT;EYES/INH:PROLONGD EXPOSR CAUSES IRRIT,HEADACHE,DROWSNSS
======================= First Aid Measures =======================
First Aid:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEED. SKIN:WASH WITH
SOAP & WATER. EYES:FLUSH WITH WATER 15 MIN. KEEP WARM AND QUIET.
GET MED ATTN IF EYE IRRITATION PERSISTS;ING:DO NOT INDUCE
VOMIT.GIVE 2-4 O Z OLIVE/VEGETABLE OIL & 1-2 OZ ACTIVTD CHARCOAL.
===================== Fire Fighting Measures =====================
Flash Point:125F(T.C.C)
Lower Limits:0.7
Upper Limits:5.0
Extinguishing Media:DRY CHEM PREFERRED.FOAM & H*2O ALSO APPLICABLE.
Fire Fighting Procedures:USE FOAM & H*2O SPARY CAREFULLY TO PREVENT
EXCESSIVE FROTHNG
Unusual Fire/Explosion Hazard:KEEP AWAY FROM HEAT OR OPEN FLAMES.CAN
REACT W/OXIDIZING MATERIAL COMBUSTIBLE.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE UNPROTECTED PERSONS. ELIM IGNITION
SOURCES. STOP LEAK. H*2O SPRAY COOL CONT/DIVERT SPILL FROM
FIRE/HEAT. PROVIDE VENTILATION. ABSORB W COMMERCIAL
ABSORBENT,SHOVEL INTO METAL DRUMS:LG SPILL:DI KE W COMMERCIAL
ABSORBENT,PUMP INTO COVERED DRUMS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTNRS TIGHTLY CLOSED.DO NOT
STORE/MIX W/STRONG OXIDANTS.STORE IN COOL WELL-VENTILATED AREA.
Other Precautions:STORE AWAY FROM POSSIBLE SOURCES OF IGNITION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE IN NORMAL USE; VAP REMOVING AIR PURIFYNG
RESP FOR MIST/SPRAY.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV.
Other Protective Equipment:WEAR FULL PROTECTIVE CLOTHING.
Supplemental Safety and Health
MSDS UNDATED:SPEC REFERENCE:MIL-C-372C.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:181-290C
Vapor Pres:NEG
Vapor Density:4.5
Spec Gravity:0.840
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,PALE LUBRICATING OIL
Percent Volatiles by Volume:64%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS SUCH AS CHLORINE & CONC OXYGEN.
Hazardous Decomposition Products:CO IN CASE OF INCOMPLETE COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN APPROVED INCINERATOR OR DISPOSE OF
IN APPROVED CHEMICAL DUMP IN ACCORDANCE WITH LOCAL,STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:CONCISE COMPOSITE PASTE "B"
Kit Part:Y
CAGE:76381
CAGE:76381
============= Composition/Information on Ingredients =============
Ingred Name:SILANE TREATED CRYSTALLINE SILICON DIOXIDE; WT %
RANGE:70-80%
Fraction by Wt: 75.0%
ACGIH TLV:5MG/CUM(DUST
Ingred Name:MONO & DI METHACRYLATES; WT % RANGE:10-20%
Fraction by Wt: 15.0%
Ingred Name:INORGANIC PIGMENTS/FILLERS: WT % RANGE 0-5%
Fraction by Wt: <5.0%
Ingred Name:INHIBITORS; WT % RANGE: 0.0-1.0
Fraction by Wt: <1.0%
Ingred Name:BENZOYL PEROXIDE; WT % RANGE: 0.0-0.5
CAS:94-36-0
RTECS #:DM8575000
Fraction by Wt: <0.5%
ACGIH TLV:5 MG/CUM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE SEVERE
BURNS,IRRITATION,TISSUE DAMAGE. SKIN:SEVERE IRRITATION.
INHALATION:MIST AND VAPOR CAUSE RESPIRATORY SYSTEM IRRITATION.
Medical Cond Aggravated by Exposure:ANY PREEXISTING SENSITIVITY OR
ALLERGY.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH EYES W/LG AMT OF WATER & CONSULT PHYSICIAN;SKIN:
WIPE OFF W/CLOTH/TISSUE.WASH WITH SOAP & WATER; INHALATION
INGESTION:NOT KNOWN.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:USE APPROPRIATE SAFETY EQUIPMENT IF
NEEDED.WIPE UP SMALL SPILL & PLACE IN DISPOSAL CONTAINER; FOR LG
QTY TRANSFER PASTE TO A SALVAGE TANK & COVER. CLEAN AREA W/SUITABLE
SOLVENT & DRY.
Neutralizing Agent:NONE
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT. KEEP
CONTAINERS TIGHTLY CLOSED
Other Precautions:AVOID EYE & SKIN CONTACT.SEE PRODUCT LABEL FOR MORE
INFO;CRYSTALLINE SILICON DIOXIDE CAN PRODUCE LUNG DISEASE IF
INHALED,HOWEVER,IN THIS FORM EXPOSURE IS UNLIKELY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED.
Ventilation:NORMAL ROOM VENTILATION.
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
KIT CONSISTS OF 5 PARTS (ETCHING LIQUID,PASTE PARTS A & B, AND RESIN
PARTS A & B). THIS DATA DESCRIBES PASTE PART B. FOR OTHER PARTS,
SEE OTHER PNI'S, SAME NSN. KEY1:N1.
================== Physical/Chemical Properties ==================
HCC:C1
Spec Gravity:2.33
Solubility in Water:NEGLIBIBLE
Appearance and Odor:TOOT COLORED PASTE,SLIGHT ACRYLATE ODOR.
Percent Volatiles by Volume:NIL
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NOT KNOWN
Hazardous Decomposition Products:INCOMPLETELY BURNED CARBON PRODUCTS,
CO*2, CO.
==================== Disposal Considerations ====================
Waste Disposal Methods:DUE TO SMALL AMOUNTS,DISPOSE OF AS ORDINARY
WASTE IN APPROVED LANDFILL.SINCE REGULATIONS VARY,CONSULT
APPLICABLE REGULATIONS OR AUTHORITIES BEFORE DISPOSAL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ACRYLOID B-72 50% RESIN, 66753
CAGE:GO264
CAGE:GO264
CAGE:77902
============= Composition/Information on Ingredients =============
Ingred Name:ACRYLIC COPOLYMER
Fraction by Wt: 49-51%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:RESIDUAL MONOMER
Fraction by Wt: 0.6%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 49-51%
OSHA PEL:200 PPM
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:SPILL PROC: FOR RECOVERY OR DISPOSAL AND SOLID DIKING
MATERIAL TO SEPARATE CONTAINERS FOR DISPOSAL. KEEP SPILLS (ING 5)
RTECS #:9999999ZZ
Ingred Name:ING 4: AND CLEANING RUNOFFS OUT OF MUNICIPAL SEWERS AND
OPEN BODIES OF WATER. NOTE: SPILLS ON POROUS SURFACES (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: CAN CONTAMINATE GROUNDWATER.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: SOLVENT VAPOR OR MIST CAN CAUSE
HEADACHE, DIZZINESS, NAUSEA, LOSS OF CONSCIOUSNESS & IRRIT OF NOSE,
THROAT & LUNGS. SKIN CONTACT: IRRITATING TO SKIN UPON RPTD/PRLNGD
CONTACT. LIQUID SUBSTANCE C AN BE ABSORBED THRU INTACT SKIN IN
HARMFUL AMOUNTS. EYE CONTACT: SUBSTANCE CAN CAUSE IRRIT & TRANSIENT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CORNEAL INJURY. CHRONIC: TOLUENE
APPEARS ON THE NAVY LIST OF OCCUPATIONAL CHEMICAL REPRODUCTIVE
HAZARDS. SEEK CONSULTATION FROM APPROP HEALTH PROFESSIONALS
CONCERNING LATEST HAZ LIST INFO & SAFE HANDLING & EXPOSURE INFO .
RPTD OVEREXP TO TOLUENE CAN CAUSE CNS EFTS. EFTS OF OVEREXP ARE
BASED ON (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: MOVE TO FRESH AIR. GIVE ARTF RESP IF BRTHG HAS
STOPPED. SEE MD. EYES: FLUSH EYES W/LARGE AMT OF WATER FOR AT LEAST
15 MIN. SEE MD IF IRRIT PERSISTS. WASH AFFECTED SKIN AREAS W/SOAP &
WATER. ING EST: IF SWALLOWED GIVE TWO GLASSES OF WATER TO DRINK.
SEE MD. NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. NOTE TO
MD: PROD CONTAINS TOLUENE, A PETRO DISTIL HAVING CNS EFTS. CAREFUL
(SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:44.6F,7.0C
Lower Limits:1.2%
Upper Limits:7.1%
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER
SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS CAN TRAVEL TO A SOURCE OF IGNITION
AND FLASH BACK. MATERIAL CAN FORM EXPLOSIVE VAPOR WITH AIR.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE IGNITION
SOURCES. WEAR NIOSH APPROVED RESP (PRESSURE-DEMAND, SCBA OR
EQUIVALENT) OR AIR MASK FOR LARGE SPILLS IN CONFINED AREA. DIKE &
CONTAIN SPILL W/INERT MATL (EG, S AND, EARTH). TRANSFER LIQUID TO
CONTAINERS (ING 4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMPERATURE: -18C/0F TO
60C/140F. LIMIT STORAGE OF FLAMMABLE MATERIAL TO APPROVED AREAS.
GROUND ALL CONTAINERS WHEN TRANSFERRING MATERIAL.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
WEAR NIOSH APPROVED RESPIRATOR SUITABLE FOR CONCENTRATIONS AND
TYPES OF AIR CONTAMINANTS ENCOUNTERED.
Ventilation:EXPLOSION-PROOF LOCAL EXHAUST VENTILATION AT POINT OF
CONTAMINANT RELEASE.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: 50-52 (WT). EFTS OF OVEREXP: INFO ABOUT SIMILAR MATLS & ON
TOXICITY PROFILES FOR SOLVENTS USED IN THIS PROD. NOTE: OVEREXP TO
TOLUENE HAS CAUSED EMBRYOFETOTOXIC EFTS IN LAB ANIMALS. FIRST AID
PROC: GASTRIC LAVAGE MAY BE INDICATED BECAUSE OF RISK OF ASPIRATION
POSED BY PETROLEUM DISTILLATES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:230F,110C
Melt/Freeze Pt:M.P/F.P Text:-139F,-95C
Vapor Pres:22 @ 20C
Vapor Density:>1
Spec Gravity:1.0 (H*2O=1)
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, VISCOUS LIQUID; SOUR, BURNT ODOR.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISCARDED THIS MATERIAL IS A HAZARDOUS
WASTE. RCRA #U-220, RQ 2000 LBS (40 CFR 302, SUPERFUND). INCINERATE
LIQUID AND CONTAMINATED MIXING MATERIAL AT A PERMITTED FACILITY IN
ACCORDANCE WITH LOCAL , STATE AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MT TONER II, EP4230
CAGE:GO339
CAGE:GO339
CAGE:23736
============= Composition/Information on Ingredients =============
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 1-5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Ingred Name:PROPENE POLYMERS; (POLYPROPYLENE)
CAS:9003-07-4
RTECS #:UD1842000
Fraction by Wt: 1-3%
Ingred Name:STYRENE-ACRYLATE COPOLYMER
Fraction by Wt: >80%
Ingred Name:COPPER OXIDE
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: 5-10%
OSHA PEL:1 (CU) MG/M3 DUST
ACGIH TLV:1 (CU) MG/M3 DUST
Ingred Name:ORGANIC PIGMENT
Fraction by Wt: 1-5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50:(ORAL ORAT) >5 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESP TRACT IRRIT MAY
OCCUR AS W/EXPOS TO LGE AMTS OF ANY NONTOXIC DUST. MAY CAUSE COUGH
& RAISE PHLEGM. CHRONIC: NONE. TONER PRESENTS A LOW HAZARD FOR
USUAL OCCUP SETTINGS. BASED ON AVA IL DATA, HUMAN EXPOS TO TONER
HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR W/LGE
AMTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF ANY NONTOXIC DUSTS. RSLTS OF ONE
ANIMAL STUDY WHERE RATS INHALED TONER THAT WAS 10X MORE RESPIRABLE
THAN COMMERCIALLY AVAIL TONER WERE OBSERVED TO HAVE NO LUNG CHANGES
AT LOW EXPOS (THE MO ST RELEVANT LEVEL TO POTNTL HUMAN EXPOS). AT
HIGHER LEVELS A SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL: WASH NOSTRILS & RINSE MOUTH. INGEST: DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF WATER. EYE: FLUSH W/WATER FOR AT
LEAST 15 MINS. SKIN: WASH W/SOAP & WATER.
===================== Fire Fighting Measures =====================
Extinguishing Media:WATER, FOAM & DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.
================== Accidental Release Measures ==================
Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE.
Other Precautions:TONER, AS A MIXTURE, IS CONSIDERED A NUISANCE DUST.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EFTS OF OVEREXP:DUE TO EXCESSIVE AMOUNTS OF DUST RETAINED IN THE LUNGS
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER; FAINT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY W/FEDERAL, STATE & LOCAL
REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:ACETYLCHOLINE BROMIDE (1:10,000 SOLUTION),38-2021
Preparer's Name:MICHAEL RESZEJA
CAGE:EO227
CAGE:EO227
CAGE:63759
============= Composition/Information on Ingredients =============
Ingred Name:ACETYLCHOLINE BROMIDE/CHOLINE ACETATE,BROMIDE
CAS:66-23-9
RTECS #:FZ9680000
Fraction by Wt: 0.01%
Other REC Limits:NONE RECOMMENDED
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: BALANCE
Other REC Limits:NONE RECOMMENDED
OSHA PEL:NOT RELEVANT
ACGIH TLV:NOT RELEVANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE. ACUTE- EYE:NO
SPECIFIC HAZARD KNOWN. MAY CAUSE TRANSIENT IRRITATION. SKIN:LOW
HAZARD FOR RECOMMENDED HANDLING. INHALE:UNLIKELY. ORAL:EXPECTED TO
BE A LOW INGESTION HAZARD AT THIS CO NCENTRATION. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:TRANSIENT EYE IRRITATION
Medical Cond Aggravated by Exposure:NONE
======================= First Aid Measures =======================
First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:UNLIKELY.
EYES:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN.
SKIN:FLUSH WITH WATER, THEN WASH SKIN WITH MILD SOAP & WATER.
ORAL:IF CONSCIOUS, DRI NK 1-2 GLASSES OF WATER. GET MEDICAL
ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:NOT RELEVANT
Upper Limits:NOT RELEVANT
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR PROTECTIVE CLOTHING AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS IF NEEDED.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNT OF WATER IF
PERMITTED. OTHERWISE, ABSORB SPILL WITH INERT MATERIAL SUCH AS
VERMICULITE. PLACE IN A CONTAINER FOR DISPOSAL.
Neutralizing Agent:NOT RELEVANT
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL PLACE.
Other Precautions:DO NOT GET IN EYES. KEEP OUT OF REACH OF CHILDREN.
FOR LABORATORY USE ONLY. NOT FOR DRUG, FOOD/HOUSEHOLD USE. USE WITH
ADEQUATE VENTILATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY NEEDED. IF EXCESSIVE MISTING IS
EXPECTED, WORK IN VENTILATION HOOD OR WEAR NIOSH-APPROVED
RESPIRATOR.
Ventilation:ADEQUATE
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:32.0F,0.0C
Vapor Pres:14
Vapor Density:0.7
Spec Gravity:1.00
Evaporation Rate & Reference:1 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS WATER SOLUTION - ODORLESS
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ALKALINE MATERIALS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:NONE EXPECTED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT OR DISPOSAL MAY BE SUBJECT
TO FEDERAL, STATE OR LOCAL REGULATIONS. FLUSH TO SEWER WITH LARGE
AMOUNT OF WATER.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:52620 TM 185 YELLOW
CAGE:SERIC
CAGE:SERIC
CAGE:SSERI
============= Composition/Information on Ingredients =============
Ingred Name:CYCLOHEXANONE, KETOHEXAMETHYLENE
CAS:108-94-1
RTECS #:GW1050000
Other REC Limits:100PPM (SKIN) STEL
OSHA PEL:50 PPM
ACGIH TLV:100 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:DIBASIC ESTER
Ingred Name:HEAVY AROMATIC SOLVENT NAPHTHA PETROLEUM *97-4*
CAS:64742-94-5
RTECS #:WF3100000
Ingred Name:PIGMENTS
Ingred Name:VOLATILE ORGANIC CONTENT: 625 G/L
RTECS #:9999999VO
Ingred Name:ACETIC ACID, C6-8-BRANCHED ALKYL ESTERS, C3-8-BRANCHED
ALKYL ESTERS ACETIC ACID
CAS:90438-79-2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: IRRITATION OF DIGESTIVE
TRACT. NERVOUS SYTEM DEPRESSION. ASPIRATION DURING
SWALLOWING/VOMITING CAN CAUSE LUNG INFLAMMATION/DAMAGE. SKIN:
PROLONGED/REPEATED OVEREXPOSURE MAY CAUSE DERMATITIS /ABSORPTION.
EYES: SEVERE IRRITANT/BLURRED VISION. INHALATION: NOSE/RESPIRATORY
TRACT IRRITATION. LIVER/KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DIARRHEA,
DROWSINESS, DIZZINESS, LOSS OF COORDINATION, FATIGUE, INFLAMMATION,
HEADACHES, REDNESS, BURNING, DEFATTING OF SKIN, TEARING, BLURRED
VISION.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISORDERS,
ASTHMA-LIKE CONDITIONS, SENSITIZATIN, ALLERGIES.
======================= First Aid Measures =======================
First Aid:INGESTION: DRINK 2 GLASSES OF WATER TO DILUTE. DON'T INDUCE
VOMITING. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. SKIN: WASH
THOROUGHLY W/SOAP & WATER. INHALATION: REMOVE TO A WELL VENTILATED
AREA. G IVE OXYGEN/CPR IF NECESSARY. EYES: FLUSH W/COPIOUS AMOUNTS
OF WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.
TREATMENT SHOULD BE DIRECTED AT CONTROL OF SYMPTOMS & CLINICAL
CONDITION.
===================== Fire Fighting Measures =====================
Flash Point:>110F
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT. WATER MAY BE
UNSUITABLE FOR BURNING LIQUIDS. IF WATER IS USED, FOG NOZZLES ARE
PREFERRED. WATER MAY BE USED TO COOL CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM IGNITION SOURCES & HOT SURFACES. CLOSED CONTAINERS MAY
RUPTURE/EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:USING NON-SPARKING TOOLS, PLACE LEAKING
CONTAINERS IN A WELL VENTILATED AREA. AVOID BREATHING VAPORS.
ELIMINATE ALL SOURCES OF HEAT, SPARKS/IGNITION.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED STORAGE AT
TEMPERATURES IN EXCESS OF 100F.
Other Precautions:DON'T BREATHE VAPORS/SPRAY MISTS. MINIMIZE SKIN
CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR AN APPROPRIATE, PROPERLY FITTED RESPIRATOR
(NIOSH/MSHA APPROVED) DURING & AFTER APPLICATION UNLESS AIR
MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE BELOW APPLICABLE
LIMITS.
Ventilation:LOCAL EXHAUST: TO CONTROL EXPOSURE TO MIST/AEROSOLS.
GENERAL EXHAUST TO MINIMIZE EXPOSURE TO VAPORS.
Other Protective Equipment:IMPERMEABLE APRONS, BOOTS, SAFETY SHOWER,
EYE BATH
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING, USING TOBACCO PRODUCTS/USING THE
WASHROOM.
Supplemental Safety and Health
TOBACCO & FOOD SHOULD BE CONSUMED IN DESIGNATED AREAS ONLY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:312.8-419F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Appearance and Odor:SOLVENT EVAPORATIVE SCREEN INK
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZERS, ALKALI METAL HYDROXIDES
Stability Condition to Avoid:HEAT, SPARKS, ELECTRICAL EQUIPMENT, OPEN
FLAMES & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO, CO2, MIXED OXIDES OF NITROGEN,
METHYL METHACRYLATE, N-BUTYL METHACRYLATE/HYDROGEN CHLORIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:T4500 THEOBROMINE CRYSTALLINE
CAGE:21076
CAGE:21076
============= Composition/Information on Ingredients =============
Ingred Name:THEOBROMINE CRYSTALLINE
CAS:83-67-0
RTECS #:XH2275000
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT):1265 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INGESTED, INHALED/ABSORBED
THROUGH SKIN & MAY CAUSE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, ANOREXIA.
======================= First Aid Measures =======================
First Aid:INGESTION: WASH OUT MOUTH W/WATER IF CONSCIOUS. SKIN/EYES:
FLUSH W/COPIOUS AMOUNTS OF WATER FOR 15 MINS. INHALATION: REMOVE TO
FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:CO2, DRY CHEMICAL POWDER/APPROPRIATE FOAM.
Fire Fighting Procedures:WEAR SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.
================== Accidental Release Measures ==================
FOR WASTE DISPOSAL. VENTILATE AREA & WASH SITE AFTER MATERIAL
PICKUP IS COMPLETE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR.
Ventilation:CHEMICAL FUME HOOD.
Other Protective Equipment:SUITABLE PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Solubility in Water:INSOLUBLE
Appearance and Odor:SOLID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:COMBUSTION: CO, CO2, NITROGEN OXIDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:INCINERATE IN A FURNACE IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ENPLATE NI-433M
CAGE:EO297
CAGE:EO297
CAGE:02258
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: >60%
Ingred Name:SODIUM HYPOPHOSPHITE
CAS:7681-53-0
RTECS #:WB5950000
Fraction by Wt: <15%
Ingred Name:NICKEL SULFATE (2A CARCINOGEN BY IARC & ACGIH)
CAS:7786-81-4
RTECS #:QR9350000
Fraction by Wt: <15%
OSHA PEL:1 MG NI/M3
ACGIH TLV:0.1 MG NI/M3; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:AMMONIUM HYDROXIDE, AQUA AMMONIA
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <5%
Other REC Limits:25 PPM
OSHA PEL:35 MG/CUM
ACGIH TLV:18 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION. INGESTION: MOUTH, THROAT, ESOPHAGUS & STOMACH
IRRITATION. SKIN: IRRITATION & NICKEL ITCH. EYES: IRRITATION &
DAMAGE. CHRONIC: GENERAL DISCOMFORT, IRRITATION & POSSIBLE SEVERE
SENSITIZATION.
Explanation of Carcinogenicity:SEE INGREDIENTS
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING STOPS,
RESUSCITATE/ADMINISTER OXYGEN IF AVAILABLE. INGESTION: NEVER GIVE
ANYTHING BY MOUTH IF UNCONSCIOUS. IF VOMITING OCCURS SPONTANEOUSLY,
KEEP AIRWAY C LEAR. GIVE PLENTY OF WATER & INDUCE VOMITING. SKIN:
WASH W/PLENTY OF WATER FOR 15 MINS. REMOVE CONTAMINATED CLOTHING &
FOOTWEAR. DISCARD FOOTWEAR IF IT CANNOT BE DECONTAMINATED. SEE
SUPP.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER FOG OR SPRAY, CO2, FOAM
Fire Fighting Procedures:WEAR NIOSH APPROVED FULL PROTECTIVE CLOTHING &
SELF-CONTAINED BREATHING APPARATUS. KEEP CONTAINERS COOL TO PREVENT
RUPTURE & RELEASE OF MATERIAL.
Unusual Fire/Explosion Hazard:HEATING OF DRIED SALTS TO TEMPERATURES
ABOVE 475F MAY RELEASE TOXIC & SPONTANEOUSLY FLAMMABLE PHOSPHINE
GAS.
================== Accidental Release Measures ==================
Spill Release Procedures:AVOID CONTACT W/SKIN, EYES & CLOTHING. WEAR
PROTECTIVE EQUIPMENT. DON'T BREATH MIST OR VAPORS. CONTAIN SPILL &
SOAK UP IN SUITABLE ABSORBENT. SHOVEL INTO PLASTIC LINED STEEL
CONTAINERS. DILUTE RESIDUA L MATERIAL W/PLENTY OF WATER &
NEUTRALIZE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL, DRY PLACE. KEEP AWAY
FROM ALKALIES & OXIDIZERS. LOOSEN COVER CAUTIOSLY WHEN OPENING.
STORE ABOVE FREEZING TEMPERATURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED RESPIRATOR WHEN AIR
CONCENTRATION IS GREATER THAN TLV/PEL. USE CARTRIDGE FILTER FOR
ACID MIST.
Ventilation:LOCAL EXHAUST: RECOMMENDED.
Other Protective Equipment:CHEMICAL RESISTANT COVERALLS, HATS, SHOES OR
BOOTS. EYE WASH & SAFETY SHOWER
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
CON'T: EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. HOLDING
EYELIDS APART. OBTAIN MEDICAL ATTENTION IN ALL CASES.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:220F
Melt/Freeze Pt:M.P/F.P Text:-4F
Spec Gravity:1.258
pH:4.4
Solubility in Water:COMPLETE
Appearance and Odor:GREEN LIQUID W/SLIGHT VINEGAR-LIKE ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS & OXIDIZERS
Stability Condition to Avoid:HEAT
Hazardous Decomposition Products:TOXIC GASES INCLUDING AMMONIA, OXIDES
OF SULFUR, NITROGEN & PHOSPHORUS. SPONTANEOUSLY FLAMMABLE
PHOSPHINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:PC:930G017 DES 420HS C/S (POLYISOCYANATE) PART B
Kit Part:Y
CAGE:83574
CAGE:83574
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PENTANE-2,4-DIONE
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ETHYL-3-ETHOXYPROPIONATE
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9596
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:AROMATIC HYDROCARBON SOLVENT NAPHTHA (PETROLEUM) LIGHT
AROMATIC
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:AROMATIC SOLVENT NAPHTHA (PETROLEUM) HEAVY AROMATIC
CAS:64742-94-5
RTECS #:WF3100000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:TRIMER HDI,TIRMER OF HEXAMETHYLENE DIISOCYANATE <0.2%
MONOMERIC HEXAMETHYLENE DIISOCYANATE(CAS#822-06-0)
CAS:3779-63-3
Fraction by Wt: 50%
Other REC Limits:NONE RECOMMENDED
Ingred Name:N-BUTYL ACETATE (CERCLA)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 10%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM
ACGIH TLV:150 PPM/200STEL;9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:AROMATIC SOLVT:EYE/SKIN:MOD
IRRIT.INHAL:SLIGHT TOXIC.1-BUTYACETATE:EYE:BURN,TEAR,RED,POSSIBLE
TRANS CORN INJURY.SKIN:PROL EXPO
DRY,CRACK.INHAL/INGEST:DROWS,DIZZ,FTG,NAU.MEK:EYE:BURN,TEAR,RED,POS
SIBLE TRANS CORNEAL CLOUDING.SKIN:PROL EXPO
RED,BURN,DRY,CRACK.INHAL:COUGH,CHEST PAINS,THROAT
IRRIT,HEAD,DIZZ,ANESTHETIC(SUPP)
Effects of Overexposure:ETHYL3-ETHOXYPROPIONATE:EYE:IRRIT,RED,SWELL OF
CONJUNC.SKIN:PROL/REP IRIT,DRY,CRACK.INHAL/INGEST:NASAL/RESP
IRRIT,CNS
EFFECTS.(DIZZ,WEAK,FTG,NAU,HEAD,UNCONSC).TOLUENE:EYE:BURN,TEAR,RED.
SKIN:PROL DRY,C RACK,DERM.INHAL:DIZZ,DROWS,FTG,LIV/KID
DMG.INGEST:DROWS,DIZZ,NAU.PETRO:EYE:IRRIT.SKIN:DEFAT,DRY.INHAL:IRRI
T MUC MEMB
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYE:FLUSH W/WATER FOR 15MINS.GET MED ATTN.SKIN:WASH
W/SOAP/WATER.DONT USE SOLVTS.REMOVE CONTAMIN CLOTH.GET MED
ATTN.INHAL:REMOVE TO FRESH AIR FROM EXPO.GIVE ART RESP/CARDIOPULM
RESUSCITATION(CPR)IF BR EATH DIFFI.GET MED ATTN.INGEST:GET MED
ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:56.0F,13.3C
Autoignition Temp:Autoignition Temp Text:NP
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WATERPSRAY MAY BE INEFFECTIVE.COOL FIRE EXPO
CNTNR W/WATER.FOG NOZZ PREFER.WEAR NIOSH/MSHA APPROV SCBA &
PROTECTIVE CLOTH TO PREVENT CONTACT W/SKIN/EYES.
Unusual Fire/Explosion Hazard:VAP MAY ACCUMULATE IN INADEQUATELY
VENTI/CONFINED AREAS.VAP MAY FORM EXPLO MIX W/AIR.VAP MAY TRAVEL
LONG DISTANCES;FLASHBACK/FLAME TO HNDLG SITE MAY OCCUR(SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:PROTECT FROM IGN.WEAR AIR-SUPPL RESP FOR
UNVENTI SPILL.COVER W/ABSORBENT MATL,ADD DECOMO SOLN(5%CONC
AMMONIA,2%DETERGT,93%H2O).ALLOW TO RX 10MINS.COLLECT INCNTNR,ADDN
ADDN DECOMPO SOLN.KEEP LOOSELY CO VER FOR 48HRS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD.ISOLATE FROM
HEAT/ELECTRICAL EQPMT/SPARKS/FLAME.DONT STORE >120F.
Other Precautions:EMPTY DR MAY CONTAIN EPXLO VAP.DONT CUT/PUNCTURE/WELD
ON/NEAR DRUM.VAP OF PRODUCT ARE HEAVIER THAN AIR & MAY COLLECT IN
LOW/CONFINED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAY/APPLYING IN ANY CIRCUMSTANCES LIKELY
TO PRODUCE AIRBORNE LEVEL OF HAZ INGREDS IN EXCESS OF TLV USE
ORGANIC VAPOR CARTRIDGE OR AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW TLV & PEL.
Other Protective Equipment:DURING SPRAY APPLICATION COMPLETE SKIN PROT
REQUIRED.AVOID SKIN CONTACT-USE OTHER PROT CLOTH.SAF
SHOWER,EYEBATH,WASH FAC
Work Hygienic Practices:WASH CONTAMIN CLOTH BEF REUSE.
Supplemental Safety and Health
FIRE/EXPLO:CLSD CNTNRS MAY EXPLO WHEN EXPO TO EXTREME HEAT.DURING FIRE
IRRIT/TOXIC GASES/AEROSOLS FROM DECOMPO/COMBUST PROD MAY BE
PRESENT. HEALTH:CNS EFFECTS,REVERSI LIV DMG @HI
DOSE.INGEST:DROWS,DIZ
Z,NAU.ACETYLACETONE:EYE:BURN,TEAR,RED.SKIN:PORL EXPO
DRY,CRACK,DERM.INHAL:DROWS,HEAD,NAU,DIZZ,UNCONSC.INGEST:NAU,VOMIT,
================== Physical/Chemical Properties ==================
HCC:F3
Boiling Pt:=79.4C, 175.F
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:NP
Vapor Density:>AIR
Spec Gravity:1.004
VOC Pounds/Gallon:493
pH:NP
Viscosity:NP
Evaporation Rate & Reference:UNAVAI
Solubility in Water:NP
Appearance and Odor:CLEAR LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume:43.8
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/WATER,ALCOHOLS,AMINES.
Stability Condition to Avoid:NONE RECOGNIZED.
Hazardous Decomposition Products:PRODUCTS OF COMBUST HAZ INCLUDES
CO,CO2.MAY ALSO INCLUDE OXIDES OF NITROGEN,TRACE OF HCN,ISOCYANATE
MONOMER.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONTAINS CHEM(S) SUBJ TO SEC 313 TITLE III
SARA/40CFR372.WHEN DISPO MATL ENSURE THAT ITS
PKG/STORED/TRANSPO/OHTERWISE MANAGED IAW LOC/STATE/FED REGS.CERCLA
RQ:N-BUTYLACETATRE=5000LBS,MEK=5000LBS,TOLUE NE=1000LBS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:J2564, LACQUER THINNER
CAGE:5W323
CAGE:5W323
============= Composition/Information on Ingredients =============
Ingred Name:METHANOL (METHYL ALCOHOL), COLUMBIAN SPIRITS
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 3.86%
Other REC Limits:200 PPM
OSHA PEL:260 MG/CUM
ACGIH TLV:262 MG/CUM (SKIN)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:METHYLCYCLOHEXANE
CAS:108-87-2
RTECS #:GV6125000
Other REC Limits:400 PPM
OSHA PEL:2000 MG/CUM
ACGIH TLV:1610 MG/CUM
Ingred Name:ETHYL BENZENE
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 1-2.6%
Other REC Limits:100 PPM
OSHA PEL:435 MG/CUM
ACGIH TLV:434 MG/CUM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Other REC Limits:400 PPM
OSHA PEL:2000 MG/CUM
ACGIH TLV:1640 MG/CUM
Ingred Name:WEIGHT PER GALLON IN POUNDS: 6.83 LB
RTECS #:9999999WG
Ingred Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 34%
Other REC Limits:375 MG/CUM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 19.3%
OSHA PEL:2400 MG/CUM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 8-9.5%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 6.6%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:50 PPM (SKIN)
ACGIH TLV:25 PPM (SKIN)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
IRRITATION, MAY BE TOXIC VIA ABSORPTION. INHALATION: IRRITATION OF
THE NOSE & THROAT, NERVOUS SYSTEM DEPRESSION. INGESTION: IRRITATION
OF THE DIGESTIVE TRACT, ASPIRATIONHAZARD, CNS DEPRESSION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: STINGING, TEARING, REDNESS, SWELLING.
SKIN: REDNESS, BURNING, DRYING, CRACKING. INHALATION: NAUSEA,
VOMITING, HEADACHE, DROWSINESS, DIZZINESS, INCOORDINATION, FATIGUE.
INGESTION: BLINDNESS, CONV ULSIONS, COMA, DEATH. TOLUENE: CHANGES
IN DNA OF CELL.
Medical Cond Aggravated by Exposure:SKIN, LUNG, ASTHMA, BLOOD, KIDNEY,
LIVER, HEART DISORDERS.
======================= First Aid Measures =======================
First Aid:EYES: MOVE TO FRESH AIR. FLUSH W/WATER FOR 20 MINS. SKIN:
FLUSH W/SOAP & WATER. DRESS DAMAGED SKIN. INHALATION: MOVE TO FRESH
AIR. IF BREATHING DIFFICULT OR STOPPED, GIVE OXYGEN OR CPR.
INGESTION: GIV E SYRUP OF IPECAC TO INDUCE VOMITING. PUT PERSON ON
LEFT SIDE W/HEAD DOWN. NOTE TO PHYSICIAN: EPINEPHRINE &
SYMPATHOMIMETIC DRUGS MAY INITIATE CARDIA ARRHYTHMIA. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:0F
Lower Limits:1%
Upper Limits:36%
Extinguishing Media:DRY CHEMICAL, CO2, HALON, POLAR OR ALCOHOL FOAM,
WATER SPRAY
Fire Fighting Procedures:EXTREMELY FLAMMABLE LIQUID & VAPOR. VAPOR MAY
CAUSE FLASH FIRE. WEAR FULL PROTECTIVE GEAR. USE WATER SPRAY TO
COOL CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS TRAVEL LONG DISTANCES IN LOW AREAS
TO IGNITION SOURCES.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP AWAY IGNITION SOURCES. ISOLATE AREA. STOP
SPILL IF W/OUT RISK. PREVENT FROM ENTERING SEWERS, STORM DRAINS,
NATURAL WATERWAYS. DIKE & RECOVER. ABSORB.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY CLOSED. STORE IN COOL,
DRY, WELL VENTILATED AREA AWAY FROM HEAT & IGNITION SOURCES. GROUND
ALL EQUIPMENT.
Other Precautions:DON'T PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND CONTAINERS, MAY EXPLODE. EMPTY CONTAINERS RETAIN RESIDUE, ARE
DANGEROUS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF LEVELS EXCEED LIMITS, USE AIR SUPPLIED
RESPIRATOR.
Ventilation:EXHAUST SYSTEMS MAY BE REQUIRED TO KEEP LEVELS BELOW
LIMITS. INSURE ELECTRICAL SYSTEMS ARE SAFE FOR EXPLOSIVE AREAS.
Other Protective Equipment:IMPERVIOUS CLOTHING. EYE WASH & SHOWER IN
AREA.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. DON'T WEAR
CONTAMINATED CLOTHING OR SHOES.
Supplemental Safety and Health
CONT'D MATERIAL TO AVOID: ISOCYANATES, OXIDIZING AGENTS, ORGANOMETALLIC
CONTAMINANTS, STRONG REDUCING AGENTS. DELIBERATE INHALATION MAY BE
HARMFUL OR FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text: 133-340F
Vapor Pres: 75.4
Vapor Density:3
Spec Gravity:0.820
Evaporation Rate & Reference:(N BU AC = 1): 3.2
Solubility in Water:APPRECIABLE
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, AMINES, ANHYDRIDES, ACETALDEHYDE, ALUMINUM, BASES,
CHLORINE, ETHYLENE OXIDE, HYDROGEN PEROXIDE (SEE SUPP)
Stability Condition to Avoid:IGNITION SOURCES (HEAT, SPARKS, FLAMES,
STATIC ELECTRICITY, PILOT LIGHTS, ELECTRICAL EQUIPMENT).
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1-COAT, TT-P-2756, 13670 P/C 03Y144
Kit Part:Y
Preparer's Name:NORM GAUL
CAGE:5M511
CAGE:33461
CAGE:5M511
============= Composition/Information on Ingredients =============
Ingred Name:N-BUTYL ACETATE (VAPOR PRESSURE 13 MM HG @ 68F)
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: <5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:150 PPM;STEL 200 PPM
ACGIH TLV:150 PPM;STEL 200 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ETHYL 3-ETHOXYPROPIONATE (VAPOR PRESSURE 0.7 MM HG @ 68F)
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: 10%
Other REC Limits:50 PPM; STEL 100 PPM
Ingred Name:MINERAL SPIRITS (VAPOR PRESSURE 2 MM HG @ 68F) (NIOSH
LIMITS: 350 MG/M3 - 8 HR TWA; 1800 MG/M3 - 15 MIN SAMPLE)
CAS:64475-85-0
RTECS #:PY8240000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:C8&10 AROMATIC HYDROCARBON (VAPOR PRESSURE 3 MM HG @ 68F)
CAS:64742-95-6
Fraction by Wt: <1%
Other REC Limits:MFR PEL: 100 PPM
Ingred Name:DISPERSION AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:ANTI-FLOAT AGENT
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 MP/F3
ACGIH TLV:10 MP/F3
Ingred Name:METHYL N-PROPYL KETONE (VAPOR PRESSURE 27.8 MM HG @ 68F)
CAS:107-87-9
RTECS #:SA7875000
Fraction by Wt: 5%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:200 PPM;STEL 250 PPM
ACGIH TLV:200 PPM;STEL 250 PPM
Ingred Name:ANTI MAR AGENT (VAPOR PRESSURE 0 MM HG)
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
Ingred Name:XYLENE (SARA III) (VAPOR PRESSURE 21 MM HG @ 100F)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 0.08%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:ETHYL BENZENE (SARA III) (VAPOR PRESSURE 7.1 MM HG @ 68F)
CAS:100-41-4
RTECS #:DA0700000
Fraction by Wt: 0.04%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 125 PPM
ACGIH TLV:100 PPM;STEL 125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA III) (VAPOR PRESSURE 22 MM HG @ 68F)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 1.66%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM;STEL 150 PPM
ACGIH TLV:100 PPM;STEL 150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:DIBUTYLTIN DILAURATE (VAPOR PRESSURE 0.2 MM HG @ 320F)
CAS:77-58-7
RTECS #:WH7000000
Fraction by Wt: <0.1%
Other REC Limits:NONE RECOMMENDED
ACGIH TLV:0.1 MG/M3
Ingred Name:2-4 PENTANEDIONE (VAPOR PRESSURE 6.9 MM HG @ 68F)
CAS:123-54-6
RTECS #:SA1925000
Fraction by Wt: <1%
Other REC Limits:UNION CARBIDE:20 PPM
Ingred Name:VOC: 255 G/L
RTECS #:9999999VO
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHAL: RESP TRACT IRRIT & ACUTE
NERVOUS SYSTEM DEPRESSION
(HEADACHE,DIZZINESS,STAGGERING,CONFUSION,UNCONSCIOUSNESS,COMA).
SKIN: IRRIT (SWELLING,REDNESS,RASH). ABSORPTION:IRRIT,DRYING,DEFAT.
EYE:IRRIT (TEARING,REDNESS,SWELLING W/STING).INGEST:IRRIT,
CORROSIVE IN GI TRACT. VOMIT MAY CAUSE ASPIRATION--CHEM
PNEUMONITIS.
Effects of Overexposure:ACUTE:EYES, NOSE, THROAT IRRIT. INHAL:HEADACHE,
DIFFICULT BREATHING, UNCONSCIOUSNESS. CHRONIC:PROLONGED CONTACT
WILL CAUSE DRYING & CRACKING OF SKIN, DUE TO DEFATTING ACTION. SKIN
SENSITIZATION, ASTHM A OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
HARMFUL IF SWALLOWED/ABSORBED THROUGH SKIN. MAY CAUSE LIVER &
KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA AND DERMATITIS.
======================= First Aid Measures =======================
First Aid:INHALATION: MOVE TO FRESH AIR. RESTORE BREATHING. ASTHMATIC
TYPE SYMPTOMS MAY DEVELOP (IMMEDIATE OR DELAYED BY SEVERAL HOURS).
GET MEDICAL AID. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AFFECTED
AREAS WITH SOAP & WATER. EYES: FLUSH WITH LUKEWARM WATER (LOW
PRESSURE) 15 MIN, LIFTING EYELIDS. GET MEDICAL AID. INGESTION: DO
NOT INDUCE VOMITING. NOTHING BY MOUTH TO UNCONSCIOUS PERSON. GET
MEDICAL AID.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:45.0F,7.2C
Lower Limits:0.60
Upper Limits:11.40
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG,
WATER SPRAY
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING EQUIP W/SCBA & FULL
PROTECTIVE CLOTHING. USE WATER TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP, AUTO IGNITION, OR EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.
================== Accidental Release Measures ==================
Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL. REMOVE
ALL SOURCES OF IGNITION. VENTILATE AREA. CONTAIN AND REMOVE WITH
INERT ABSORBENT AND NON-SPARKING TOOLS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN BLDGS IN COMPLY W/OSHA
1910.106,IN VENTD AREA,IN CLOSED CONTAINER.DON'T STORE NEAR HIGH
TEMP/IGNIT SOURCES.PREVENT PROLONGED BREATHING VAPOR.
Other Precautions:KEEP CONTAINERS TIGHT & UPRIGHT (PREVENT LEAK).
PROLONGED OVEREXPOSURE MAY CAUSE ALLERGIC REACTION. AVOID SKIN &
EYE CONTACT. DON'T INGEST. DON'T HANDLE TILL MFR PRECAUTIONS
READ/UNDERSTOOD.SMOKE IN S MOKING AREAS ONLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:RESPIRATOR RECOMMENDED FOR ORGANIC VAPOR
ENVIRONMENT (AIR PURIFYING/FRESH AIR SUPPLIED) OBEY OSHA REGS FOR
RSPRTR USE. PROVIDE VENT TO KEEP BELOW OSHA LIMITS. IF MAINTAIN
BELOW PEL/TLV, OTHER OSHA/NIO SH APPROVED RSPRTR MAY BE USED.
Ventilation:EXHAUST VENTILATION SUFFICIENT TO KEEP VAPOR CONCENTRATIONS
BELOW TLVS. REMOVE ALL IGNITION SOURCES.
Other Protective Equipment:THE USE OF LONG SLEEVE AND LONG LEG CLOTHING
IS RECOMMENDED. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:213 TO 401F
Vapor Density:> AIR
Spec Gravity:1.33373
Viscosity:*
Evaporation Rate & Reference:0.87 X N-BUTYL ACETATE
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW LIQUID WITH SOLVENT ODOR
Percent Volatiles by Volume:28.9
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE MUST BE DISPOSED OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS MUST BE HANDLED WITH CARE (RESIDUE IS FLAMMABLE). DO NOT
INCINERATE CLOSED CO NTAINERS. EPA HZD CODE: D001, F003, F005.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METADI AEROSOL SPRAY, 40-6269
Preparer's Name:THOMAS R. DERAM
CAGE:09410
CAGE:09410
============= Composition/Information on Ingredients =============
Ingred Name:HEXYLENE GLYCOL
CAS:107-41-5
RTECS #:SA0810000
Fraction by Wt: <10%
OSHA PEL:C 25 PPM
ACGIH TLV:C 25 PPM; 9192
Ingred Name:ISOPROPYL ALCOHOL (SARA III)
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 10-30%
OSHA PEL:400 PPM/500 STEL
ACGIH TLV:400 PPM/500STEL;9192
Ingred Name:FLUORO CHLORO CARBON PROPELLANT(CONSISTING OF INGREDIENTS 4
& 5 AT A 50/50 MIXTURE)
Fraction by Wt: >60%
Other REC Limits:1000 PPM (MFR)
Ingred Name:P-11
CAS:1175-69-4
Ingred Name:DICHLORODIFLUOROMETHANE (SARA III)
CAS:75-71-8
RTECS #:PA8200000
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ozone Depleting Chemical:1
Ingred Name:DIAMOND ABRASIVE/VARIOUS GRADES
Fraction by Wt: 5%
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:DEFATTING WITH PROLONGED CONTACT, SEE
EFFECTS OF OVEREXPOSURE
Effects of Overexposure:EYES/SKIN:MILD IRRITATION.
INHAL:DROW,DIZZ,NASAL AND RESP IRRIT.INJEST:NAUSEA,
VOMIT,DIARRHEA,ABDOM IRRIT.
Medical Cond Aggravated by Exposure:OVER EXPOSURE MAY AGGRAVATE
ASTHMATIC CONDITIONS
======================= First Aid Measures =======================
First Aid:SKIN: WASH THOROUGHLY WITH SOAP AND WATER. INHAL: MOVE TO
FRESH AIR. SUPPORT BREATHING(GIVE O*2 ARTF/RESP) . EYES: FLUSH
THOROUGHLY WITH WATER FOR AT LEAST 15 MIN. INJEST: DILUTE WITH
WATER, IN DUCE VOMITING.
===================== Fire Fighting Measures =====================
Flash Point:COMBUSTIBLE
Extinguishing Media:WATER, CARBON DIOXIDE, FOAM
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIP.
Unusual Fire/Explosion Hazard:CONTR CONTAINS LIQUEFIED COMPRESSED GAS
UNDER PRESSURE,PLUS MINOR AMOUNT OF FLAM SOLVENT.THERMAL DECOMP OF
PROD WILL INCLUDE CHLORIDES,FLORIDES&PHOSGENE
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA, ABSORB LIQUID ON SUITABLE
INERT ABSORBING MATERIAL AND DISPOSE IN SUITABLE WASTE CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:PRODUCT CONTAINS LIQUEFIED GAS UNDER
PRESSURE. AVOID TEMPS ABOVE 125F.
Other Precautions:NO NOT SPRAY NEAR EYES. NO SMOKING IN AREA OF USE. DO
NOT USE IN GENERAL VICINITY OF ARC WELDING,OPEN FLAMES OR HOT
SURFACES.HEAT &/OR UV RADIATION MAY CAUSE FORMATION OF
CHLORIDES,FLUORIDES OR PHOSGE NE
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IN PRESENCE
OF HIGH VAPOR CONCENTATION.
Ventilation:LOCAL EXHAST TO MAINTAIN EXPOSURE BELOW TLV IN INGRED
SECTION
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:GOOD PERSONAL HYGIENE TO BE FOLLOWED AT ALL
TIMES
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:-6F,-21C
Melt/Freeze Pt:M.P/F.P Text:90%
Vapor Pres:1900 @ 70F
Vapor Density:3
Spec Gravity:> 1
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:PLEASANT ODOR, VARIOUS COLORS ACCORDING TO DIAMOND
GRADE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVIOD CONTACT WITH STRONG MINERAL ACIDS STRONG OXIDIZING AGENTS, RUBBER
AND SOME PLASTICS.
Stability Condition to Avoid:AVOID OPEN FLAMES OR HIGH TEMPERATURES
ABOVE 125F IN STORAGE CANS
Hazardous Decomposition Products:HIGH TEMP (FLAME) DECOMP OF PROPELLANT
ONLY MAY FORM HYDROCHLORIC AND HYDROFLUORIC ACIDS, POSSIBLY
PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:FLUSH WASTE MATERIAL WITHOUT PROPELLENT DOWN
DRAIN.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:606516 GASPAK POUCH
Preparer's Name:DALE M. OREN
CAGE:06531
CAGE:05545
CAGE:06531
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH, CONTAINING LESS THAN
1% CRYSTALLINE SILICA
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: 57%
Other REC Limits:10 MG/CUM
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 2%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:SKIN/EYE: IRRITATION. INHALATION:
IRRITATION & PNEUMONOCONIOSIS. * NATURAL DIATOMACEOUS EARTH
PRESENTS A MODERATE RISK FROM INHALATION OF PAARTICULATE. OTHERWISE
IT IS NONTOXIC AND RELATIVELY HARMLESS . PNEUMONOCONIOSIS IS A
POSSIBLE OCCUPATIONAL HAZARD FROM EXCESSIVE INHALATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN/EYE: IRRITATION. INHALATION: IRRITATION &
PNEUMONOCONIOSIS.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL
CASES.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:WATER SPRAY
Unusual Fire/Explosion Hazard:ANY ORGANIC POWDER CAN BE POTENTIALLY
EXPLOSIVE IF DISTRIBUTED IN AIR IN CERTAIN CONCENTRATIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE VACUUM OR WET SWEEPING TO AVOID CREATING
DUST CONDITIONS WHEN PICKING UP SPILLS. PLACE IN CLOSED CONTAINER
FOR DISPOSAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:AS REQUIRED
Ventilation:PROVIDE GENERAL/LOCAL EXHAUST VENTILATION TO KEEP <TLV.
Other Protective Equipment:AS REQUIRED
Supplemental Safety and Health
MSDS RECEIVED FROM FOCAL POINT F (AIR FORCE). AIR FORCE IDENTIFIED THE
NSN.
================== Physical/Chemical Properties ==================
HCC:N1
Appearance and Odor:PLASTIC BAG W/SACHET FILLED W/MIXTURE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
HYDROFLUORIC ACID & ALKALI CARBONATE.
Stability Condition to Avoid:HIGH TEMPERATURE
==================== Disposal Considerations ====================
Waste Disposal Methods:POWDER SHOULD BE LANDIFILLED & ACTIVATED
PACKAGES SHOULD BE AUTOCLAVED IF EXPOSED TO MICROORGANISMS &
DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, & FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:8270 SOLVENT CLEANER
Preparer's Name:JOHN SCOTT
CAGE:CALGN
CAGE:CALGN
============= Composition/Information on Ingredients =============
Ingred Name:PERCHLOROETHYLENE (TETRACHLOROETHYLENE) (SUSPECTED ANIMAL
CARCINOGEN BY NTP & IARC - GROUP 2B) *95-2*
CAS:127-18-4
RTECS #:KX3850000
Fraction by Wt: 8-10%
Other REC Limits:50 PPM
OSHA PEL:50 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Ingred Name:PETROLEUM DISTILLATE
Fraction by Wt: 50-60%
OSHA PEL:500 PPM
Ingred Name:DICHLOROMETHANE (METHYLENE CHLORIDE) (SUSP HUMAN CARC BY
ACGIH, SUSP ANIM CARC BY IARC; NTP - IARC GROUP 2B) *95-2*
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 30-40%
OSHA PEL:500 PPM
ACGIH TLV:174 MG/CUM (A2)
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 8850 MG/KG (SEE SUPP)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: IRRITANT. INHALATION: WILL
IRRITATE NASAL & RESPIRATORY PASSAGES. OVEREXPOSURE MAY CAUSE LIVER
ABNORMALITIES, KIDNEY, LUNG/BRAIN DAMAGE.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, SKIN DRYNESS
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/EYES FOR 15 MINS. SKIN: WASH THOROUGHLY W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS
DIFFICULT, GIVE OXYGEN/CPR AS NECESSARY. INGESTION: DON'T INDUCE
VOMITING. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTES TO
PHYSICIANS: DON'T GIVE STIMULANTS. EPINEPHRINE/EPHEDRINE MAY
ADVERSLY AFFECT THE HEART W/FATAL RESULTS.
===================== Fire Fighting Measures =====================
Flash Point:174F
Extinguishing Media:FOAM, CO2
Fire Fighting Procedures:USE SELF CONTAINED BREATHING APPARATUS W/A
FULL FACE SHIELD OPERATED IN PRESSURE DEMAND/OTHER POSITIVE
PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPORS ARE >AIR & MAY TRAVEL ALONG THE
GROUND/BE MOVED BY VENTILATION & IGNITED BY IGNITION SOURCES AT
LOCATIONS DISTANT FROM HANDLING POINT. (SEE SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: WILL EVAPORATE. LARGE: MAY BE ABSORBED
W/AN ABSORBENT MATERIAL & DRUMMED.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM HEAT. KEEP CONTAINER
CLOSED AT ALL TIMES. MOVE W/BUNGS IN PLACE. WEAR ADEQUATE EQUIPMENT
WHEN TRANSFERRING CHEMICAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION ISN'T ADEQUATE, USE SELF
CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST TO MAINTAIN TLVS.
Other Protective Equipment:RUBBER BOOTS, APRON, NIOSH APPROVED
CLOTHING/EQUIPMENT, SAFETY SHOWER, EYE WASH
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR: TETRACHOLOROETHYLENE. FIRE HAZARD CONT'D:
NEVER USE WELDING/CUTTING TORCH IN/NEAR DRUM EVENT EMPTY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:103.6F
Vapor Density:>1
Spec Gravity:0.94
Evaporation Rate & Reference:(N-BU ACETATE=1): >1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR WATER-WHITE W/CHLORINATED SOLVENT ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HEAT, PILOT LIGHTS & OTHER IGNITION
SOURCES
Hazardous Decomposition Products:CO2, CO, PHOSGENE, VARIOUS HYDRO
CARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:DESTROY BY LIQUID INCINERATOR W/OFF-GAS
SCRUBBER. CONTAMINATED ABSORBENT MAY BE DEPOSITED IN LANDFILL IN
ACCORDANCE W/LOCAL, STATE & FEDERAL REGULATIONS. UN/NA1693.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:POLYURETHANE FLOOR ENAMEL TILE RED, A33 R 8
CAGE:54636
CAGE:54636
============= Composition/Information on Ingredients =============
Ingred Name:ING 4: HARMFUL OR FATAL. PROTECT AGAINST DUST WHICH MAY BE
GENERATED BY SANDING OR ABRADING DRIED FILM.
RTECS #:9999999ZZ
Ingred Name:HYDROTREATED LIGHT PETROLEUM DISTILLATE. VP: 2.0.
CAS:64742-47-8
Fraction by Wt: 5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:MINERAL SPIRITS. VP: 0.5.
CAS:64742-88-7
Fraction by Wt: 35-40%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
Ingred Name:CHROMIUM (III) OXIDE (2:3)
CAS:1308-38-9
RTECS #:GB6475000
Fraction by Wt: 0-5%
OSHA PEL:0.5 MG/M3 (CR)
ACGIH TLV:0.5 MG/M3 (CR)
Ingred Name:SUPP DATA: SANDING/ABRADING OF DRIED FILM. INTENTIONAL
MISUSE BY DELIBERATELY CONC & INHALING CONTENTS CAN BE (ING 5)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: IN CONFINED AREA VAPORS IN HIGH
CONCENTRATION ARE ANESTHETIC. OVEREXPOSURE MAY RESULT IN
LIGHTHEADEDNESS AND STAGGERING GAIT. IRRITANT TO SKIN AND UPPER
RESPIRATORY SYSTEM. CHRONIC: REPORTS HAV E ASSOCIATED REPEATED AND
PROLONGED OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM AND QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND
WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE.
EYES: FLUSH W ITH LARGE AMOUNTS OF WATER FOR AT LEAST15 MINUTES.
GET MEDICAL ATTENTION. INGESTION: CALL MD IMMEDIATELY .
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:102F,39C
Lower Limits:0.5%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT
EQUIP.WATER SPRAY MAY BE INEFT.IF WATER USED,FOG NOZZ PREF.WATER
MAY BE USED TO COOL CLSD CNTNRS TO PVNT (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD.ISOLATE FROM
HEAT,ELEC EQUIP,SPARKS,& OPEN FLAME.CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. APPLIC TO HOT SURFS REQS (SUPP DATA)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CONTENTS ARE COMBUST.KEEP AWAY FROM
HEAT & OPEN FLAME. CONSULT NFPA CODE. USE APPRVD BONDING &
GROUNDING PROC. KEEP CNTNRS CLSD WHEN NOT IN USE.
Other Precautions:TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP
LBLG.DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.COATING
CONTAINS MATLS CLASSIFIED AS NUISANCE PARTICULATES, FOR EXAMPLE
TITANIUM DIOXIDE, CALCIUM CARBONATE ETC.SEE ACGIH (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR NIOSH/MSHA APPROVED
RESPIRATORY DEVICE FOR PROTECTION AGAINST MATERIALS IN INGREDIENTS
SECTION.
Ventilation:LOC EXHST PREFERABLE. GENERAL EXHST ACCEPTABLE IF EXPOS TO
MATLS IN ING SEC IS MAINTAINED BELOW APPLIC EXPOS LIMITS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE ONLY WITH ADEQ VENT. AVOID BREATHING VAPOR
AND SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES. WASH HANDS AFTER
USING.
Supplemental Safety and Health
FIRE FIGHT PROC: PRESS BUILD-UP & POSS AUTOIGNIT/EXPLO WHEN EXPOS TO
EXTREME HEAT. EXPLO HAZ: SPECIAL PREC. DURING EMER CNDTNS OVEREXP
TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPAREN
T. OBTAIN MED ATTN. OTHER PREC: TLV LIST, PREFACE & APPENDIX D)
WHICH MAY BE PRESENT AT HAZ LEVS ONLY DURING (ING 4)
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:61
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE
APPLIC EPA HAZ WASTE NUMBERS. INCIN IN APPRVD FACILITY. DO NOT
INCIN CLSD CNTNR. DISP OF I/A/W FED, ST,& LOC REGS REGARDING
POLLUTION.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ALL WOOD CASED PENCIL PRODUCTS, DARK GRAY
CAGE:73781
CAGE:73781
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS; (WOOD CASED PENCIL)
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PENCIL PRODUCTS BEARING THE PMA
CERTIFICATION MARK (SEAL) ARE CERTIFIED IN A PROGRAM OF TOXICOLOGIC
EVALUATION BY MEDICAL EXPERT SUBJECT TO REVIEW BY THE PROGRAMS
TOXICOLOGICAL REVIEW BD. TO CONTAIN N O MATERIALS IN SUFFICIENT
QUANTITIES TOOFFER AN ACUTE OR CHRONIC HEALTH HAZARD TO HUMANS. NO
ACUTE OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHRONIC HEALTH LABELING IS REQUIRED
UNDER, PROVISION OF FEDERAL LAW, THE FEDERAL HAZARDOUS SUBSTANCE
ACT, OR UNDER ASTM STANDARD D 4236.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTIFICIAL RESPIRATION) .
EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES,
SEEK ASSIS TANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER.
CALL MD .
===================== Fire Fighting Measures =====================
Flash Point:365F,185C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:PENCIL PRODUCTS STORED IN BULK ARE
SUBJECT TO IGNITION BY FIRE AND MAY, IN CASE OF FIRE, RELEASE TOXIC
AND OTHER IRRITATING GASES.
================== Accidental Release Measures ==================
Spill Release Procedures:NOT APPLICABLE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NOT APPLICABLE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:NOT APPLICABLE.
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NOT APPLICABLE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Appearance and Odor:SOLID STICK FORM----CEDAR FRAGRANCE, DK GREY
================= Stability and Reactivity Data =================
NOT APPLICABLE.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:NOT APPLICABLE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS .
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: AMMONIUM HYDROXIDE SOLUTIONS, LC11080
Cage: EO318
=======================================================
Contractor Summary
=======================================================
Cage: EO318
Cage: 0MX47
=======================================================
Ingredients
=======================================================
Cas: 1336-21-6
RTECS #: BQ9625000
% Wt: 4.2-50
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
% Wt: BALANCE
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
BURNS. GET MED AID AT ONCE. INGEST: GIVE
-----------------------------
ALKALI. DO NOT INDUCE VOMIT. GET MED AID AT ONCE.
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: AMMONIUM HYDROXIDE IS CORR IRRITANT TO SKIN, EYE, RESP
TRACT & MUC MEMBS. CAN CAUSE SEV BURNS, EYE & LUNG INJURY AT HIGH
SOLN CONCS. ACUTE: MILD EXPOS MAY CAUSE IRRIT OF NOSE (COUGHING, SNEEZING),
RED NESS & ITCHING OF SKIN, REDNESS & IRRITOF EYES. EXPOS AT HIGHER
CONCS MAY CAUSE RESP DISTRESS, PULM (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: EDEMA, SHOCK, CONVULSIONS,
CYANOSIS, CNS DEPRESS; CHEM BURNS TO EYES & SKIN MAY OCCUR RESULTING IN
CORROSIVE DMG INCLUDING ULCERATION & TEMPORARY BLINDNESS. INGEST MAY RSLT
IN NAUS, VOMIT, G I IRRIT, EXCESSIVE SALIVATION; IN SEVERE CASES PERFORATION,
CNS DEPRESS, SHOCK, CONVULSIONS & PULM EDEMA CAN (SUPDAT)
Medical Cond Aggravated By Exposure: SKIN AND RESPIRATORY DISEASE AGGRAVATED BY
EXPOSURE.
First Aid: INHAL: MOVE VICTIM TO FRESH AIR IMMED, GIVE ARTF RESP IF NECESSARY.
GET MED AID AT ONCE. SKIN: REMOVE CONTAM CLTHG, WASH W/SOAP & WATER.
FLUSH W/LARGE QTYS OF WATER (15-20 MIN) UNTIL CHEM IS GONE. COV ER BURNS
W/DRY STERILE DRESSING (SECURE, NOT TIGHT). GET MED AID AT ONCE. EYES: IMMED
FLUSH W/LARGE AMTS OF WATER (AT LEAST 15-20 MIN) LIFTING UPPER/LOWER LIDS
OCCASIONALLY UNTIL CHEMICAL IS
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NEUT TO PH 7 W/DILUTE ACID OR SUITABLE AGENT. ABSORB
W/INERT ABSORB (SAND, DIATOMACEOUS EARTH), SCOOP INTO GLASS/PLASTIC CNTNR FOR
LATER DISPOSAL. VENT AREA, WASH DOWN W/WATER IF NECESSARY. AVOID BRTH G GAS,
WEAR PROT CLTHG/NIOSH APPRVD RESP EQUIP.
Neutralizing Agent: NEUTRALIZE TO PH 7 WITH A DILUTE ACID OR SUITABLE AGENT.
Waste Disposal Methods: DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS.
Handling And Storage Precautions: STORE CAPPED IN GLASS OR PLASTIC CONTAINER.
PROTECT FROM HEAT AND INCOMPATIBLE SUBSTANCES. VENTILATE AREA.
Other Precautions: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONFLAM (SUPDAT)
Lower Limits: 16% (SUPDAT)
Upper Limits: 25%
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: NGELIG FIRE & EXPLOSION HAZ. ALTHOUGH NOT A
FLAM LIQ (DOT), AMMONIA GAS EVOLVED IS FLAMM, IS EYE, SKIN & RESP
IRRITANT. MOVE CNTNRS IF POSS, COOL WITH (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQUIRED FOR LAB USE WHEN WORKING UNDER APPROVED
HOOD. >300PPM - NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS WITH
FULL FACEPIECE.
Ventilation: PROVIDE LOCAL EXHAUST VENTILATION TO MEET PERMISSABLE EXPOSURE
LIMITS (PEL) FOR AMMONIA GAS.
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: DO NOT WEAR CONTACT LENSES WHEN WORKING WITH
CHEMICALS.
Supplemental Safety and Health: BP: (NH*3 VAPOR RELEASE). PH: ALKALINE. FL PT:
(AS AQUA AMMONIA). LEL: (FOR EVOLVED AMMONIA GAS) EXPLO HAZ: WATER. AVOID
BRTHG CORR VAPS. MATLS TO AVOID: W/STRONG OXIDIZERS, MOST METALS & THEIR
ALLOYS . EFTS OF OVEREXP: OCCUR. CHRONIC: BRONCHITIS, DERMATITIS,
CONJUNCTIVITIS CAN OCCUR.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: SUPDAT
M.P/F.P Text: <32F,<0C
Vapor Density: >AIR
Spec Gravity: <1.0
PH: SUPDAT
Evaporation Rate & Reference: 1 (WATER)
Solubility in Water: COMPLETELY SOLUBLE
Appearance and Odor: CLEAR, COLORLESS LIQUID; PUNGENT TO FAINT AMMONIA ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEATING EVOLVES AMMONIA GAS (NH*3).
Materials To Avoid: REACTS EXOTHERMICALLY W/ACIDS, REACTS W/HYPOCHLORITES,
HALOGENS, SODIUM HYDROXIDE & GALVANIZED SURFS. REACTS (SUPDAT)
Hazardous Decomposition Products: AMMONIA GAS IS RELEASED WHICH MAY DECOMPOSE
ABOVE 842F TO HYDROGEN AND NITROGEN GASES.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: AMMONIUM HYDROXIDE SOLUTIONS, LC11080
Cage: EO318
Assigned IND: Y
Company Name: LABCHEM INC
Street: 200 WILLIAM PITT WAY
Zipcode: 15238
Label Required IND: Y
Date Of Label Review: 11/09/1998
Status Code: C
Label Date: 11/09/1998
Origination
Chronic Hazard IND: Y
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: MILD EXPOSURE MAY CAUSE IRRITATION OF NOSE
(COUGHING, SNEEZING), REDNESS AND ITCHING OF SKIN, REDNESS AND IRRITATION OF
EYES. EXPOSURE AT HIGHER CONCENTRATIONS MAY CAUSE RESPIRATORY DISTRESS, P
ULMONARY EDEMA, SHOCK, CONVULSIONS, CYANOSIS, CNS DEPRESSION. CHEMICAL BURNS
TO EYES AND SKIN MAY OCCUR RESULTING IN CORROSIVE DAMAGE INCLUDING ULCERATION
AND TEMPORARY BLINDNESS. INGESTION MAY RESULT IN NAUSEA, VOMITING, GASTRIC
IRRITATION, EXCESSIVE SALIVATION; IN SEVERE CASESPERFORATION, CNS DEPRESSION,
SHOCK, CONVULSIONS AND PULMONARY EDEMA CAN OCCUR. CHRONIC: BRONCHITIS,
DERMATITIS, CONJUNCTI VITIS.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:UM900 SERIES
Preparer's Name:FRANK PETERS
CAGE:21546
CAGE:21546
============= Composition/Information on Ingredients =============
Ingred Name:NON-HAZARDOUS INGREDIENTS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Explanation of Carcinogenicity:NONE
Medical Cond Aggravated by Exposure:ABRASIVE CAN SCRATCH EYES.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE APPROPRIATE TECHNIQUES & MEDIA FOR SURROUNDING
FIRE.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:MATERIAL CAN SPATTER >212F. POLYMER FILM
CAN BURN.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP PROPERLY W/PAPER TOWELS & A WET
SPONGE. PUT PAPER TOWELS IN TRASH & RINSE OUT SPONGE.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER SEALED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATOR THAT IS NIOSH APPROVED FOR SPRAYS
& MISTS.
Ventilation:LOCAL EXHAUST: RECOMMENDED. MECHANICAL (GENERAL):
RECOMMENDED WHEN SPRAYING.
Other Protective Equipment:NONE
Work Hygienic Practices:GOOD HYGIENE PRACTICES SHOULD BE FOLLOWED.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F
Vapor Density:<1
Spec Gravity:1-1.3
pH:6.5-9
Evaporation Rate & Reference:(BUTYL ACETATE=1): <1
Solubility in Water:INSOLUBLE
Appearance and Odor:OPAQUE COLORED LATEX PAINT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:TEMPS >212F
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METHYL ETHYL KETONE
CAGE:0YFV5
CAGE:0YFV5
============= Composition/Information on Ingredients =============
Ingred Name:NO INGREDIENT FOR THIS FORMULATION_INGREDIENT
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV:PEL: 200 PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
MODERATE IRRITATION, DEFATTING, DERMATITIS. INHALATION: NASAL AND
RESPIRATORY IRRITATION, CENTRAL NERVOUS SYSTEM EFFECTS, DEATH.
INGESTION: GASTROINTESTINAL IRRITATION.
Explanation of Carcinogenicity:NOT CARCINOGENIC.
Effects of Overexposure:EYES: REDNESS, TEARING, BLURRED VISION.
INHALATION: DIZZINESS, WEAKNESS, FATIGUE, HEADACHE,
UNCONSCIOUSNESS. INGESTION: NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN,
RESPIRATORY TRACT, LIVER, OR KIDNEY MAY BE AT INCREASED RISK FROM
EXPOSURE TO THIS MATERIAL.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH AREA WITH SOAP
AND WATER. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
INHALATION: MOVE TO FR ESH AIR. IF NOT BREATHING, GIVE CPR.
IFBREATHING DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. KEEP PERSON WARM. GET MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:23.0F,-5.0C
Lower Limits:2.0
Extinguishing Media:ALCOHOL FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE WHEN
FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR & MAY TRAVEL
ALONG THE GROUND & IGNITE BY PILOT LIGHTS OR OTHER SOURCES OF
IGNITION AT LOCATIONS DISTANT FROM MATERIAL HANDLING POINT.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL AND TRANSFER TO HOOD
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID AND/OR SOLID) ALL HAZARD PRECAUTIONS GIVEN IN THIS DATASHEET
MUST BE OBSERVED .
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT IS EXCEEDED, USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN THE
ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO
PERMIT OTHER NIOSH/MSHA RESPIR ATORS (NEGATIVE PRESSURE TYPE).
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL
EXHAUST VENTILATION TO MAINTAIN EXPOSURE BELOW TLVS.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,
IMPERVIOUS WORK CLOTHING AND APRON AS REQUIRED TO PREVENT SKIN
EXPOSURE.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
FLAMMABLE LIQUID.
================== Physical/Chemical Properties ==================
HCC:F2
Boiling Pt:B.P. Text:175F,79C
Vapor Pres:70 MM
Vapor Density:2.5 AIR=1
Spec Gravity:0.805-0.807
Evaporation Rate & Reference:5.70 (N-BUTYL ACETATE=1)
Appearance and Odor:LIQUID.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD.
ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR HOOD DUCT
WORK. DISPOSE OF REMAINING MATERIAL IN ACCORDANCE WITH APPLICABLE
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1325, KRYLON ALL-PURPOSE SILICONE SPRAY
CAGE:09800
CAGE:26290
CAGE:09800
============= Composition/Information on Ingredients =============
Ingred Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Fraction by Wt: 10-30%
Ingred Name:METHYLCYCLOHEXANE
CAS:108-87-2
RTECS #:GV6125000
Fraction by Wt: 5-10%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM; 9495
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5-10%
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM; 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:HEXANE (N-HEXANE) (CERCLA)
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 10-30%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM; 9495
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CYCLOHEXANE (SARA 313) (CERCLA)
CAS:110-82-7
RTECS #:GU6300000
Fraction by Wt: 1-5%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM, 9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 10-30%
OSHA PEL:500 PPM
ACGIH TLV:400 PPM/500STEL;9495
Ingred Name:V M & P NAPHTHA
CAS:64742-89-8
Fraction by Wt: 30-50%
Ingred Name:HEXANE ISOMERS
Fraction by Wt: 10-30%
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 10-30%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9495
===================== Hazards Identification =====================
LD50 LC50 Mixture:PRODUCT'S LD50 (ORAL RAT) WAS NOT STATED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:CAUSES IRRITATION. SKIN:CAUSES
IRRITATION. NOT EXPECTED TO BE HARMFUL BY ABSORPTION. INHALED:MAY
BE HARMFUL. LIQUID OR VAPOR MAY CAUSE RESPIRATORY IRRITATION.
INGESTION:NOT EXPECTED UNDER NORMAL CONDITIONS OF USE. IF
SWALLOWED, MAY CAUSE IRRITATION OR BURNS OF MUCOUS MEMBRANE,
ESOPHAGUS, G/I TRACT.
Explanation of Carcinogenicity:AS OIF THE DATE OF THIS MSDS, NONE OF
THE INGREDIENTS HAVE BEEN LISTED BY NTP, IARC OR OSHA AS A
CARCINOGEN.
Effects of Overexposure:EYE:IRRITATION. SKIN:IRRITATION.
INHALED:IRRITATION OF RESPIRATORY TRACT. INGESTION:G/I BURNS,
IRRITATION.
Medical Cond Aggravated by Exposure:MFR GAVE NO INFORMATION ON MSDS.
======================= First Aid Measures =======================
First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WASH W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. INHALED:REMOVE FROM
EXPOSURE. A ID OR RESTORE BREATHING AS NEEDED. INGESTED:DILUTE BY
DRINKING LARGE QUANTITIES OF WATER. IMMEDIATELY CONTACT POISON
CONTROL CENTER OR HOSPITAL EMERGENCY ROOM FOR TREATMENT DIRECTIONS.
===================== Fire Fighting Measures =====================
Flash Point:>-4F,>-20C
Lower Limits:1.2
Upper Limits:9.5
Extinguishing Media:USE FOG, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
WATER MAY BE INEFFECTIVE, USE IT TO COOL FIRE EXPOSED CONTAINERS.
Fire Fighting Procedures:VERY FLAMMABLE LIQUID. VAPORS ARE HEAVIER THAN
AIR & CAN TRAVEL ALONG SURFACES TO IGNITION SOURCES & FLASH BACK.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. DO NOT INCINERATE
CONTAINER. AVOID HEAT. KEEP CONTAINER <120F. DO NOT PUNCTURE. AVOID
ALL IGNIOION SOURCES. VAPOR MAY IGNITE EXPLOSIVELY.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SOAK UP
ABSORBENT MATERIAL AND REMOVE TO CHEMICAL DISPOSAL AREA. PREVENT
ENTRY INTO NATURAL BODIES OF WATER.
Neutralizing Agent:MFR GAVE NO INFORMATION ON MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 120F. DO NOT PLACE ON
REAIATOR, STOVE OR IN DIRECT SUNLIGHT.
Other Precautions:HANDLE I/A/W GOOD INDUSTRIAL HYGIENE & SAFETY
PRACTICE. AVOID UNNECESSARY EXPOSURE. REMOVE MATERIAL FROM
EYES,SKIN,CLOTHING. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE AIR CONTAMINATION CAN EXCEED ACCEPTABLE
CRITERIA, USE NIOSH/MSHA APPROVED RESPIRATORY EQUIPMENT. SELECT
RESPIRATORS BASED ON FORM & CONCNTRATION OF AIR CONTAMINATION I/A/W
OSHA 29 CFR 1910.134 O R OTHER STANDARDS OR GUIDELINES.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & FLOW TO KEEP
CONTAMINANT CONCENTRATION LEVELS BELOW ACCEPTABLE CRITERIA.
Other Protective Equipment:MFR GAVE NO INFORMATION ON MSDS.
Work Hygienic Practices:MFR:? HMIS:USE GOOD INDUSTRIAL HYGIENE
PRACTICES. MINIMIZE CONTACT & WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:V3
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:>-48F,>-44C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:50 PSI
Vapor Density:>1
Spec Gravity:0.65 +/-0.02
pH:NEUT
Evaporation Rate & Reference:>1(BUTYL ACETATE=1)
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID & LIQUIFIED GAS, HYDROCARBON SOLVENT ODOR.
Percent Volatiles by Volume:92-94
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS OR BASES.
Stability Condition to Avoid:MFR GAVE NO INFORMATION ON MSDS.
Hazardous Decomposition Products:OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE/PROVINCIAL,
AND FEDERAL REQUIREMENTS. EMPTY CONTAINER:MAY CONTAIN EXPLOSIVE
VAPORS. DO NOT CUT, PUNCTURE OR WELD ON OR NEARBY. INCINERATION
WILL CAUSE CONTAINER TO BURST VIOLENTLY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:FRENCH ULTRAMARINE BLUE
Preparer's Name:WOODHALL STOPFORD
CAGE:72925
CAGE:72925
============= Composition/Information on Ingredients =============
Ingred Name:CADMIUM PIGMENT
Ingred Name:CADMIUM SUSPECTED HUMAN CARCINOGEN (ACGIH,IARC, & NTP)
INTENDED CHANGE (IC)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: 0.05%
Other REC Limits:A2 CARCINOGEN
OSHA PEL:0.05 MG/CUM (CD)
ACGIH TLV:0.01 MG/CUM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:COBALT
CAS:7440-48-4
RTECS #:GF8750000
Other REC Limits:0.05 PPM
OSHA PEL:0.1 MG/CUM
ACGIH TLV:0.05 MG/CUM
Ingred Name:HEXACHLOROBENZENE
CAS:118-74-1
RTECS #:DA2975000
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:NICKEL (SOLUBLE) (SUSPECTED HUMAN CARCINOGEN BY NTP, IARC,
ACGIH) INTENDED CHANGE (IC)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: 1.00%
Other REC Limits:1 MG/CUM
OSHA PEL:1 MG/CUM
ACGIH TLV:0.05 MG/CUM IC
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INGESTION: MAY BE HARMFUL IF
SWALLOWED. CRONIC: EXPOSURE MAY CAUSE DAMAGE TO THE HEART/LUNGS.
EXPOSURE MAY CAUSE DAMAGE TOTHE CHEST. EXPOSURE MAY CAUSE HARM TO
THE DEVELOPING FETUS. LUNG DISEASE. KID NEY DISEASE. PREGNANCY.
HEART DISEASE.
Explanation of Carcinogenicity:NONE
======================= First Aid Measures =======================
First Aid:INGESTION: GET PROMPT MEDICAL ATTENTION. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
================== Accidental Release Measures ==================
Spill Release Procedures:NO SPECIAL SPILL PROCEDURES REQUIRED.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH-CERTIFIED MASK FOR DUSTS
Ventilation:LOCALLY EXHAUSTING HOOD
Work Hygienic Practices:DON'T SPRAY APPLY. WASH HANDS IMMEDIATELY AFTER
USE. WHEN USING DON'T EAT, DRINK/SMOKE. AVOID USING IF PREGNANT.
Supplemental Safety and Health
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/FEDERAL, STATAE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: TANDEM-R FERRITIN
Kit Part: Y
Cage: FO596
Box: 269006
=======================================================
Preparer Co. when other than Responsible Party Co.
=======================================================
Cage: FO596
Assigned Ind: Y
Box: 269006
=======================================================
Contractor Summary
=======================================================
Cage: 63493
Box: 269006
Cage: FO596
Box: 269006
=======================================================
Ingredients
=======================================================
Cas: 26628-22-8
RTECS #: VY8050000
% Wt: 0.1
Other REC Limits: 0.1 PPM
ACGIH TLV: C 0.29 MG/CUM
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Explanation Of Carcinogenicity: NONE
First Aid: EYES/SKIN: IMMEDIATELY FLUSH W/COPIOUS AMOUNTS OF WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FLUSH DRAINS W/COPIOUS AMOUNTS OF WATER TO PREVENT
AZIDE ACCUMULATION.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE. REFRIGERATE,
UNLESS OTHERWISE SPECIFIED IN KIT INSERT.
Other Precautions: AZIDE REACTS W/MANY HEAVY METALS SUCH AS LEAD, COPPER,
MERCURY, SILVER & GOLD TO FORM EXPLOSIVE COMPOUNDS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: DRY CHEMICAL
Unusual Fire/Explosion Hazard: CONTACT W/COPPER/LEAD DRAIN PIPES MAY RESULT IN
THE FORMATION OF POTENTIALLY EXPLOSIVE AZIDE DEPOSITS.
=======================================================
Control Measures
=======================================================
Other Protective Equipment: LAB COAT
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
Spec Gravity: 1.85
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: ACIDS, HEAVY METALS; LEAD, COPPER, BROMINE, CARBON
DISULFIDE, CHROMYCHLORIDE, DIBROMO MALONITRILE, DIMETHYL SULFATE
Hazardous Decomposition Products: SODIUM & OXIDES OF NITROGEN
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: TANDEM-R FERRITIN
Cage: FO596
Assigned IND: Y
Company Name: HYBRITECH INCORPORATED
Street: 11095 TORREYANA ROAD
PO Box: 269006
Zipcode: 92126
Label Required IND: Y
Date Of Label Review: 12/16/1998
Status Code: C
Label Date: 12/16/1998
Origination Code: G
Hazard And Precautions: N/K
N/K
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:HARD HAT PRIMERS AND TOPCOATS, 2190
CAGE:08882
CAGE:08882
============= Composition/Information on Ingredients =============
Ingred Name:SUPDAT:KIDNEY, LUNG, SPLEEN & EYE DMG AS WELL AS ANEMIA.
AFFECTS IN HUMANS HAVE SHOWN LIVER & CARD ABNORM. (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:ETHYLENE GLYCOL BUTYL ETHER MAY BE HARMFUL IF
ABSORBED THROUGH SKIN & HAS BEEN SHOWN TO CAUSE BLOOD ABNORM (ING
9)
RTECS #:9999999ZZ
Ingred Name:ING 8:IN LAB ANIMALS.
RTECS #:9999999ZZ
Ingred Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
Ingred Name:XYLENE; (XYLOL) (SARA 313) (CERCLA). VP:9.5 @ 20C.
LEL:1.2%.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 15-25%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:TOLUENE (SARA 313) (CERCLA). VP:22 @ 20C. LEL:1.2%.
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 10-25%
OSHA PEL:200 PPM; Z-2
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VM & P NAPHTHA. VP:2 @ 20C. LEL:0.9%.
CAS:64742-89-8
Fraction by Wt: 0-5%
OSHA PEL:300 PPM (MFR)
ACGIH TLV:300 PPM (MFR)
Ingred Name:ETHANOL, 2-BUTOXY-; (ETHYLENE GLYCOL BUTYL ETHER). VP:0.9 @
20C. LEL:1.1%.
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 0-5%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM
Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)
(CERCLA). VP:70 @ 20C. LEL:2.0%.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 0-3%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:HYDROCARBON PROPELLANT (PROPANE/ISOBUTANE); (PROPELLANT)
(PROPANE, BUTANE, ISOBUTANE). VP:85 PSIG. LEL:1.8%
CAS:68476-86-8
Fraction by Wt: 25%
OSHA PEL:1000 PPM (MFR)
ACGIH TLV:1000 PPM (MFR)
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HARMFUL IF INHALED. MAY
AFFECT BRAIN & NERV SYS CAUSING DIZZ, HDCH/NAUS. RPTD OVEREXP MAY
PROGRESSIVELY LEAD TO STAGG GAIT, CONFUSION, UNCON/COMA. CAUSES
NOSE & THROAT IRRIT. SKIN OR EYE:C AUSES EYE & SKIN IRRIT WHICH CAN
LEAD TO DERM W/RPTD OVEREXP. INGEST:MAY CAUSE GI IRRIT, NAUS, VOMIT
& (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DIARR. ANIMAL STUDIES HAVE CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFTS ON THE CNS, HEMATOPOIETIC
TISS, BLOOD, KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL
MONOBUTYL ETHER (EGBE). (EXTR ACTED FROM DHHS (NIOSH) PUB NO.
90-118). TOLUENE APPEARS ON NAVY LISTING OF OCCUP CHEM REPROD HAZS.
SEEK (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOSURE, RESTORE BREATHING & NOTIFY PHYS.
EYE:FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINS. NOTIFY PHYS. SKIN:WASH AFFECTED AREA WITH SOAP & WATER,
REMOVE CONTAMI NATED CLOTHING AND WASH BEFORE REUSE. INGEST:DO NOT
INDUCE VOMITING. KEEP PERSON WARM, QUIET & GET MED ATTN. ASPIRATION
OF THIS MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH
CAN BE FATAL.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:<0F,<-18C
Lower Limits:SEE INGS
Extinguishing Media:NFPA CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY
CHEMICAL OR FOAM).
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
MAY BE USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILD-UP & POSS
AUTOIGNIT/EXPLO. IF WATER IS USED, FOG (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DO NOT APPLY TO HOT SURFACES.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE ABOVE 120F. DO NOT
PUNCTURE OR INCINERATE CONTAINERS.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS MAY BE HARMFUL OR FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR
(TC23C) TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY AND ORGANIC
VAPORS DURING SPRAY APPLICATION. IN CONFINED AREAS:USE NIOSH
APPROVED SUPPLIED-AIR RESPIRATORS OR HOODS (TC19C).
Ventilation:PROVIDE GENERAL DILUTION/LOC EXHAUST VENT IN VOLUME &
PATTERN TO KEEP TLV OF HAZ INGREDS BELOW ACCEPTABLE LIMITS.
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:NOZZ ARE PREF. EFTS OF OVEREXP:CONSULTATION FROM APPROP
HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG &
EXPOS INFO . CHRONIC:RPTS HAVE SHOWN RPTD & PRLNGD OCCUP OVEREXP
TO SOLVS W/PERM BRAIN & NERV SYS DMG. OVEREXP TO TOLUENE & XYLOL IN
LAB ANIMALS HAS SHOWN LIVER ABNORM, (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY OPEN FLAME-CARBON MONOXIDE AND
CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:STAY SILV 35
CAGE:27911
CAGE:27911
============= Composition/Information on Ingredients =============
Ingred Name:SILVER (SARA III)
CAS:7440-22-4
RTECS #:VW3500000
Fraction by Wt: 35.0%
OSHA PEL:0.01 MG/M3
ACGIH TLV:0.1 MG/M3; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:COPPER (SARA III)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 26.0%
OSHA PEL:0.1MG/M3 FUME/1 DUST
ACGIH TLV:0.2MG/M3 FUME; 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ZINC (SARA III)
CAS:7440-66-6
RTECS #:ZG8600000
Fraction by Wt: 21.0%
OSHA PEL:10 MG ZNO/M3
ACGIH TLV:10 MG ZNO/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:CADMIUM
CAS:86627-71-6
RTECS #:EY9800000
Fraction by Wt: 18.0%
===================== Hazards Identification =====================
Effects of Overexposure:WHEN BRAZING IN CONFINED AREAS,DIZZINESS AND
NAUSEA
======================= First Aid Measures =======================
First Aid:CONSULT PHYSICIAN
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE RESPIRATOR WHEN IN CONFINED AREAS
Ventilation:LOCAL EXHAUST IS PREFERRED
Other Protective Equipment:RESPIRATOR MASK
Supplemental Safety and Health
ITEM IS GRADE VIII OF FEDERAL SPECIFICATION QQ-B-654
================== Physical/Chemical Properties ==================
HCC:N1
Spec Gravity:9.18
Appearance and Odor:COPPER COLORED AND ODORLESS
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:23990 BP616-500 TRIETHYLAMINE 99.7%
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:TRIETHYLAMINE
CAS:121-44-8
RTECS #:YE0175000
Fraction by Wt: 100%
Other REC Limits:10 PPM
OSHA PEL:100 MG/CUM
ACGIH TLV:41 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): 460 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: SEVERE IRRITATION/BURNS.
MAY BE ABSORBED. LACRYMATOR. INGESTION: HARMFUL. MAY CAUSE SEVERE
GI TRACT IRRITATION W/POSSIBLE BURNS. INHALATION: RESPIRATORY TRACT
IRRITATION W/BURNING PAIN TO N OSE/THROAT. PULMONARY EDEMA.
PROLONGED/REPEATED EXPOSURE MAY CAUSE DAMAGE TO KIDNEYS & LUNGS.
DERMATITIS/ULCERATIONS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, BURNS, SENSITIZATION TO LIGHT, HALO
VISION, NAUSEA, VOMITING, COUGHING, WHEEZING, SHORTNESS OF BREATH
======================= First Aid Measures =======================
First Aid:EYES: DON'T ALLOW TO RUB/KEEP EYES CLOSED. FLUSH CONTINUOUSLY
W/WATER. IRRIGATE EXCESSIVELY FOR 30 MINS. SKIN: FLUSH W/PLENTY OF
SOAP & WATER FOR 15 MINS. INGESTION: IF CONSCIOUS & ALERT, GIVE 2-4
CUP FULS OF MILK/WATER. NEVER GIVE ANYTHINGBY MOUTH IF UNCONSCIOUS.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NECESSARY.
OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:12.2F
Lower Limits:1.2
Upper Limits:8
Extinguishing Media:DRY CHEMICAL, CO2/ALCOHOL-RESISTANT FOAM. DON'T USE
WATER.
Fire Fighting Procedures:WEAR SCBA IN PRESSURE DEMAND, MSHA/NIOSH
APPROVED & FULL PROTECTIVE GEAR. WATER MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:VAPORS TRAVEL TO IGNITION SOURCES &
FLASHBACK/CAUSE FLASH FIRE. FIRE MAY SPREAD BY USE OF WATER. VAPORS
MIXED W/AIR CAN EXPLODE WHEN IGNITED. AUTOIGNITION:446F.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB W/INERT MATERIAL; DRY SAND/EARTH. PLACE
INTO A CHEMICAL WASTE CONTAINER. REMOVE ALL SOURCES OF IGNITION.
ISOLATE AREA & DENY ENTRY. PROVIDE VENTILATION.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP FROM HEAT/SPARKS/FLAME. STORE IN
A COOL, DRY PLACE AWAY FROM STRONG ACIDS. KEEP CONTAINERS TIGHTLY
CLOSED. USE W/ADEQUATE VENTILATION.
Other Precautions:GROUND & BOND CONTAINERS WHEN TRANSFERRING MATRERIAL.
DON'T GET IN EYES, ON SKIN/ON CLOTHING. EMPTY CONTAINERS RETAIN
PRODUCT RESIDUE. DON'T INGEST/INHALE. DON'T
PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL /GRIND/EXPOSED TO IGNITION
SOURCES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:MEETING OSHA'S 29 CFR 1910.134 & ANSI Z88.2
REQUIREMENTS WHENEVER WORKPLACE CONDITIONS WARRANT A RESPIRATOR'S
USE.
Ventilation:PROCESS ENCLOSURES/LOCAL EXHAUST TO CONTROL AIRBORNE LEVELS
<RECOMMENDED EXPOSURE LIMITS. USE ONLY IN CHEMICAL FUME HOOD
Other Protective Equipment:PROTECTIVE CLOTHING
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. WASH THOROUGHLY AFTER HANDLING. DISCARD CONTAMINATED
SHOES.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:192.02F
Melt/Freeze Pt:M.P/F.P Text:-174.5
Vapor Pres:54
Vapor Density:3.5
Spec Gravity:0.728
Evaporation Rate & Reference:(BUTYL ACETATE =1): 5.6
Appearance and Odor:CLEAR, COLORLESS LIQUID W/AMMONIA-LIKE/FISHY ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING AGENTS
Stability Condition to Avoid:EXCESS HEAT & OTHER IGNITION SOURCES
Hazardous Decomposition Products:NITROGEN OXIDES, CO, CO2, NITROGEN
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:1401 ANTI SEIZE
CAGE:OFC18
CAGE:0FC18
CAGE:OFC18
============= Composition/Information on Ingredients =============
Ingred Name:NAPHTHOL SPIRITS; (ISOPARAFINNIC HYDROCARBON)
CAS:64742-48-9
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:COPPER; (COPPER COMPOUND) (SARA 313) (CERCLA)
CAS:7440-50-8
RTECS #:GL5325000
Fraction by Wt: 13%
OSHA PEL:0.1MG/M3 FUME;1 DUST
ACGIH TLV:0.2 MG/M3 FUME
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE/CHRONIC: INHALATION: HIGH
CONCENTRATIONS ARE IRRITATING TO THE EYES AND UPPER RESPIRATORY
TRACT. MAY CAUSE HEADACHES AND DIZZINESS, ARE ANESTHETIC AND MAY
HAVE OTHER CENTRAL NERVOUS SYSTEM EFFEC TS. SKIN: FREQUENT OR
PROLONGED CONTACTMAY IRRITATE AND CAUSE DERMATITIS. LOW ORDER OF
TOXICITY. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INGESTION: SMALL AMOUNTS OF THE
LIQUID ASPIRATED INTO THE RESPIRATORY SYSTEM DURING INGESTION OR
FROM VOMITING MAY CAUSE BRONCHIOPNEUMONIA OR PULMONARY EDEMA.
MINIMAL TOXICITY. EYES: CAN CAU SE SEVERE IRRITATION, REDNESS,
TEARING AND BLURRED VISION.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE VICTIM TO FRESH AIR. IF BREATHING IS
STOPPED GIVE ARTIFICIAL RESPIRATION. GET IMMEDIATE MEDICAL
ATTENTION. INGESTION: DILUTE WITH WATER. DO NOT INDUCE VOMITING.
GET MEDICAL ATTENTIO N. EYES: FLUSH EYES WITH WATER LIFTING UPPER
AND LOWER LIDS. GET MEDICAL ATTENTION. SKIN: WASH EXPOSED SKIN
AREAS WITH SOAP AND WATER.
===================== Fire Fighting Measures =====================
Flash Point Method:TOC
Flash Point:76.0F,24.4C
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROTECTIVE
EQUIPMENT . USE EQUIP OR SHIELDING REQD TO PROTECT PERSONNEL
AGAINST BURSTING, RUPTURING OR VENTING CNTNRS.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE SPRAY PER CPSC FLAME
EXTENSION TEST. AT ELEVATED TEMPERATURES (ABOVE 120F) CONTAINERS
MAY VENT, RUPTURE OR BURST.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP AREA BY MOPPING OR WITH ABSORBENT
MATERIALS AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL. CONTACT
FEDERAL, STATE OR LOCAL AUTHORITIES FOR APPROVED DISPOSAL
PROCEDURES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AEROSOL PRODS PRESENT LIMITED HAZ
DURING STOR/USE IF LABEL PRECS ARE FOLLOWED. INTENTIONAL MISUSE BY
DELIB CONC & INHAL CONTENTS CAN BE HARMFUL/FATAL.
Other Precautions:PRESSURIZED CONTAINERS MUST NOT BE EXPOSED TO TEMPS
ABOVE 120F AND SPRAY SHOULD NOT BE DIRECTED TOWARD FACE OR EYES,
OPEN FLAME OR OTHER IGNIT SOURCE. PLEASE READ & FOLLOW DIRECTIONS
ON PROD LABEL. TH EY ARE BEST GUIDE TO USING PROD (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:UNDER NORMAL CONDITIONS NO RESPIRATORY
PROTECTION IS REQUIRED. USE NIOSH/MSHA APPROVED RESPIRATOR
APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:GENERAL VENTILATION NORMALLY ADEQUATE. USE EXPLOSION PROOF
EQUIPMENT IN CONFINED AREAS.
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
LONG SLEEVES SHOULD BE WORN.
Work Hygienic Practices:DO NOT EAT, DRINK OR SMOKE IN WORK AREA. WASH
HANDS BEFORE EATING. DO NOT STORE AT TEMPERATURES ABOVE 120F.
Supplemental Safety and Health
OTHER PRECS: IN MOST EFFECTIVE WAY & THEY ALSO GIVE THE NECESSARY
SAFETY PRECS TO PROTECT HEALTH.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:140F,60C
Vapor Pres:45 @ 75F
Spec Gravity:0.973 @ 75F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREY VISCOUS LIQUID; MILD SOLVENT ODOR.
Percent Volatiles by Volume:67%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT EXPOSE TO TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN USED PROPERLY AEROSOL PRODUCTS DO NOT
GENERATE HAZARDOUS WASTE. EMPTY DE-PRESSURIZED CONTAINERS SHOULD BE
RECYCLED. CONSULT FEDERAL, STATE AND LOCAL AUTHORITIES FOR APPROVED
PROCEDURES.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:9734 ENDURANCE OIL STAIN
CAGE:EO698
CAGE:01PD6
CAGE:EO698
============= Composition/Information on Ingredients =============
Ingred Name:KEROSENE (PETROLEUM), (C10-C15 SATURATED HYDROCARBONS 97%,
C10 AROMATICS 3%) (SUSP ANIMAL CARCINOGEN BY IARC)*98-3*
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 60-70%
Other REC Limits:200 PPM EXXON
Ingred Name:CRYSTALLINE-QUARTZ SILICA, SILICA DUST (SUSPECTED HUMAN
CARCINOGEN BY IARC-GROUP 2A; SUSPECTED CARCINOGEN NTP) *98-3*
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 1-5%
Other REC Limits:0.05 MG/CUM (NIOSH)
OSHA PEL:10 MG/CUM %RESP SIO2
ACGIH TLV:0.1 MG/CUM RESP DUST
Ingred Name:YELLOW OXIDE, YELLOW IRON OXIDE*98-3*
CAS:51274-00-1
Fraction by Wt: 1-5%
Ingred Name:FATTY ACIDS, TALL-OIL, POLYMER W/GLYCEROL, PENTAERYTHRITOL
& PHTHALIC ANHYDRIDE *98-3*
CAS:66070-62-0
Fraction by Wt: 20-30%
Ingred Name:VOLATILE ORGANIC CONTENT: 7.3 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITANT. CNS DEPRESSION. SKIN: MAY CAUSE IRRITATION/DERMATITIS.
EYES: SEVERE IRRITANT/BLURRED VISION. INGESTION: LARGE AMOUNTS CAN
CAUSE LUNG INFLAMMATION & DAMAGE DUE T O ASPIRATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. (SEE SUPP)
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:IRRITATION, FATIGUE, DROWSINESS, DIZZINESS,
LIGHTHEADEDNESS, HEADACHE, UNCOORDINATION, NAUSEA, COUGHING,
DEFATTING, BLURRED VISION, TEARING, REDNESS, INFLAMMATION
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, RESPIRATORY
& LUNG DISORDERS, ASTHMA-LIKE CONDITIONS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. HAVE TRAINED PERSON GIVE OXYGEN IF NEEDED. SKIN: WASH
OFF QUICKLY W/PLENTY OF WATER, THEN SOAP & WATER. EYES: FLUSH
IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR 15 MINS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:105F
Lower Limits:0.7
Extinguishing Media:DRY CHEMICAL/FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL & PROTECT EXPOSED
CONTAINERS.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT/FIRE. VAPORS CAN FORM EXPLOSIVE MIXTURES IN
AIR AT ELEVATED TEMPS. EMITS TOXIC GASES UNDER FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
AREA. MAY BE COLLECTED W/NONCOMBUSTIBLE ABSORBENT MATERIALS.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 100F. KEEP AWAY FROM HEAT,
SPARKS & OPEN FLAME. KEEP CONTAINERS TIGHTLY CLOSED & UPRIGHT WHEN
NOT IN USE. USE W/ADEQUATE VENTILATION.
Other Precautions:GROUND EQUIPMENT WHEN TRANSFERRING TO PREVENT
ACCUMULATION OF STATIC CHARGE. DON'T TAKE INTERNALLY. KEEP OUT OF
REACH OF CHILDREN. AVOID CONTACT W/SKIN, EYES & BREATHING OF
VAPORS. EMPTY CONTAINERS MA Y CONTAIN HAZARDOUS RESIDUES.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE ONLY NIOSH/MSHA APPROVED RESPIRATORS
IAW/OSHA STANDARD 29 CFR 1910.134. AVOID CONDITIONS WHICH RESULT IN
FORMATION OF INHALABLE PARTICLES SUCH AS SPRAYING/ABRADING PAINTED
SURFACES.
Ventilation:DILUTION/LOCAL EXHAUST TO PREVENT BUILDUP OF VAPORS.
Other Protective Equipment:EYE WASH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL/FATAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310-400F
Percent Volatiles by Volume:78.5
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZERS, ACIDS, BASES, AMINES
Stability Condition to Avoid:EXTREME HEAT/FIRE/OPEN FLAME, SPARKS,
ELEVATED TEMPERATURES
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. AVOID DISCHARGE TO NATURAL WATERS. UN1263
COMBUSTIBLE LIQUID.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIX 170C RFT
CAGE:19740
CAGE:19740
============= Composition/Information on Ingredients =============
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <5%
OSHA PEL:SEE TABLE Z3
ACGIH TLV:0.1 MG/M3 RDUST;9293
Ingred Name:PARTICULATES NOT OTHERWISE REGULATED (NUISANCE DUST)
Fraction by Wt: 100%
OSHA PEL:15 MG/M3 TOTAL DUST
ACGIH TLV:10 MG/M3 TDUST; 8990
===================== Hazards Identification =====================
Effects of Overexposure:REPEATED INHALATION OF RESP. FREE CRYSTALLINE
SILICA MAY CAUSE DELAYED LUNG INJURY (SILICOSIS).
======================= First Aid Measures =======================
First Aid:TERMINATE EXPOSURE.
======================Handling and Storage ======================
Handling and Storage Precautions:REMOVAL OF THIS PRODUCT AFTER USE MAY
RESULT IN THE GENERATION OF DUST.
Other Precautions:REPEATED INHALATION OF RESPIRABLE FREE CRYSTALLINE
SILICA DUST MAY CAUSE DELAYED LUNG INJURY (SILICOSIS).
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FULL FACEPIECE RESPIRATOR W/APPROPRIATE FILTER
PAD OR CARTRIDGE(S)
Ventilation:LOCAL EXHAUST AND MECHANICAL
Other Protective Equipment:AS REQUIRED TO MEET APPLICABLE OSHA
STANDARDS.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Spec Gravity:0.8
Solubility in Water:INSOLUBLE
Appearance and Odor:COARSE AGGREGATE W/FINE POWDERED MATRIX.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
==================== Disposal Considerations ====================
Waste Disposal Methods:ROUTINE HOUSEKEEPING
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:METHYL ALCOHOL 14280, A54RS50
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL; (METHANOL) (SARA 313) (CERCLA) LD50 (ORAL
RAT): 5628 MG/KG
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: >99%
OSHA PEL:200 PPM, S
ACGIH TLV:200 PPM/250 STEL, S
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:SUP DAT: BERYLLIUM DIHYDRIDE, CARBON TETRACHLORIDE +
METALS, CHLOROFORM + HEAT, CHLOROFORM + SODIUM HYDROXIDE, (ING 3)
RTECS #:9999999ZZ
Ingred Name:ING 2: CYANURIC CHLORIDE, DIETHYL ZINC, NITRIC ACID, &
POTASSIUM TERTBUTOXIDE. PLEASE REFER TO THE NFPA FIRE (ING 4)
RTECS #:9999999ZZ
Ingred Name:ING 3: PROTECTION GUIDE FOR ALL SPECIFICS.
RTECS #:9999999ZZ
Ingred Name:EFTS OF OVEREXP: CHRONIC: PRLNG/RPTD SKIN CONT MAY CAUSE
DERM. CHRONIC INHAL & INGEST MAY CAUSE EFTS SIMILAR TO (ING 6)
RTECS #:9999999ZZ
Ingred Name:ING 5: THOSE OF ACUTE INHALATION AND INGESTION.
RTECS #:9999999ZZ
Ingred Name:FIRST AID PROC: INDUCE VOMIT BY GIVING 1 TEASPOON OF SYRUP
OF IPECAC. INHAL: GET MED AID IMMED. REMOVE FROM (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7: EXPOS TO FRESH AIR IMMED. IF NOT BRTHG, GIVE ARTF
RESP. IF BRTHG IS DFCLT, GIVE OXYGEN. NOTES TO MD: EFTS (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8: MAY BE DELAYED. ETHANOL MAY INHIBIT METABOLISM.
ANTIDOTE: NO SPECIFIC ANTIDOTE EXISTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MOD IRRIT. VAPS MAY CAUSE
IRRIT. MAY CAUSE PAINFUL SENSIT TO LIGHT. SKIN: MAY CAUSE IRRIT.
MAY BE ABSORBED THRU SKIN IN HARMFUL AMTS. INGEST: MAY CAUSE IRRIT
OF DIGESTIVE TRACT. MAY CAUSE CNS DEPRESS, INCL EXCITEMENT,
FOLLOWEDBY HDCH, DIZZ, DROW, & NAUS. ADVANCED STAGES MAY CAUSE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: COLLAPSE, UNCON, COMA & POSS DEATH
DUE TO RESP FAILURE. MAY CAUSE KIDNEY FAILURE. INHAL: MAY CAUSE
RESP TRACT IRRIT, LIVER & KIDNEY DAMAGE, ADVERSE CNS EFTS INCLUDING
HDCH, CONVULSIONS, & PO SS DEATH. MAY CAUSE VISUAL IMPAIRMENT &POSS
PERM BLINDNESS, & EFTS SIMILAR TO THOSE DESCRIBED FOR INGEST. (ING
5)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN,
OCCASIONALLY LIFTING UPPER & LOWER LIDS. GET MED AID IMMED. DO NOT
ALLOW VICTIM TO RUB/KEEP EYES CLOSED. SKIN: FLUSH W/PLENTY OF SOAP
& WATER FOR AT LEAST 15 MIN WHILE REMOVING CONTAMINATED CLOTHING &
SHOES. GET MED AID IF IRRIT DEVELOPS/PERSISTS. INGEST: IF CONSCIOUS
& ALERT, GIVE 2-4 CUPFULS OF MILK/WATER. GET MED AID IMMED. (ING 7)
===================== Fire Fighting Measures =====================
Flash Point:53.6F,12.0C
Lower Limits:6.00%
Upper Limits:31.00%
Extinguishing Media:FOR SMALL FIRES, USE DRY CHEMICAL, CARBON DIOXIDE,
WATER SPRAY OR ALCOHOL-RESISTANT FOAM.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS. WATER
MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:CONTRS CAN BUILD-UP PRESS IF EXPOSED TO
HEAT &/OR FIRE. VAPS CAN TRAVEL TO SOURCE OF IGNIT & FLASH BACK.
DURING FIRE, IRRITATING & HIGHLY TOX GASES (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERS PROT EQUIP AS INDICATED. SCOOP
UP W/NON-SPARKING TOOL, THEN PLACE INTO SUITABLE CONTR FOR DISP.
USE WATER SPRAY TO DISPERSE GAS/VAP. REMOVE SOURCES OF IGNIT.
ABSORB SPILL USING ABSORB,NON-COMBUST MATL SUCH AS EARTH,
SAND/VERMICULITE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENT. EMPTY CONTAINERS
RETAIN PROD RESIDUE (LIQUID, &/OR VAPOR), & CAN BE DANGEROUS. DO
NOT GET ON SKIN/IN EYES. DO NOT INGEST/INHALE.
Other Precautions:DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL,
GRIND/EXPOSE EMPTY CONTAINERS TO HEAT, SPARKS/OPEN FLAMES. KEEP
AWAY FROM SOURCES OF IGNITION. STORE IN COOL, DRY, WELL-VENTILATED
AREA AWAY FROM IN COMPATIBLE SUBSTANCES. FLAMMABLES-AREA.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN
29 CFR 1910.134. ALWAYS USE A NIOSH APPROVED RESPIRATOR WHEN
NECESSARY.
Ventilation:USE ADEQUATE GENERAL OR LOCAL EXHAUST VENTILATION TO KEEP
AIRBORNE CONCENTRATIONS BELOW THE PERMISSIBLE EXPOSURE LIMITS.
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA . WEAR APPROPRIATE PROTECTIVE CLOTHING.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE
CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ: MAY BE GENERATED BY THERMAL DECOMP/COMBUST. FLAM LIQ. CAN
RELEASE VAPS THAT FORM EXPLO MIXTS AT TEMPS ABOVE FLASH POINT.
MATLS TO AVOID: SODIUM HYPOCHLORITE). ACTIVE METALS (SUCH AS
POTASSI UM & MAGNESIUM). SUBSTANCE IS ALSO INCOMPATIBLE W/SPECIFIC
CHEMS INCL: ACETYL BROMIDE, ALKYL ALUMINUM SALTS, (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:148F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:96 MMHG
Vapor Density:1.1
Spec Gravity:0.791
Evaporation Rate & Reference:5.2 (ETHER=1)
Solubility in Water:MISCIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID, WITH SLIGHT ALCOHOL-LIKE
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDANTS (SUCH AS BARIUM PERCHLORATE, BROMINE, CHLORINE, HYDROGEN
PEROXIDE, LEAD PERCHLORATE, PERCHLORIC ACID, (SUP DAT)
Stability Condition to Avoid:HIGH TEMPERATURES, INCOMPATIBLE MATERIALS,
IGNITION SOURCES.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
FORMALDEHYDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL,
STATE, AND LOCAL REGULATIONS. RCRA U-SERIES: WASTE NUMBER U154
(IGNITABLE WASTE). THIS MATERIAL IS BANNED FROM LAND DISPOSAL
ACCORDING TO RCRA.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MANNITOL, M1120, M1128, MA165, MA170; CODE M3410
Preparer's Name:E. BRULL
CAGE:63415
CAGE:63415
CAGE:TO829
============= Composition/Information on Ingredients =============
Ingred Name:MANNITOL. (C6H1406)
CAS:69-65-8
RTECS #:OP2060000
= Wt:100.
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL TOXICITY (LD50): 13500 MG/KG (RAT).
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE: SLIGHTLY DANGEROUS TO DANGEROUS
IN CASE OF INGESTION. VERY SLIGHTLY TO SLIGHTLY DANGEROUS IN CASE
OF SKIN OR EYE CONTACT (IRRITANT), AND INHALATION. CHRONIC: THERE
IS NO KNOWN EFFECT FROM CHRON IC EXPOSURE TO THIS PRODUCT.
CARCINOGENIC EFFECTS, MUTAGENIC EFFECTS AND TERATOGENIC EFFECTS:
NOT AVAILABLE. TOXICITY OF PRODUCT TO REPRODUCTIVE SYSTEM: NOT
AVAILABLE.
Medical Cond Aggravated by Exposure:REPEATED OR PROLONGED EXPOSURE IS
NOT KNOWN TO AGGRAVATE MEDICAL CONDITION.
======================= First Aid Measures =======================
First Aid:EYE CONT: IMMED FLUSH EYES W/RUNNING WATER FOR AT LEAST 15
MINS, KEEPING EYELIDS OPEN. COLD WATER MAY BE USED. SKIN CONT: IF
CHEM GOT ONTO CLOTHED PORTION OF BODY, REMOVE CONTAM CLTHG AS
QUICKLY AS PO SS, PROT YOUR OWN HANDS & BODY. PLACE VICTIM UNDER
DELUGE SHOWER. IF CHEM TOUCHES EXPOS SKIN, THOROUGHLY WASH CONTAM
SKIN W/RUNNING WATER & NON-ABRASIVE SOAP. BE PARTICULARLY CAREFUL
TO CLEAN FOLDS, C REVICES, CREASES, & GROIN. COLD WATER MAY BE
USED. COVER IRRIT SKIN W/EMOLIENT. IF IRRIT PERSISTS, SEEK MED
ATTN. WASH CONTM CLTHG BEFORE REUSING. SERIOUS SKIN CONT: NO ADDNL
INFO. INHAL: ALLOW VICTI M TO REST IN WELL VENT (OTHER INFO).
===================== Fire Fighting Measures =====================
Flash Point:NOT AVAILABLE.
Autoignition Temp:=460.C, 860.F
Lower Limits:NOT AVAILABL
Upper Limits:NOT AVAILABL
Extinguishing Media:SMALL FIRE: USE DRY CHEMICALS, CO2, WATER SPRAY, OR
FOAM. LARGE FIRE: USE WATER SPRAY, FOG OR FOAM. DO NOT USE WATER
JET.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . PRODUCTS OF COMBUSTION: CARBON OXIDES (CO, CO2).
FLAMMABILITY OF THE PRODUCT: COMBUSTIBLE.
Unusual Fire/Explosion Hazard:NO SPECIFIC INFORMATION IS AVAILABLE IN
DATABASE REGARDING FLAMMABILITY OR RISKS OF EXPLOSION OF PRODUCT IN
PRESENCE OF VARIOUS MATERIALS. RISKS OF EXPLOSION OF PRODUCT IN
PRESENCE OF MECHANICAL IMPAC T OR STATIC DISCHARGE: NOT AVAILABLE.
SPECIAL REMARKS ON FIRE & EXPLOSION HAZARDS: NO ADDITIONAL REMARKS.
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILL: USE APPROP TOOLS TO PUT SPILLED
SOLID IN A CONVENIENT WASTE DISP CNTNR. FINISH CLEANING BY
SPREADING WATER ON CONTAM SURFACE & DISPOSE OF ACCORD TO LOCAL &
REGIONAL AUTHORITY REQ. LRG SPILL:DATABASE CONTAINS NO ADDNL INFO
IN CASE OF A SPILL &/OR LEAK OF PROD. USE A SHOVEL TO PUT MATL IN
CONVENIENT WASTE DISP CNTNR. FINISH CLEANING BY SPREADING WATER ON
CONTAM SURF & ALLOW (WASTE DISP).
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT & SOURCES OF
IGNITION. DO NOT BREATH DUST. KEEP CONTAINER DRY, IN COOL PLACE,
TIGHTLY CLOSED. GROUND ALL EQUIPMENT CONTAINING MATERIAL. KEEP IN
A COOL, WELL-VENTILATED PLACE. COMB UST MATERIALS SHOULD BE STORED
AWAY FROM EXTREME HEAT & AWAY FROM STRONG OXIDIZING AGENTS.
Other Precautions:EMPTY CONTAINERS POSE A FIRE RISK. EVAPORATE RESIDE
UNDER A FUME HOOD. GROUND ALL EQUIPMENT CONTAINING MATERIAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE
EXPOSURE OF CONCERN .
Ventilation:USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER
ENGINEERING CONTROLS TO KEEP AIRBORNE LEVELS BELOW RECOMMENDED
EXPOS LIMITS. (SUPP SFTY & HLTH).
FACESHIELD .
Other Protective Equipment:EYEWASH & DELUGE SHOWER METING ANSI DESIGN
CRITERIA . LAB COAT.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
VENTILATION: IF USER OPERATIONS GENERATE DUST, FUME OR MIST, USE
VENTILATION TO KEEP EXPOS TO AIRBORNE CONTAMS BELOW EXPOS LIMIT.
EXPOSURE LIMITS: NOT AVAILABLE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:DECOMPOSES.
Melt/Freeze Pt:=166.C, 330.8F
Vapor Pres:NOT AVAILABLE.
Vapor Density:NOT AVAIL.
Spec Gravity:1.52 (WATER=1).
pH:NOT AVAILABLE.
Solubility in Water:SOLUBLE IN COLD WATER.
Appearance and Odor:SOLID. COLOR, ODOR, TASTE, CRITICAL TEMPERATURE,
VOLATILITY: NOT AVAILABLE.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO SPECIFIC INFORMATION IS AVAILABLE IN DATABASE REGARDING REACTIVITY
OF MATERIAL IN PRESENCE OF VARIOUS OTHER MATERIALS. SPECIAL REMARKS
ON REACTIVITY: NO ADDITIONAL REMARK.
Stability Condition to Avoid:INSTABILITY TEMPERATURE: NOT AVAIL.
CONDITIONS OF INSTABILITY: NO ADDITIONAL REMARK. CORROSIVITY:
NON-CORROSIVE IN PRESENCE OF GLASS. SPECIAL REMARKS CORROSIVITY:
NO ADDTL REMARK.
=================== Toxicological Information===================
Toxicological Information:TOXICITY TO ANIMALS: ACUTE ORAL TOXICITY
(LD50): 13500 MG/KG (RAT). SPECIAL REMARKS ON TOXICITY TO ANIMALS,
CHRONIC EFFECTS ON HUMANS, AND OTHER TOXIC EFFECTS ON HUMANS: NO
ADDITIONAL REMARKS. TOXIC OLOGICAL DATA ON INGREDIENTS: NOT
APPLICABLE. TOXICITY OF THE PRODUCT TO THE REPRODUCTIVE SYSTEM: NOT
AVAILABLE.CARCINOGENIC EFFECTS: NOT AVAILABLE. MUTAGENIC EFFECTS:
NOT AVAILABLE. TERATOGENIC EFF ECTS: NOT AVAILABLE.
PHYSICAL/CHEMICAL: ODOR THRESHOLD, WATER/OIL DIST. COEFF.,
IONICITY: NOT AVAILABLE. DISPERSION PROPERTIES: SEE SOLUBILITY IN
WATER.
===================== Ecological Information =====================
Ecological:ECOTOXICITY, BOD5 AND COD: NOT AVAILABLE. PRODUCTS OF
BIODEGRADATION: CARBON OXIDES (CO, CO2). TOXICITY OF PRODUCTS OF
BIODEGRADATION: THE PRODUCTS OF DEGRADATION ARE MORE TOXIC. SPECIAL
REMARKS ON PR ODUCTS OF BIODEGRADATION: NO ADDITIONAL REMARK.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE W/APPLICABLE FEDERA, STATE
AND LOCAL REGULATIONS . RECYCLE TO PROCESS, IF POSS. CONSULT LOCAL
OR REGIONAL AUTH. SPILL/RELEASE: TO EVACUATE THRU SANITARY SYSTEM.
SUGGESTED PROT CLOTHES MAY NOT BE SUFFICIEN T. CONSULT A SPECIALIST
BEFORE HANDLING PRODUCT.
=================== MSDS Transport Information ===================
Transport Information:DOT CLASSIFICATION: NOT A DOT CONTROLLED MATERIAL
(UNITED STATES). IDENTIFICATION: NOT APPLICABLE (PIN AND PG).
SPECIAL PROVISIONS FOR TRANSPORT: NOT APPLICABLE. D.O.T.
===================== Regulatory Information =====================
Federal Regulatory Information:THE FOLLOWING PRODUCT IS LISTED ON TSCA:
MANNITOL. OTHER REGULATIONS: OUR DATABASE CONTAINS NO SPECIAL
CONSIDERATIONS ON THE PRODUCT. OTHER CLASSIFICATION: NOT
CONTROLLED UNDER WHMIS (CANADA). NOT CO NTROLLED UNDER DSCL
(EUROPE).
State Regulatory Information:CALIFORNIA PROPOSITION 65 WARNINGS:
WARNING: THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO STATE OF
CALIFORNIA TO CAUSE CANCER. CHEMICAL INGREDIENT REQUIRING THIS
WARNING: NONE. WARNING: THIS PRODUCT CON TAINS A CHEMICAL KNOWN TO
STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM. CHEMICAL REQUIRING THIS WARNING: NONE. OTHER SPECIAL
CONSIDERATIONS: NO ADDITIONAL REMARK. REFERENCES: NOT AVAILABLE.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SAVIN TONER PAK-BLACK, PART NO:4120-36
Preparer's Name:KRISTINA SAGE
CAGE:54762
CAGE:54762
CAGE:29382
CAGE:4M009
CAGE:0NU41
============= Composition/Information on Ingredients =============
Ingred Name:HYDROTREATED HEAVY NAPHTHA
CAS:64742-48-9
Fraction by Wt: 89%
Other REC Limits:NONE RECOMMENDED
Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 2%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9293
Ingred Name:ACRYLIC POLYMER
CAS:25608-63-7
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POLYETHYLENE (WAX)
CAS:9002-88-4
RTECS #:TQ3325000
Fraction by Wt: 6%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL RAT LD50: >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF HIGH
CONCENTRATIONS (>1000 PPM) MAY CAUSE RESPIRATORY IRRITATION AND
CENTRAL NERVOUS SYSTEM DEPRESSION. CONTACT MAY CAUSE SKIN AND EYE
IRRITATION. CHRONIC: HEALTH STUDIES HAVE SHO WN THAT MANY PETROLEUM
PRODUCTS POSE POTENTIAL HUMAN HEALTH RISKS WHICH VARY FROM PERSON
TO PERSON.
Explanation of Carcinogenicity:CARBON BLACK IS LISTED BY IARC AS
UNCLASSIFIABLE AS TO CARCINOGNEICITY.
Effects of Overexposure:INHALATION: COUGHING, WHEEZING, SHORTNESS OF
BREATH, HEADACHE, NAUSEA. EYES: REDNESS, BLURRED VISION, TEARING.
SKIN: REDNESS, RASH, ITCHING.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: WASH WITH
SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. GIVE
MOUTH-TO-MOUTH RESUSC ITATION IF NOT BREATHING. GET MEDICAL
ATTENTION. INGESTION: RINSE MOUTH & DRINK LARGE AMOUNTS OF WATER.
GET MEDICAL ATTENTION IF SYMPTOMS DEVELOP.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:106F,41C
Lower Limits:0.7
Upper Limits:6.5
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. VENTILATE
CONFINED OR ENCLOSED AREAS. KEEP PRODUCT OUT OF SEWERS AND
WATERWAYS. CONTAIN SPILL. ABSORB WITH INERT MATERIAL AND PLACE IN A
CONTAINER FOR LATER DISPOSAL .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
STRONG OXIDIZING AGENTS AND SOURCES OF IGNITION. KEEP CONTAINERS
CLOSED WHEN MATERIAL IS NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. EMPTY CONTAINERS MAY
CONTAIN RESIDUE AND CAN BE DANGEROUS IF WELDED, CUT, DRILLED OR
OTHERWISE HEATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:NONE NORMALLY REQUIRED.
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
USED WITH SAVIN COPIER MODELS: 7450, 7350, 7300, AND 7230.
================== Physical/Chemical Properties ==================
HCC:F4
Boiling Pt:B.P. Text:322F,161C
Vapor Pres:<10 MM HG
Vapor Density:>5 (AIR=1)
Spec Gravity:0.78 (WATER=1)
Evaporation Rate & Reference:0.3 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK LIQUID, FAINT PETROLEUM HYDROCARBON ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID CONTACT WITH STRONG OXIDIZING
AGENTS. AVOID SOURCES OF IGNITION.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:50649 DE-VO-KO WONDER-SPEED,HIGH HIDE BASE
CAGE:EO559
CAGE:EO559
CAGE:6R552
============= Composition/Information on Ingredients =============
Ingred Name:ALUMINUM SILICATE ANHYDROUS *93-1*
CAS:22708-90-3
Fraction by Wt: 1-10%
ACGIH TLV:30 MPPCF
Ingred Name:ALUMINUM SILICATE *93-1*
CAS:1335-30-4
Fraction by Wt: <5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM
Ingred Name:WEIGHT PER GALLON IN POUNDS:10.64-11.22
RTECS #:9999999WG
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 45-55%
Ingred Name:POLYVINYL ACETATE ACRYLIC RESIN
Fraction by Wt: 10-15%
Ingred Name:TITANIUM DIOXIDE, TIO2
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 5-15%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9293
Ingred Name:CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 5-20%
OSHA PEL:15 MG/CUM (DUST)
ACGIH TLV:10 MG/CUM (DUST)
Ingred Name:CLAY (KAOLIN)
CAS:1332-58-7
RTECS #:GF1670500
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:2 MG/M3 TDUST; 9293
Ingred Name:DIATOMACEOUS EARTH, FLUX-CALCINED, NATURAL, SILICA*93-1*
CAS:68855-54-9
Fraction by Wt: <5%
OSHA PEL:1.7 MPPCF
ACGIH TLV:0.80 MG/CUM
Ingred Name:PROPANOIC ACID, 2-METHYL, MONOESTER
W/2,2,4-TRIMETHYL-1,3-PENTANEDIOL, TEXANOL(ESTER ALCOHOL)
CAS:25265-77-4
RTECS #:UF6000000
Fraction by Wt: <5%
Ingred Name:ETHYLENE GLYCOL, GLYCOL
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: <5%
Other REC Limits:10 MG/CUM
ACGIH TLV:C 127 MG/CUM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:AMMONIUM HYDROXIDE, AQUA AMMONIA
CAS:1336-21-6
RTECS #:BQ9625000
Fraction by Wt: <5%
Other REC Limits:25 PPM
OSHA PEL:35 MG/CUM
ACGIH TLV:25 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: RESPIRATORY TRACT
IRRITATION, HEADACHE & DIZZINESS. SKIN/EYES: IRRITATION.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: DUST DISEASE OF THE LUNGS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/WATER FOR AT
LEAST 15 MINS. SKIN: REMOVE W/SOAP & WATER. INGESTION: DRINK 1 TO 2
GLASSES OF WATER TO DILUTE. DON'T INDUCE VOMITING. TREAT
SYMPTOMATICALLY . OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:CO2, DRY CHEMICAL, FOAM OR OTHER NFPA APPROVED
CLASS B EXTINGUISHER
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS. WATER SPRAY MAY BE INEFFECTIVE.
IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:WATER SHOULD BE USED TO COOL CLOSED
CONTAINERS & PREVENT PRESSURE BUILD-UP, AUTOIGNITION, OR EXPLOSION
WHEN EXPOSED TO FIRE OR EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:WASH W/WATER. CONTAIN SPILLED MATERIAL &
REMOVE W/INERT ABSORBENT. STORE IN CLOSED CONTAINER UNTIL PROPERLY
DISPOSED OF.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE BELOW 110F & KEEP FROM FREEZING.
KEEP CONTAINER CLOSED WHEN NOT IN USE. DON'T REUSE EMPTY
CONTAINERS. KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:OUTDOOR OR OPEN AREAS W/UNRESTRICTED VENTILATION
& DURING SANDING OR GRINDING OPERATIONS, USE NIOSH/MSHA APPROVED
MECHANICAL FILTER RESPIRATOR. RESTRICTED VENTILATION AREAS, WEAR
NIOSH/MSHA APPROVED C HEMICAL/MECHANICAL FILTERS. SEE SUPP.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST IN VOLUME & PATTERN TO
KEEP AIR CONTAMINANT CONCENTRATION BELOW APPLICABLE TLV LIMITS
Work Hygienic Practices:REMOVE/WASH CONTAMINATED CLOTHING BEFORE REUSE.
WASH HANDS BEFORE EATING, SMOKING OR USING WASHROOM.
Supplemental Safety and Health
RESPIRATORY PROTECTION (CONT'D): CONFINED AREAS, USE NIOSH/MSHA
APPROVED AIR SUPPLY RESPIRATORS OR HOODS. USE NIOSH/MSHA APPROVED
RESPIRATORS WHEN FLAME CUTTING, WELDING, BRAZING & SANDING MATERIAL
CO ATED W/PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212-387F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:68-75
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO, CO2, OXIDES OF NITROGEN, & OXIDES
OF METALS IN INGREDIENTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. INCINERATE ONLY IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINERS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:INTERTUF EPOXY XD BASE
CAGE:50411
CAGE:50411
============= Composition/Information on Ingredients =============
Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC
PETROLEUM DISTILLATES). VP:3.0 @ 20C
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 10%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)
Ingred Name:2-HEPTANONE; (METHYL N-AMYL KETONE). VP:2.14 @ 20C
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 6%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM
Ingred Name:XYLENE (SARA 313) (CERCLA). VP:5.1 @ 20C
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:PHOSPHORIC ACID, ZINC SALT (2:3); (ZINC PHOSPHATE)
CAS:7779-90-0
RTECS #:TD0590000
Fraction by Wt: 7%
OSHA PEL:10 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: 2%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:OTHER PREC:BRAZE/WELD WITHOUT NIOSH APPRVD MECH FILTER
RESP/APPROP & ADEQ VENT. ALL ELEC EQUIP & INSTALLATIONS (ING 7)
RTECS #:9999999ZZ
Ingred Name:ING 6:SHOULD BE MADE & GROUNDED I/A/W NATIONAL ELEC CODE.
WORKMEN ARE REQD TO USE ONLY NON-FERROUS TOOLS & WEAR (ING 8)
RTECS #:9999999ZZ
Ingred Name:ING 7:NON-SPARKING SHOES IN AREAS WHERE EXPLO HAZ EXIST. IF
WORKMEN ARE EXPOS TO SPRAY APPLIC/ABRASIVE BLAST (ING 9)
RTECS #:9999999ZZ
Ingred Name:ING 8:CLEANING, ENGINEERING & ADMINISTRATIVE CONTROLS MUST
BE USED TO MAINTAIN EXPOS LEVEL BELOW OSHA REQD (ING 10)
RTECS #:9999999ZZ
Ingred Name:ING 9:LEVEL/USE NIOSH APPRVD MECH FILTER RESP/PROT. THIS
PROD CONTAINS CRYSTALLINE SILICA WHICH CAN CAUSE (ING 11)
RTECS #:9999999ZZ
Ingred Name:ING 10:ADVERSE HLTH EFTS WHEN RESPIRED. REC USE OF PROD IS
NOT EXPECTED TO CREATE SUCH EXPOSURE RISK. SANDING (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11:OF DRIED COATING IS NOT REC. IF SANDING OF DRIED
COATING IS PERFORMED, ENGINEERING & ADMINISTRATIVE (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12:CONTROLS MUST BE USED TO MAINTAIN EXPOSURE LEVEL
BELOW APPLIC PEL, OR APPROP NIOSH APPRVD RESP MUST USED (ING 14)
RTECS #:9999999ZZ
Ingred Name:ING 13:FOR PROTECTION.
RTECS #:9999999ZZ
Ingred Name:RESP PROT:PARTICULATES, GAS & VAPOR. IN CONFINED AREAS, USE
NIOSH APPRVD AIR-LINE RESPIRATORS AND HOOD.
RTECS #:9999999ZZ
Ingred Name:VENT:AND LOWER EXPLO LEVEL (LEL) BELOW STATED LIMIT & TO
REMOVE DECOMP PRODS DURING WELDING & FLAME CUTTING OF (ING 17)
RTECS #:9999999ZZ
Ingred Name:ING 16:SURFACES COATED WITH THIS PRODUCT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRIT OF RESP TRACT/ACUTE
NERV SYS CAUSING HDCH, DIZZ/NAUS. EYE & SKIN:PRIMARY IRRIT. INHAL
OF SOLV VAP MAY CAUSE NOSE & THROAT IRRIT & DIZZ , NAUS, HDCH &
SLEEPINESS. DIRECT EYE /SKIN CON T MAY CAUSE MOD TO SEV IRRIT &
SKIN SENSIT. SOLV CAN BE ABSORBED INTO BODY THROUGH SKIN. OVEREXP
OR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ:IARC
MONOGRAPHS, SUPP. VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL RPT
ON CARCINS, (SUPDAT)
Effects of Overexposure:HLTH HAZ:INTENTIONAL INHAL OF VAP MAY CAUSE
HEART ABNORM. PRLNGD/RPTD OVEREXP MAY CAUSE ANEMIA, PERM BRAIN &
NERV SYS DMG, LIVER, KIDNEY & EYE DMG.
Medical Cond Aggravated by Exposure:CRYSTALLINE SILICA MAY AGGRAVATE
EXISTING RESPIRATORY CONDITIONS. SMOKING AGGRAVATES THE EFFECTS OF
OVEREXPOSURE.
======================= First Aid Measures =======================
First Aid:INGEST:CALL MD IMMEDIATELY . INHAL:REMOVE FROM EXPOSURE. KEEP
WARM & QUIET. NOTIFY PHYS. EYES:FLUSH IMMEDIATELY W/LG AMTS OF
WATER FOR @ LST 15 MINUTES. TAKE TO PHYSICIAN FOR MEDICAL
TREATMENT.SKIN:WASH AFFECTED AREAS W/LG AMTS OF WATER. REMOVE
CONTAMINATED CLOTHING.
===================== Fire Fighting Measures =====================
Flash Point:102F,39C
Lower Limits:0.7-1.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPKS, ELEC EQUIP, & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. IN ABSENCE OF (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAMES, HOT
SURFACES, & ELECTRICAL, STATIC/FRICTION SPARKS). AVOID BRTHG
VAPORS, WEAR APPRVD (NIOSH) RESP, & VENTILATE AREA. REMOVE W/INERT
ABSORB SUCH AS SAND, KITTY L ITTER, ETC, AND USE NON-SPARKING
TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:SECURE CLOSURES & KEEP CNTNRS UPRIGHT
TO PVNT LEAKAGE. STORE LG QTYS ONLY IN BUILDING DESIGNED TO COMPLY
W/OSHA 1910.106. DO NOT STORE >120F.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT GET IN EYES/ON SKIN.
AVOID BRTHG VAPS/SPRAY MIST. DO NOT STORE/USE NEAR HEAT, SPKS/OPEN
FLAME. CNTNRS SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL OF
LIQ IN EXCESS O F FEW INCHES. DO NOT FLAME CUT, (ING 6)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IN OUTDOOR/OPEN AREAS W/UNRESTRICTED VENT, USE
NIOSH APPRVD MECH FILTER RESP TO REMOVE SOLID AIRBORNE PARTICLES OF
OVERSPRAY DURING SPRAY APPLIC. IN RESTRICTED VENT AREAS, USE NIOSH
APPRVD MECH FILTERRESPS DESIGNED TO REMOVE (ING 15)
Ventilation:PROVIDE GEN DILUTION/LOC EXHAUST VENT IN VOL & PATTERN TO
KEEP THRESHOLD LIM VALUES (TLV) BELOW STATED OSHA LIMS(ING 16)
Other Protective Equipment:AS NEEDED-USE BODY PROT, SUCH AS RUBBER
APRON, ETC. ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:BEFORE SMOKING/EATING, WASH HANDS THOROUGHLY.
Supplemental Safety and Health
EXPLO HAZ:ELECTRICITY, WATER SPRAY (FOG NOZZLE IS PREFERRED) MAY BE
USED TO COOL CONTAINERS. AVOID EXPOSURE TO DECOMPOSITION. REFER TO
D.O.T. P 5800.3 (1984 EMERERGENCY RESPONSE BOOK, GUIDBOOK FOR HAZ
MATLS' INCIDENT" GUIDE NO. 26, ID NO. 1263). EXPLAN OF
CARCIN:1994:ANTICIPATED TO BE CARCINOGEN.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>210F,>99C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.51
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:30
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:MAY PRDCE HAZ FUMES WHEN HEATED TO
DECOMP AS IN WELDING. FUMES MAY PRDCE CARBON DIOXIDE & CARBON
MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN A SAFE MANNER IN ACCORDANCE WITH
LOCAL, STATE, AND FEDERAL REGULATIONS THAT APPLY TO INCINERATION OR
SECURE LANDFILL.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MARKING CHALK-RED
CAGE:0NML2
CAGE:0NML2
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL; (SILICON DIOXIDE (AMORPHOUS))
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <1%
OSHA PEL:6 MG/M3
ACGIH TLV:10 MG/M3
Ingred Name:TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)
CAS:14807-96-6
RTECS #:MW2700000
Fraction by Wt: 10-20%
OSHA PEL:0.2 FIBERS/CC
ACGIH TLV:0.2 FIBER/CC, A1
Ingred Name:SILICA, CRYSTALLINE - QUARTZ
CAS:14808-60-7
RTECS #:VV7330000
Fraction by Wt: <2%
OSHA PEL:SEE TABLE Z-3
ACGIH TLV:0.1 MG/M3 RDUST
Ingred Name:CARBONIC ACID, CALCIUM SALT; (CALCIUM CARBONATE)
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: >50%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:IRON (III) OXIDE; (PIGMENT RED 101) (IRON OXIDE RED)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <20%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG(FE)/M3 FUME, B2
Ingred Name:ARSENIC (SARA 313) (CERCLA) (<100 PPM)
CAS:7440-38-2
RTECS #:CG0525000
Fraction by Wt: <0.1%
OSHA PEL:SEE 1910.1018
ACGIH TLV:0.01 MG/M3, A1
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:CADMIUM (SARA 313) (CERCLA) (<5 PPM)
CAS:7440-43-9
RTECS #:EU9800000
Fraction by Wt: <0.1%
OSHA PEL:0.2 MG/M3 DUST; Z-2
ACGIH TLV:0.01 MG/M3 DUST
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Ingred Name:MERCURY (SARA 313) (CERCLA) (<1 PPM)
CAS:7439-97-6
RTECS #:OV4550000
Fraction by Wt: <0.1%
OSHA PEL:C, 0.1 MG/M3; Z-2
ACGIH TLV:S, 0.025 MG/M3; A4
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:NICKEL (SARA 313) (CERCLA)(<400 PPM)
CAS:7440-02-0
RTECS #:QR5950000
Fraction by Wt: <0.1%
OSHA PEL:1 MG/M3
ACGIH TLV:1 MG/M3
Ingred Name:LEAD (SARA 313) (CERCLA) (<100 PPM)
CAS:7439-92-1
RTECS #:OF7525000
Fraction by Wt: <0.1%
OSHA PEL:SEE 1910.1025
ACGIH TLV:0.15 MG/M3 DUST
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SUPDAT: MONO ON EVAL OF CARCIN RISK OF CHEM TO MAN, VOL 49,
PG 257, 1990:GROUP 2B. NTP 7TH ANNUAL RPT ON (ING 12)
RTECS #:9999999ZZ
Ingred Name:ING 11: CARCINS, 1994:ANTIC TO BE CARCIN. HUMAN:LUNGS,
NASAL CAVITIES. SILICA, CRYSTALLINE-QUARTZ:IARC MONO, (ING 13)
RTECS #:9999999ZZ
Ingred Name:ING 12: SUPP. VOL 7, PG 341, 1987:GROUP 2A. NTP 7TH ANNUAL
PRT ON CARCINS, 1994:ANTIC TO BE CARCINOGEN.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:LEAD APPEARS ON NAVY LIST OF OCCUP
CHEM REPROD HAZARDS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO . ACUTE:IRRIT MAY RSLT FROM PRL NGD/RPTD EXPOS BY INHAL/BY EYE
CONT. PRLNGD INHAL OF IRON OXIDE DUST MAY RSLT IN CNDTN OF LUNG
KNOWN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:ARSENIC:IARC MONO, SUPP. VOL 7, PG 100,
1987:GROUP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:KNOWN TO BE
CARCIN. (SUPDAT)
Effects of Overexposure:HLTH HAZ:AS SIDEROSIS. PRLNGD INHAL OF SILICON
DIOXIDE MAY RSLT IN SILICOSIS. THERE IS SOME EVID THAT THIS MATL
MAY BE CARCINOGENIC. CALCIUM CARBONATE CONTAINS CRYSTALLINE SILICA
AT LEVELS BETWEEN 0.0 1%-2%. THERE IS SOME EVIDENCE THAT
THISMATERIAL MAY BE CARCINOGENIC. LIMIT EXPOSURE TO THE LOWEST
LIMIT POSSIBLE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH W/WATER FOR @ LEAST 15 MINS. CALL PHYS IF IRRIT
CONTINUES. SKIN:WASH IMMED W/SOAP & PLENTY OF WATER. INHAL:REMOVE
TO FRESH AIR. GIVE ARTF RESP IF NOT BRTHG. CALL PHYS. INGEST:CALL
PHYS IMME D.
===================== Fire Fighting Measures =====================
Flash Point:NONE-FLAMMABLE
Extinguishing Media:NONE. USE WATER TO COOL FIRE-EXPOSED CONTAINERS.
WATER MAY BE USED TO WASH SPILLS AWAY FROM EXPOSURES.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID BREATHING VAPORS OR DUST.
Unusual Fire/Explosion Hazard:CALCIUM OXIDE, CARBON DIOXIDE, TOXIC
OXIDES OF CARBON.
================== Accidental Release Measures ==================
Spill Release Procedures:VACUUM OR SCOOP MATERIAL INTO APPROP CNTNR FOR
RECLAMATION/DISP. IF EXCESSIVE DUST IS GENERATED, USE APPROP
NIOSH/MSHA APPRVD RESPIRATORY EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND EYES.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL VENT TO KEEP DUST LEVS BELOW REC EXPOS LIM. IF EXPOS
LIM ARE EXCEEDED, NIOSH/MSHA APPRVD DUST RESP SHOULD BE WORN.
Other Protective Equipment:ANSI APPRVD EMERGENCY EYE WASH & DELUGE
SHOWER .
Work Hygienic Practices:WASH THORO AFTER HNDLG, WASH CONTAMD CLTHG
BEFORE REUSE. FOLLOW GOOD HOUSEKEEPING PROCEDURES.
Supplemental Safety and Health
PH:8.6-8.8 (SATURATED SOLUTION). EXPLAN OF CARCIN:CODE OF FED REGS, VOL
29, PG 1910.1018, 1987:OSHA CANCER HAZ. ANIMAL:LUNG & LYMPHATIC
CANCER. CADMIUM:IARC MONO, SUPP, VOL 7, PG 139, 1987:GROUP 2A. N TP
7TH ANNUAL RPT ON CARCINS, 1994:ANTIC TO BE CARCIN. HUMAN:LUNG,
PROSTATE, RENAL SYS EFTS. NICKEL CMDPS:IARC (ING 11)
================== Physical/Chemical Properties ==================
Melt/Freeze Pt:M.P/F.P Text:>1500F,>816
Spec Gravity:3.2 (H*2O=1)
pH:SUPDAT
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED POWDER, ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
(W/CALCIUM CARBONATE):ACIDS, ALUMINUM, FLUORINE, MAGNESIUM, ALUM OR
AMMONIUM SALTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:TOXIC OXIDES OF CARBON AND CALCIUM
OXIDE UPON THERMAL DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL, STATE, AND FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:BLACK DEVELOPER FOR DC-1605, 1656, 1685, 1855, 2155
CAGE:65678
CAGE:65678
============= Composition/Information on Ingredients =============
Ingred Name:IRON (III) OXIDE; (IRON OXIDE)
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: 67%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5 MG/M3 FUME (FE)
Ingred Name:ZINC OXIDE (SARA 313) (CERCLA)
CAS:1314-13-2
RTECS #:ZH4810000
Fraction by Wt: 18%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Ingred Name:COPPER OXIDE
CAS:1317-38-0
RTECS #:GL7900000
Fraction by Wt: 10%
OSHA PEL:1 MG CU/M3
ACGIH TLV:1 MG CU/M3
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE IN NORMAL HANDLING AND USE.
MINIMAL RESPIRATORY TRACT IRRITATION MAY OCCUR AS WITH EXPOSURE TO
LARGE AMOUNTS OF ANY NON-TOXIC DUST.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NOT APPLICABLE.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . SKIN: WASH WITH SOAP AND WATER.
EYES: FLUSH THOROUGHLY WITH WATER FOR AT LEAST 15 MINUTES AND SEEK
MEDICAL TR EATMENT. INGEST: DILUTE STOMACH CONTENTS WITH SEVERAL
GLASSES OF WATER AND SEEK MEDICAL TREATMENT.
===================== Fire Fighting Measures =====================
Extinguishing Media:IF PRODUCT BECOMES INVOLVED IN A FIRE, USE CARBON
DIOXIDE EXTINGUISHER. WATER, FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE UNDER NORMAL STORAGE AND USE
CONDITIONS.
================== Accidental Release Measures ==================
Spill Release Procedures:CLEAN UP WITH A VACUUM CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:CLOSE CAP TIGHTLY AND STORE IN A COOL,
DRY AND DARK PLACE.
Other Precautions:AVOID COMBUSTION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL USE. USE NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:NONE REQUIRED UNDER NORMAL USE.
Other Protective Equipment:NONE REQUIRED UNDER NORMAL USE.
Work Hygienic Practices:AVOID INHALATION, INGESTION, SKIN OR EYE
CONTACT.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Spec Gravity:1.91 (H*2O=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:FINE BLACK POWDER; PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE IN NORMAL HANDLING AND USE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DEVRAN, DV229C BASE
Kit Part:Y
Preparer's Name:H KLINE
CAGE:0Y2E4
CAGE:55849
CAGE:0Y2E4
============= Composition/Information on Ingredients =============
Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE). LD50 (ORAL, RAT): 10
G/KG
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <30%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9495
Ingred Name:IRON OXIDE; (IRON OXIDE (RED))
CAS:1309-37-1
RTECS #:NO7400000
Fraction by Wt: <10%
OSHA PEL:10 MG/M3 (FE)
ACGIH TLV:5MG(FE)/M3FUME,B2;95
Ingred Name:ALUMINO-SILICATE
CAS:37244-96-5
Fraction by Wt: <15%
OSHA PEL:5 MG/M3 (MFR)
ACGIH TLV:5 MG/M3 (MFR)
Ingred Name:XYLENE (SARA 313) (CERCLA). VP: 6.6 @ 68F. LD50 (ORAL,
RAT): 3.9 G/KG
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1.03%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM/150STEL;9495
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:N-BUTYL ALCOHOL; (BUTYL ALCOHOL) (SARA 313) (CERCLA). VP:
4.3 @ 68F. LD50 (ORAL, RAT): 4.2 G/KG
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 2.83%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9495
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (1-METHOXY
2-PROPANOL ACETATE). VP: 2.1 @ 68F. LD50 (ORAL, RAT): 12 G/KG
CAS:108-65-6
RTECS #:AI8925000
Fraction by Wt: 12.77%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:METHYL N-AMYL KETONE. VP: 2.1 @ 68F. LD50 (ORAL, RAT): 12
G/KG
CAS:110-43-0
RTECS #:MJ5075000
Fraction by Wt: 4.43%
OSHA PEL:100 PPM
ACGIH TLV:50 PPM; 9495
Ingred Name:P-CHLOROBENZOTRIFLUORIDE. VP: 5.3 @ 68F. LD50 (ORAL, RAT):
2.7 G/KG
CAS:98-56-6
RTECS #:XS9145000
Fraction by Wt: 20.97%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC RESIN. VP: 3.38 @ 68F
CAS:29354-73-2
Fraction by Wt: <10%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:ACRYLIC RESIN. VP: 3.7 @ 68F
CAS:29354-73-2
Fraction by Wt: <20%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:BISPHENOL A EPOXY RESIN; (EPOXY RESIN (SARA)). LD50 (ORAL,
RAT): 20 G/KG
CAS:25036-25-3
Fraction by Wt: <15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC CONTENT MIXED: 384 G/L. MIXED THINNED: 420
G/L
RTECS #:9999999VO
Ingred Name:SUPDAT: CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY.
RTECS #:9999999ZZ
Ingred Name:SPILL PROC: OCCURS, NOTIFY LOCAL AUTHORITIES.
RTECS #:9999999ZZ
Ingred Name:RESP PROT: TO CHEM HAZ. "IN CONFINED/RESTRICTED VENT AREAS
USE AIR-LINE RESP/HOODS. REFER TO 29 CFR, OSHA PARTS (ING 16)
RTECS #:9999999ZZ
Ingred Name:ING 15: 1910.134 & 1915 FOR COATING OPERATIONS; PART
1910.146 CONFINED SPACES; ANSI Z68.2, PRACTICES FOR RESP PROT.
RTECS #:9999999ZZ
Ingred Name:VENT: TO KEEP AIR CONTAMINANT CONC BELOW TLV LIMS. REMOVE
WELDING/FLAME CUTTING DECOMP PRODS; FOLLOW CURRENT (ING 18)
RTECS #:9999999ZZ
Ingred Name:ING 17: ANSI 249.1 "SAFETY IN WELDING & CUTTING. "REFER TO
29 CFR PARTS 1910 & 1915, FOR COATING OPERATIONS: (ING 19)
RTECS #:9999999ZZ
Ingred Name:ING 18: PART 1910.146, CONFINED SPACES.
RTECS #:9999999ZZ
Ingred Name:OTHER PROT EQUIP: SHOE COVERINGS TO PREVENT SKIN CONTACT.
USE EXPLOSION AND SPARK-PROOF EQUIPMENT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:VAP/SPRAY MIST/SPATTERED MATL CAN BE
HARMFUL. IRRIT TO EYES, SKIN, & IF INHALED, TO NOSE & THROAT.
EXCESSIVE/PRLNG INHAL CAN CAUSE HDCH, NAUS/DIZZ. RPTD & PRLNG OCCUP
OVEREXP TO SOLV IS ASSOCD W/PERM BRAIN & NERVOUS SYS DMG &/DEATH.
OVER-EXP (PRLNG/RPTD USE) CAN AGGRAVATE/ACCENTUATE ANY OF THESE
EFTS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SKIN: IRRIT. SENSIT/ALLERGIC RXN,
SUCH AS RASH/HIVES. CAN BE ABSORBED THRU SKIN. CAN CAUSE DEFAT &
DRYING OF SKIN. INHAL: IRRIT. LUNG INJURY. CNS DMG. CHEM PNEUMONIA.
XYLENE/TOLUENE MAY CAUS E IRREGULAR HEART BEAT. HIGH VAP CONCS MAY
CAUSE KIDNEY &/LIVER DMG. EYES: SEV IRRIT. INGEST: HARMFUL IF
(SUPDAT)
Medical Cond Aggravated by Exposure:KIDNEYS, LIVER, SKIN, EYES,
RESPIRATORY, ALLERGIES, LUNGS.
======================= First Aid Measures =======================
First Aid:INHAL: REMOVE TO FRESH AIR. RESTORE NORM BRTHG. TREAT
SYMPTOMATICALLY, SEE MD. SKIN: WASH THOROUGHLY W/SOAP & H*2O.
REMOVE CONTAMD CLTHG. CONSULT MD IF IRRIT PERSISTS. EYES: FLUSH
IMMED W/PLENTLY OF H *2O FOR AT LEAST 15 MIN & GET MED ATTN.INGEST:
DRINK 1 OR 2 GLASSES OF H*2O TO DILUTE. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCON PERS. DO NOT INDUCE VOMIT (UNLESS METHANOL LISTED
IN SECTION (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:103F,39C
Lower Limits:0.90%
Upper Limits:13.10%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROT EQUIPMENT
. WATER MAY BE USED TO COOL CLOSED CNTNRS TO PVNT PRESS
BUILD-UP/EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT AND PRESSURE BUILDUP. MAY PRODUCE A
FLOATING FIRE HAZARD. KEEP AWAY FROM HEAT AND OPEN FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT. AVOID BRTHG VAP.
VENT AREA. USE ABSORB, INERT, CLEANUP MATLS. (DO NOT USE SAWDUST.)
REMOVE ABSORB MATL W/NON-SPARKING TOOLS. PLACE IN SEPARATE CNTNRS.
KEEP OUT OF SEWERS & WATERWAYS. IF ENTRY IS THREATENED/ (ING 14)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED, UPRIGHT WHEN
NOT IN USE. STORE IN COOL, DRY, WELL-VENTILATED AREA. AVOID
PROLONGED STORAGE TEMPERATURES ABOVE 100F.
Other Precautions:USE CAUTION WHEN POURING. AVOID BREATHING SANDING
DUST. DO NOT WELD OR FLAME CUT ON EMPTY CONTAINER. DESTROY
CONTAMINATED LEATHER AND ABSORBENT SHOES WHICH CANNOT BE
DECONTAMINATED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WEAR NIOSH CERTIFIED RESP DESIGNED TO REMOVE A
COMBINATION OF PARTICULATES (DUST/SPRAY MIST) & VAP. WHEN BRUSHING,
ROLLING/SPREADING SELECT APPROP RESP PROT FOR CNDTNS. FOR SPECIFIC
CNDTNS, REFER TO C URRENT "NIOSH POCKET GUIDE (ING 15)
Ventilation:IMPLEMENT ADMINISTRATIVE & ENGINEERING CONTROLS TO REDUCE
EXPOS. PROVIDE SUFFICIENT VENT IN VOL & PATTERN (ING 17)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
DEPENDENT UPON APPLICATN METH WEAR RESISTANT COVERALLS, & (ING 20)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, SMOKING OR USING TOILET. LAUNDER CONTAMINATED CLOTHING
BEFORE USE.
Supplemental Safety and Health
EVAP RATE: LOW: 0.34 HIGH: 0.90 (BU AC =1). EFTS OF OVEREXP: SWALLOWED.
ASPIRATION INTO LUNGS CAN DMG LUNGS & CAUSE CHEM PNEUMONIA. LIVER
DMG. TARGET ORGANS: KIDNEY, LIVER, BLOOD, LUNGS, HEART, SKIN,
EYES, STOMACH, INTESTINES, SPLEEN, CNS,FETAL DEFECTS. FIRST AID
PROC: 2). CONTACT PHYSICIAN OR POISON CONTROL (ING 13)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>244F,>118C
Vapor Pres:SEE ING
Vapor Density:HVR/AIR
Spec Gravity:1.28-1.40
Evaporation Rate & Reference:SUPDAT
Appearance and Odor:LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:51.3
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, ALKALIES.
Stability Condition to Avoid:HEAT, OPEN FLAMES, ARC OR SPARKS. AMINES
UNDER UNCONTROLLED CONDITIONS.
Hazardous Decomposition Products:BY FIRE, BURNING OR WELDING: CO, CO*2,
IRON OXIDE FUMES, CHLORINE, ALDEHYDES, FLUOROCARBON GASES. TOXIC
GASES OF FUMES.
==================== Disposal Considerations ====================
Waste Disposal Methods:PLACE IN SEPARATE, APPROPRIATE, CLOSED CONTAINER
IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL
REGULATIONS. THIS MATERIAL HAS NOT BEEN TESTED BY TOXICITY
CHARACTERISTIC LEACHING PROCEDUR E (TCLP). EPA WASTE NO: D001.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:W12,W13 "RADIUS INDICATOR FLUID"
CAGE:HO257
CAGE:38589
CAGE:HO257
============= Composition/Information on Ingredients =============
Ingred Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: >95%
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Effects of Overexposure:EYES: POSS IRRIT. SKIN:POSS SLIGHT IRRIT.
INHAL: POSS NASAL, RESPIRATORY IRRIT FROM (SEE OTHR PRECAU
======================= First Aid Measures =======================
First Aid:SKIN: WASH EXPOS AREA W/SOAP & H*20. REMOVE CONTAM CLOTHES &
CLEAN BEFORE RE-USE. EYES: FLUSH W/LRG AMTS H*20 AT LEAST 15
MIN,LIFTING LIDS.GET MED ATTN. INGEST:GIVE 2 GLASSES H*20,INDUCE
VOMIT IMMED B Y STICKING FINGER DOWN THROAT. (SEE OTHR PRECAU)
===================== Fire Fighting Measures =====================
Flash Point:241F,116C (CC)
Lower Limits:3.2
Extinguishing Media:WATER FOG,CO*2,OR DRY CHEMICAL
Fire Fighting Procedures:H*20/FOAM MAY CAUSE FROTHING WHICH CAN BE (SEE
SUPP DATA)
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM (EVEN EMPTY),PROD (EVEN RESIDUE) CAN IGNITE EXPLOSIVELY
================== Accidental Release Measures ==================
Spill Release Procedures:SM SPILL: ABSORB LIQ ON ABSORMENT
MATL,TRANSFER TO HOOD. LRG SPILL: ELIM ALL IGNIT SOURCES. STOP
SPILL AT SOURCE,DIKE AREA OF SPILL TO PREVENT SPREAD,PUMP LIQ TO
SALVAGE TANK. REMAINING LIQ MAY BE TAK EN UP ON ABSORBENT MATL &
SHOVELLED INTO CONTAINER
======================Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF MATL POSS HAZARDOUS WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES,ALL HAZARD
PRECAUTNS GIVEN FOR THIS PROD MUST BE OBSERVED.
Other Precautions:EFFECTS OF OVEREXP: EXCESSIVE INHAL OF VAPS. INGEST:
POSS GI IRRIT,NAUSEA,VOMITING,DIARRHA. EMER FIRST AID PROC: CALL A
PHYS. INHAL: REMOVE TO FRESH AIR. KEEP PERSON WARM,QUIET,GET MED
ATTN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD AIR SUPPLIED RESPIRATOR IF TLV
IS EXCEEDED.
Ventilation:SUFFICIENT MECHANICAL- GENERAL &/OR LOCAL EXHAUST
Other Protective Equipment:TO PREVENT RPTD/PRLNG SKIN CONT,WEAR
IMPERVIOUS CLOTHES,BOOT
Supplemental Safety and Health
SPECL FIRE FIGHT PROC: VIOLENT & POSS ENDANGER THE LIFE OF THE
FIREFIGHTER,ESPECIALLY IF SPRAY INTO CNTNRS OF HOT,BURNING LIQ. USE
SCBA W/FULL FACEPIECE OPERATED IN A POSITIVE PRESSURE MODE.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:387F (197C)
Vapor Pres:0.1
Vapor Density:2.6
Spec Gravity:1.115
Evaporation Rate & Reference:<1.00 (BU AC)
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS: CO*2 &
CO,ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SM SPILL: ALLOW VOLATILE PORTION TO EVAPORATE IN
HOOD. ALLOW ENOUGH TIME FOR VAPS TO COMPLETELY CLEAR HOOD DUCT
WORK. DISPOSE OF REMAINING MATL. LRG SPILL: DESTROY BY LIQ INC
INERATION. WASTE DISPOAL MUST BE IAW FEDERAL,STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:O-M-232 METHANOL,METHYL ALCOHOL
CAGE:DO973
CAGE:82925
CAGE:DO973
============= Composition/Information on Ingredients =============
Ingred Name:METHYL ALCOHOL (METHANOL) (SARA III)
CAS:67-56-1
RTECS #:PC1400000
Fraction by Wt: 99.9%
OSHA PEL:S,200PPM/250STEL
ACGIH TLV:S,200PPM/250STEL; 93
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
Effects of Overexposure:WEAKNESS,HEADACHE,NAUSEA,VOMITING,ABDOMINAL
PAIN,DIMNESS OF VISION,NARCOSIS,COMA,RESPIRATORY FAILURE
======================= First Aid Measures =======================
First Aid:INHAL:RMV TO FRESH AIR. IF NOT BRTHNG GIVE CPR; IF BRTHNG
DIFF GIVE OXYGEN, EYE:IMMED FLUSH W/PLENTY OF WATER. SKIN:WASH
W/SOAP & WATER. RTY CONTAM CLTHG&SHOES. INGEST:INDUCE VOMIT. RPT
UNTIL VOMIT IS CLEAR. NOTHG BY MOUTH IF UNCONSC. GET MEDICAL ATT
===================== Fire Fighting Measures =====================
Flash Point:54F,12C OC
Lower Limits:6.0
Upper Limits:36.5
Extinguishing Media:DRY CHENICAL,ALCOHOL FOAM,WATER SPRAY INEFFECTIVE
Fire Fighting Procedures:USE WATER TO KEEP FIRE EXPOSED CONTAINERS COOL
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT BUILDS UP PRESSURE IN
CLOSED DRUMS.COOL WITH WATER.AVOID SPARKS.BULK VESSELS GROUND
================== Accidental Release Measures ==================
Spill Release Procedures:USE WATER SPRAY TO DISPERSE VAPORS AND TO
PROTECT MEN ATTEMPTING TO STOP A LEAK.REMOVE SOURCES OF
IGNITION.VENTILATE AREA.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE CONTAINERS IN WELL VENTILATED
PLACE.LARG VOLUME STORAGE REMOTE FROM INHABITED BUILDINGS OR
STRUCTURES.
Other Precautions:KEEP AWAY FROM ALL SOURCES OF IGNITION.WEAR CHEMICAL
& GET DOC.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:SELF CONTAINED BREATHING APPARATUS,OR BUREAU OF
MINES CARTRIDGE
Ventilation:MECHANICAL AS NEEDED,SPARKPROOF FANS.
Other Protective Equipment:FACE SHIELD,CHEMICAL
Supplemental Safety and Health
THIS COMMODITY IS GRADE "A" IN FEDERAL SPECIFICATION OM 232
================== Physical/Chemical Properties ==================
HCC:F5
Boiling Pt:B.P. Text:147F,64C
Vapor Pres:92
Vapor Density:1.1
Spec Gravity:0.8
Evaporation Rate & Reference:2.0,BUTYL ACETATE
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR,COLORLESS LIQUID,SLIGHT ALCOHOL ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,SOURCES OF IGNITION.
Stability Condition to Avoid:KEEP AWAY FROM OPEN FLAME,HEAT &
SPARKS.OPEN CONTAINER.
Hazardous Decomposition Products:BURNING MAY PRODUCE IRRITATING VAPOR
OR CARBON MONOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:MATERIAL MAY BE INCINERATED I/A/W LOCAL, STATE &
FEDERAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:MIL-H-46170B;HYDRAULIC FLUID
Preparer's Name:P.A.PARKER
CAGE:0DH22
CAGE:0DHB8
CAGE:0DH22
============= Composition/Information on Ingredients =============
Ingred Name:SYNTHETIC HYDROCARBONS(DIESTER)
Ingred Name:OTHER COMPONENTS (TYPE NOT SPECIFIED)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATION OF
EYES,SKIN,RESPIRATORY OR G.I.TRACTS;CNS EFFECTS LIKE
HEADACHE,DIZZINESS,NAUSEA AND VOMITING.CHRONIC:DRYING OF
SKIN,DEFATTING OR DERMATITIS POSSIBLE.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:SEE HEALTH HAZARDS DATA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.
======================= First Aid Measures =======================
First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:COC
Flash Point:450F,232C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:EXPOSURE TO HEAT BUILDS UP PRESSURE IN
CLOSED CONTAINERS.FIRE OR EXCESSIVE HEAT MAY CAUSE PRODUCTION OF
HAZARDOUS DECOMPOSITION PRODUCTS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER PERSONAL PROTECTION;REMOVE ALL
IGNITION SOURCES;CONTAIN FREE MATERIAL IF POSSIBLE;USE SUITABLE
INERT ABSORBENT MATERIAL AND RECOVER FOR PROPER DISPOSAL IN AN
APPROVED CONTAINER.
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. PROTECT
CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:DO NOT BREATHE MIST. AVOID PROLONGED OR REPEATED
BREATHING OF VAPOR. AVOID CONTACT WITH EYES. USE WITH ADEQUATE
VENTILATION. WASH THOROUGHLY AFTER HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NORMALLY NOT REQUIRED;USE NIOSH/MSHA APPROVED
RESPIRATOR FOR ORGANIC VAPORS/MIST AS REQUIRED IF ABOVE PEL/TLV OR
SCBA IN AN ENCLOSED AREA.
Ventilation:LOCAL/GENERAL TO MAINTAIN PEL/TLV.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER,WORK
CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.
================== Physical/Chemical Properties ==================
HCC:V6
Boiling Pt:B.P. Text:>600F,>316C
Spec Gravity:<1.0
Evaporation Rate & Reference:<1.0(N-BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED CLEAR LIQUID;MILD ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE AND
OTHER UNIDENTIFIED COMPONENTS (TOXIC IN NATURE.).
==================== Disposal Considerations ====================
Waste Disposal Methods:CONSULT LOCAL AUTHORITIES.DISPOSAL MUST BE MADE
IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:GENETRON (FC)-134A
Preparer's Name:MSDS # GTRN-0011
CAGE:0B7T5
CAGE:0B7T5
CAGE:0PK95
============= Composition/Information on Ingredients =============
Ingred Name:1,1,1,2-TETRAFLUOROETHANE
CAS:811-97-2
Fraction by Wt: 100%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:LC50 INHAL RAT IS >500,000PPM/4 HRS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:EYES:MAY CAUSE SEVERE
IRRITATION.SKIN:MAY CAUSE IRRITATION.LIQUID CAUSES
DEFATTING.INGEST:UNLIKELY ROUTE OF EXPOSURE DUE TO PHYSICAL
STATE,HOWEVER TISSUE MAY FREEZING MAY OCCUR.INHAL:THIS ITEM IS A SI
MPLE ASPHYXIANT.
Explanation of Carcinogenicity:THERE ARE NO INGREDIENTS ABOVE 0.1%
WHICH ARE IDENTIFIED AS CARCINOGENS BY NTP,IARC OR OSHA.
Effects of Overexposure:INHAL:LOSS OF COORDINATION,INCREASED PULSE
RATE,DEEPER RESPIRATION.HIGHER LEVELS MAY CAUSE CARDIAC ARRYTHMIAS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING;WASH WITH WATER.WARM
FROSTBITTEN AREA WITH LUKEWARM WATER;CALL PHYSICIAN.EYES:FLUSH
FROSTBITTEN AREA WITH LUKEWARM WATER;CALL PHYSICIAN.INHAL:REMOVE TO
FRESH AIR.GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED.DO NOT
GIVE EPINEPHRINE(ADRENALIN).INGEST:DO NOT INDUCE VOMITING UNLESS
DIRECTED BY PHYSICIAN.GET PROMPT QUALIFIED MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Autoignition Temp:Autoignition Temp Text:>750C
Extinguishing Media:USE MEDIA APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:USE A SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE EQUIPMENT.COOL FIRE EXPOSED CONTAINERS WITH WATER
FOG.
Unusual Fire/Explosion Hazard:THIS MATERIAL MAY BECOME FLAMMABLE WHEN
MIXED WITH AIR UNDER HIGH PRESSURE IN THE PRESENCE OF A STRONG
IGNITION SOURCE.AVOID REACTIVE METALS.
================== Accidental Release Measures ==================
Spill Release Procedures:USE PROPER RESPIRATORY AND PROTECTIVE
EQUIPMENT.REMOVE IGNITION SOURCES;SHUT OFF LEAK;PROVIDE
VENTILATION.TEST AREA FOR SUFFICIENT OXYGEN BEFORE REENTERING(ESP.
LOW-LYING AREAS).
Neutralizing Agent:NOT APPLICABLE.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL,DRY,WELL-VENTILATED
PLACE.KEEP CONTAINER CLOSED WHEN NOT IN USE.KEEP AWAY FROM
HEAT,SPARKS,FLAMES AND INCOMPATIBLE MATERIALS.
Other Precautions:FOLLOW LABEL DIRECTIONS.AVOID BREATHING VAPORS.AVOID
SKIN AND EYE CONTACT.AVOID SUNLIGHT.DO NOT STORE IN SUBGROUND
LOCATIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHERE ENVIRONMENTAL CONTROLS ARE LACKING OR IN
ENCLOSED SPACES USE EITHER A SELF-CONTAINED BREATHING APPARATUS OR
A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS,DEPENDING ON
THE AIRBORN CONCENTRA TION.
Ventilation:USE GENERAL DILUTION VENTILATION FOR STORAGE AREAS;LOCAL
VENTILATION FOR FILLING OPERATIONS.
Other Protective Equipment:IMPERVIOUS SHOES/CLOTH WHERE LEAKAGE IS
PROBABLE & SHOULD BE THERMALLY INSULTAED TO PREVENT FREEZING.NO
CONTACT LENSES.
Work Hygienic Practices:EYEWASH STATIONS,SAFETY SHOWERS.TEST FOR
ADEQUATE OXYGEN BEFORE ENTERING CONFINED SPACES.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:G3
Boiling Pt:B.P. Text:-15F,-26C
Melt/Freeze Pt:M.P/F.P Text:214F,101C
Decomp Temp:Decomp Text:482F,250C
Vapor Pres:85.8
Vapor Density:3.5
Spec Gravity:<1.22
Evaporation Rate & Reference:>1 COMPARED TO CCL*4
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GAS AT RT.CLEAR COLORLESS LIQUID AND VAPOR,FAINT
ETHEREAL ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:NO
FRESHLY ABRADED AL SURFACES MAY CAUSE STRONG EXOTHERMIC REACTION.AVOID
ACTIVE METALS (NA,K,CA,POWDERED AL,MG,ZN).
Stability Condition to Avoid:DO NOT MIX WITH OXYGEN OR AIR ABOVE
ATMOSPHERIC PRESSURE.AVOID IGNITION SOURCES.
Hazardous Decomposition Products:HALOGENS, HALOGEN ACIDS, POSSIBLY
CARBONYL HALIDES, PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL,STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:082391, TRAFFIC SPOTTER
CAGE:97257
CAGE:97257
============= Composition/Information on Ingredients =============
Ingred Name:ETHANOL, 2-BUTOXY-;(2-BUTOXYETHANOL); (EGBE); (ETHYLENE
GLYCOL MONOBUTYL ETHER)
CAS:111-76-2
RTECS #:KJ8575000
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:MODERATE TO SEVERE IRRITATION AND
POSSIBLE TISSUE DAMAGE TO EYES DEPENDING ON EXPOSURE. NAUSEA,
VOMITING AND DIARRHEA MAY OCCUR UPON INGESTION. PROLONGED SKIN
CONTACT MAY CAUSE MODERATE IRRITATION, DE FATTING AND DERMATITIS.
OVEREXOPUSRE OF2-BUTOXYETHANOL MAY CAUSE KIDNEY, LIVER & RED BLOOD
CELL (EFT OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:INJURY. MAY PENETRATE SKIN. ANIMAL
STUDIES CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE
CNS, THE HEMATOPOIETIC TISSUES, THE BLOOD, THE KIDNEYS & LIVER,
ASSOCIATED WITH THE ADMINIS TRATION OF ETHYLENE GLYCOL MONOBUTYL
ETHER (EGBE) (EXTRACTED FROM DHHS (NIOSH) PUBLICATION NO. 90-118) .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHAL:MOVE TO FRESH AIR. CALL MD IF SYMPTOMS PERSIST.
INGEST:GIVE LARGE QUANTITIES OF WATER THEN SEVERAL GLASSES OF MILK.
INDUCE VOMITING, GET MD IMMEDIATELY. EYE:FLUSH IMMEDIATELY WTIH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES LIFTING EYELIDS
OCCASIONALLY. SKIN:REMOVE CONTAMINATED CLOTHING AND WASH WITH
PLENTY OF SOAP & WATER.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:AS REQUIRED BY SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN LARGE SPILLS AND PUMP TO RECOVER,
SMALL SPILLS CAN BE MOPPED UP. FLUSH CONTAMINATED AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE. KEEP
CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ONLY WITHOUT ADEQUATE VENTILATION. NIOSH/MSHA
APPROVED RESPIRATORS APPROPRIATE FOR EXPOSURE OF CONCERN .
Ventilation:EQUIVALENT TO OUTDOORS.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH HANDS THOROUGHLY AFTER USE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.04
Solubility in Water:COMPLETE
Appearance and Odor:OPACIFIED YELLOW LIQUID WITH CHARACTERISTIC ODOR
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS AND OXIDIZERS.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:WAX, FLOOR, WATER EMULSION
Preparer's Name:REGULATORY AFFAIRS DEPT.
CAGE:28745
CAGE:28745
============= Composition/Information on Ingredients =============
Ingred Name:NONHAZARDOUS INGREDIENTS
Fraction by Wt: NA
Other REC Limits:NONE SPECIFIED
===================== Hazards Identification =====================
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:NONE KNOWN
Medical Cond Aggravated by Exposure:NONE KNOWN
======================= First Aid Measures =======================
First Aid:NA
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:NONE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:PICK UP WITH MOP OR WET VAC AND WASH AWAY WITH
WATER.
======================Handling and Storage ======================
Handling and Storage Precautions:FREEZING OF PRODUCT MAY RUPTURE
CONTAINER AND DAMAGE PRODUCT QUALITY. PRODUCT SHELF LIFE IS BEST
RETAINED BY STROEAGE AT 45-100F TEMPERATURES.
Other Precautions:NA
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED
Ventilation:MECHANICAL VENTILATION IS SUGGESTED.
Other Protective Equipment:NA
Work Hygienic Practices:DO NOT TAKE INTERNALLY. WASH CONTAMINATED
CLOTHES BEFORE REUSE.
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:213F,101C
Melt/Freeze Pt:M.P/F.P Text:30.0F,-1.1C
Vapor Pres:21.4 MM
Vapor Density:0.6
Spec Gravity:1.00
pH:9.0
Evaporation Rate & Reference:<1 (DIETHYL ETHER = 1)
Solubility in Water:APPRECIABLE
Appearance and Odor:OFF WHITE EMULSION: NON-OBJECTIONABLE ODOR
Percent Volatiles by Volume:83.6
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN TO HILLYARD INDUSTRIES, INC.
Hazardous Decomposition Products:NONE KNOWN
==================== Disposal Considerations ====================
Waste Disposal Methods:WASH SMALL QUANTITIES DOWN SEWER W/LARGE AMT OF
WATER. KEEP SPILLS/CLEANING RUNOFFS OUT OF MUNICIPAL SEWERS/OPEN
BODIES OF WATER. LARGE SPILLS: PICK UP RUNOFFS W/WET VAC/ABSORBENT.
LANDFILL/INCINERATE SOLID; LIQ PER LOCAL, STATE, FEDERAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:SODIUM TRIPOLYPHOSPHATE
Resp. Party Other MSDS Num.:7758-29-4
CAGE:MO680
CAGE:MO680
Contract Num:SP0450-00-M-D758
CAGE:75656
============= Composition/Information on Ingredients =============
Ingred Name:SODIUM TRIPOLYPHOSPHATE
CAS:7758-29-4
RTECS #:YK4570000
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50(RAT): >2000MG/KG
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS MILDLY IRRITATING TO THE
EYES. SKIN IRRITATION FROM CONTINUOUS CONTACT HAS BEEN REPORTED
DURING MANUFACTURING WHEN PROTECTIVE MEASURES FOR CONTACT OR
PERSONAL HYGIENE PROCEDURES ARE NOT FOL LOWED. HUMAN INDUSTRIAL
EXPERIENCE HAS SHOWN NO SIGNIFICANT INHALATION HAZARD OR SKIN
IRRITATION WHEN EXPOSURES ARE PROPERLY CONTROLLED. CHRONIC: CHRONIC
EXPOSURE TO VERY HIGH LEVELS OF THIS PRODUCT P RODUCES KIDNEY
DAMAGE AND IMPAIRED BONE DEVELOPMENT IN LABORATORY ANIMALS.
HOWEVER, PRODUCT IS LISTED BY THE UNITED STATES FOOD AND DRUG
ADMINISTRATION AS A GENERALLY RECOGNIZED AS SAFE (GRAS) FOOD AD
DITIVE.
Explanation of Carcinogenicity:ACGIH: NOT LISTED.
Effects of Overexposure:PRODUCT IS MILDLY IRRITATING TO THE EYES AND
NON-IRRITATING TO THE SKIN.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY RESPONSIBLE
PARTY.
======================= First Aid Measures =======================
First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. IF IRRITATION
OCCURS & PERSISTS, OBTAIN MEDICAL ATTENTION. SKIN: WASH WITH PLENTY
OF SOAP & WATER. GET MEDICAL ATTENTION IF IRRITATION OCCURS &
PERSISTS . INGESTION: DRINK 1 TO 2 GLASSES OF WATER. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON IF DISCOMFORT PERSISTS,
OBTAIN MEDICAL ATTENTION. INHALATION: REMOVE TO FRESH AIR. IF
BREATHING DIFFIC ULTY OR DISCOMFORT OCCURS & PERSISTS, OBTAIN
MEDICAL ATTENTION. NOTES TO MD: THIS PRODUCT CAUSES MILD EYE
IRRITATION & IS NON-IRRITATING TO SKIN. TREATMENT IS CONTROLLED
REMOVAL OF EXPOSURE WITH SYMPT OMATIC & SUPPORTIVE CARE.
===================== Fire Fighting Measures =====================
Flash Point:NON-COMBUSTIBLE
Extinguishing Media:NON-COMBUSTIBLE.
Fire Fighting Procedures:NOT APPLICABLE.
Unusual Fire/Explosion Hazard:NONE. SENSITIVITY TO STATIC DISCHARGE:
NONE. SENSITIVITY TO IMPACT: NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:MATERIAL SHOULD BE SWEPT UP FOR SALVAGE OR
DISPOSAL.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================Handling and Storage ======================
Handling and Storage Precautions:ANIMAL STUDIES AND MANUFACTURING
EXPERIENCE INDICATE THAT EXPOSURE TO THE PRODUCT MAY RESULT IN EYE
AND SKIN IRRITATION UNDER NORMAL CONDITIONS OF USE. IN THE EVENT OF
CONTACT, IMMEDIATELY FLUSH EYES WITH WATER; WASH SKIN WITH SOAP
AND WATER.
Other Precautions:THE PRODUCT SHOULD BE STORED IN A CLEAN DRY AREA TO
MAINTAIN PRODUCT QUALITY AND TO PREVENT POSSIBLE CONTAMINATION BY
OTHER CHEMICALS. COMMENTS: VENTILATION: CONTROL MEASURES SUCH AS
LOCAL EXHAUST VE NTILATION MAY BE REQUIRED WHERE EXCESSIVE AIRBORNE
DUST LOADING MAY BE PRESENT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE APPROVED RESPIRATORY PROTECTION ID RELEASE
OF THE PRODUCT INTO THE WORK AREA IS EXPECTED.
Ventilation:CONTROL MEASURES SUCH AS LOCAL EXHAUST VENTILATION MAY BE
REQUIRED WHERE EXCESSIVE AIRBORNE DUST LOADING MAY BE PRESENT.
EXPECTED.
Other Protective Equipment:USE LONG SLEEVED WORK SHIRT TO REDUCE
EXPOSED SKIN AREA.
Work Hygienic Practices:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Supplemental Safety and Health
PREVENTION OF EYE & SKIN CONTACT MAY BE REQUIRED UNDER NORMAL USE
CONDITIONS. HOWEVER, SEVERE AGITATION OR DISPERSION INTO THE WORK
ENVIRONMENT MAY REQUIRE ENCLOSURE OF THE PROCESS & LOCAL EXHAUST VE
NTILATION AT THE SOURCE TO PREVENT RELEASE INTO THE AIR.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:>1000.C, 1832.F
Melt/Freeze Pt:=622.C, ######F
Vapor Pres:NON-VOLITILE
Vapor Density:N/VOLITILE
Spec Gravity:0.5 - 1.2 G/ML
pH:10@25C
Evaporation Rate & Reference:NON-VOLITILE (BUAC=1)
Solubility in Water:13
Appearance and Odor:WHITE GRANULES OR POWDER; NO ODOR
Percent Volatiles by Volume:NON-VOLITILE
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
=================== Toxicological Information===================
Toxicological Information:EYE EFFECTS: MILDLY IRRITATING (RABBIT) [FMC
186-917].SKIN EFFECTS: NON-IRRITATING (RABBIT) [FMC 188-1047].
DERMAL LD50: NO DATA AVAILABLE FOR THE PRODUCT. ORAL LD50: >2000
MG/KG (RAT) [FMC STUDY 197- 2169]. INHALATION LC50: 0.39 MG/L
(RAT)(4 HR) (MAXIMUM ATTAINABLE DUST CONCENTRATION) [FMC STUDY
188-1011]. ACUTE EFFECTS FROM OVEREXPOSURE: PRODUCT IS MILDLY
IRRITATING TO EYES & NONIRRITATING TO SKI N. CHRONIC EFFECTS:
CHRONIC EXPOSURE TO VERY HIGH LEVELS OF PRODUCT PRODUCES KIDNEY
DAMAGE & IMPAIRED BONE DEVELOPMENT IN LABORATORY ANIMALS. HOWEVER,
PRODUCT IS LISTED BY US FDA AS A GENERALLY RECOGN IZED AS SAFE
(GRAS) FOOD ADDITIVE.
===================== Ecological Information =====================
Ecological:ECOTOXICOLOGICAL INFORMATION: 96 HR LC50 >100 MG/L,
NON-TOXIC (RAINBOW TROUT, INLAND SILVERSIDES AND MYSID SHRIMP).
[FMC STUDY 189-1081], 1082 & 1083]48 HR EC50 > 100 MG/L, NON-TOXIC
(DAPHNIA MAGNA) [ FMC 189-1084]. CHEMICAL FATE INFORMATION:
INORGANIC COMPOUNDS IN CONTACT WITH THE SOIL, SUB-SURFACE OR
SURFACE WATERS MAY BE TAKEN UP BY PLANTS AND UTILIZED AS ESSENTIAL
NUTRIENTS. PHOSPHATES MAY ALSO FORM PRECIPITATES, USUALLY IN THE
FORM OF CALCIUM OR MAGNESIUM. THE RESULTANT COMPOUNDS ARE INSOLUBLE
IN WATER AND BECOME PART OF THE SOIL OR SEDIMENT. THE TERM
BIODEGRADABILITY, AS SUCH, IS NOT APPL ICABLE TO INORDGANIC
COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:THIS PRODUCT DOES NOT PRESENT A DANGER OR HAZARD
FOR DISPOSAL. EXCEPT FOR FOOD APPLICATIONS, SALVAGE AND RETURN TO
CONTAINER. PROCESS OR RECYCLE FOR OTHER USES. MAY BE DISPOSED OF IN
LANDFILLS ACCORDI NG TO LOCAL, STATE OR FEDERAL REGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:US DOT (DEPARTMENT OF TRANSPORTATION): PROPER
SHIPPING NME: NOT REGULATED. UN/NA NUMBER: NONE. PLACARDS: NOT
REQUIRED. LABEL: NOT REQUIRED. OTHER SHIPPING INFORMATION: DOT
MARKING: NOT APPLICABLE. HAZ ARDOUS SUBSTANCE/RQ: NOT LISTED. 49
STCC NUMBER: NOT APPLICABLE. SPECIAL SHIPPING NOTES: IMDG: NOT
REGULATED. IATA: NOT REGULATED.
===================== Regulatory Information =====================
SARA Title III Information:SECTION 311 HAZARD CATEGORY (40 CFR 370):
NOT APPLICABLE. SECTION 312 THRESHOLD PLANNING QUANTITY (40 CFR
370): NOT APPLICABLE. SECTION 313 REPORTABLE INGREDIENTS (40 CFR
372): NOT APPLICABLE.SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES
(40 CFR 355): NOT LISTED.
Federal Regulatory Information:CERCLA REGULATORY (40 CFR 302.4):
LISTED. CERCLA: SODIUM TRIPOLYPHOSPHATE (STPP) - 5000 LBS.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
======================= Other Information =======================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:ZIRCONIUM OXIDE, Z83500
CAGE:1B464
CAGE:1B464
============= Composition/Information on Ingredients =============
Ingred Name:ZIRCONIUM OXIDE. PEL & TLV:5 MG/M3;10 MG/M3 STEL, (ZR).
CAS:1314-23-4
RTECS #:ZH8800000
Fraction by Wt: 100%
OSHA PEL:SEE INGREDIENT NAME
ACGIH TLV:SEE INGREDIENT NAME
Ingred Name:OTHER PROT EQUIP:EMPLOYER SHOULD PROVIDE EYE WASH FOUNTAIN
W/IN IMMED WORK AREA FOR EMERGENCY USE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:SINGLE INTRATRACHEAL
INSTILLATION TO RATS PRDCD FIBROGENIC & PROLIFERATIVE CHANGES &
SCLEROSIS IN LUNG TISS. SKIN:APPLICATN TO ABRADED SKIN MAY CAUSE
ALLERGIC GRANULOMA FORM IN PREVIOUSLY EXPOSED PERS. INGEST:GI
ABSORP IS POOR & THEREFORE ORAL TOX IS LOW. CHRONIC:INHAL:ONE STUDY
REPORTED (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PULM GRANULOMAS IN RABBITS EXPOSED TO
ZIRCONIUM CMPDS. SKIN:RPTD/PRLNG CONT TO ABRADED SKIN MAY CAUSE
ALLERGIC GRANULOMA, CHARACT BY RED-BROWN, FIRM, SHINY,
ERYTHEMATOUS, NONTENDER PAPULES WH ICH GENERALLY DISAPPEAR SPONT,
BUT SLOWLY, PERSISTING FOR MTHS/YRS.
Medical Cond Aggravated by Exposure:PERSONS W/PRE-EXISTING SKIN
DISORDERS.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE FROM EXPOS AREA TO FRESH AIR IMMED. IF BRTHG HAS
STOPPED, PERFORM ARTF RESP. KEEP PERS WARM & @ REST. TREAT
SYMPTOMATICALLY & SUPPORTIVELY. GET MD IMMED. SKIN:REMOVE CONTAM
CLTHG & SHOES IMMED. WASH AFFECTED AREA W/SOAP/MILD DETERGENT & LG
AMTS OF H*2O UNTIL NO EVID OF CHEM REMAINS (APPROX 15-20 MINS). GET
MD IMMED. EYE:WASH IMMED W/LG AMTS OF H*2O/NORM SALINE, OCCAS
LIFTING (SUPDAT)
===================== Fire Fighting Measures =====================
Extinguishing Media:EXTINGUISH USING AGENT SUITABLE FOR TYPE OF
SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS-DEMAND/POS PRESS
SCBA & FULL PROT EQUIP . NO ACUTE HAZ. MOVE CNTNR FROM FIRE AREA IF
POSS. AVOID BRTHG VAP/DUST; KEEP UPWIND.
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME.
================== Accidental Release Measures ==================
Spill Release Procedures:OCCUP SPILL:FOR LG SPILLS, SWEEP UP W/MINIMUM
OF DUSTING & PLACE INTO SUITABLE CLEAN, DRY CONTAINERS FOR
RECLAMATION OR LATER DISPOSAL. RESIDUE SHOULD BE CLEANED UP USING
HIGH-EFFICIENCY PARTICULATE F ILTER VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE IN TIGHTLY CLOSED CONTAINER.
Other Precautions:OBSERVE ALL FEDERAL, STATE & LOCAL REGULATIONS WHEN
STORING THIS SUBSTANCE. FOR ASSISTANCE, CONTACT DISTRICT DIRECTORS
OF ENVIRONMENTAL PROTECTION AGENCY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR BASED ON
CONTAMINATION LEVEL FOUND IN WORKPLACE & ON SPECIFIC OPERATION.
REFER TO ORIGINAL MSDS FOR SPECIFIC SELECTIONS .
Ventilation:PROVIDE LOCAL EXHAUST VENTILATION SYSTEM TO MEET PEL.
Other Protective Equipment:APPROP PROT (IMPERVIOUS) CLTHG & EQUIP.
WHERE THERE IS ANY POSS THAT EMPLOYEE'S EYES MAY BE EXPOS TO
SUBSTANCE, (ING 2)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
APPEAR/ODOR:MONOCLINIC CRYSTALS. FIRST AID PROC:UPPER & LOWER LIDS,
UNTIL NO EVID OF CHEM REMAINS (APPROX 15-20 MINS). GET MD IMMED.
INGEST:TREAT SYMPTOMATICALLY & SUPPORTIVELY. GET MD IMMED. IF VOMIT
OCCURS, KEEP HEAD LOWER THAN HIPS TO PVNT ASPIR.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:9032F,5000C
Melt/Freeze Pt:M.P/F.P Text:4919F,2715C
Spec Gravity:5.6-6.2
Solubility in Water:INSOLUBLE
Appearance and Odor:ODORLESS, TASTELESS, WHITE TO YELLOW-BROWN, HEAVY
AMORPHOUS POWDER OR(SUPP DATA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NO DATA AVAILABLE.
Stability Condition to Avoid:PREVENT DISPERSION OF DUST IN AIR.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
TOXIC &/OR HAZARDOUS GASES.
==================== Disposal Considerations ====================
Waste Disposal Methods:OBSERVE ALL FEDERAL, STATE & LOCAL REGULATIONS
WHEN DISPOSING OF THIS SUBSTANCE. FOR ASSISTANCE, CONTACT DISTRICT
DIRECTORS OF ENVIRONMENTAL PROTECTION AGENCY.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:COIN CELL POLY-CARBONMONOFLURIDE (BR) LITHIUM BATTERY
Preparer's Name:DOD, HMIS, DSCR-VBA
CAGE:99998
CAGE:99998
CAGE:1HJ92
============= Composition/Information on Ingredients =============
Ingred Name:CATHODE: POLY-CARBONMONOFLUORIDE, (CF)N
Ingred Name:ANODE: LITHIUM, (LI)
Ingred Name:ELECTROLYTE, LI SALT: LITHIUM TETRAFLUOROBORATE, (LIBF4)
Ingred Name:ELECTROLYTE, SOLVENT: Y-BUTYROLACTONE, (Y-BL)
Ingred Name:ELECTROLYTE, SOLVENT: 1,2 DIMETHOXYETHANE, (DME)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:NOSkin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:THIS BATTERY IS A SEALED ARTICLE
EXEMPT FROM THE REQUIREMENTS OF THE HAZARD COMMUNICATION STANDARD,
29 CFR 1910.1200. A MSDS IS NOT REQUIRED. UNDER NORMAL CONDITIONS
OF USE THIS BATTERY DOES NOT RELEA SE MORE THAN VERY SMALL
QUANTITIES, E.G. MINUTE OR TRACE AMOUNTS OF A HAZARDOUS CHEMICAL,
AND DOES NOT POSE A PHYSICAL HAZARD OR HEALTH RISK TO EMPLOYEES.
Effects of Overexposure:NONE.
======================= First Aid Measures =======================
First Aid:NONE REQUIRED.
===================== Fire Fighting Measures =====================
Extinguishing Media:USE MEDIA APROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures:REMOVE BATTERIES FROM AREA OF FIRE.
================== Accidental Release Measures ==================
Spill Release Procedures:IF ONE OF THESE BATTERIES SHOULD LEAK
ELECTROLYTE, WASH THE AREA WITH COPIOUS AMOUNTS OF WATER. IF
CONTACTED BY ANY OF LEAKED ELECTROLYTE, WASH AREA WITH COPIOUS
AMOUNTS OF WATER AND IF IRRITATION OR ADVERSE SYMPTOMS DEVELOP OR
PERSISTS, GET MEDICAL ATTENTION.
======================Handling and Storage ======================
Handling and Storage Precautions:DO NOT ALLOW CELLS OR BATTERIES TO
SHORT CIRCUIT. STORE IN ORIGINAL CONTAINERS. DO NOT PUNCTURE,
INCINERATE, EXPOSE TO FIRE OR TEMPERATURES ABOVE 185F. DO NOT
CHARGE. DO NOT CUT OPEN.
============= Exposure Controls/Personal Protection =============
Other Protective Equipment:NONE NORMALLY REQUIRED.
Work Hygienic Practices:NO SPECIAL WORK HYGENIC PRACTICES NEEDED.
Supplemental Safety and Health
NONE
================== Physical/Chemical Properties ==================
HCC:Z6
Appearance and Odor:A SEALED COIN CELL BATTERY.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ITEM IS A SEALED BATTERY CELL.
Stability Condition to Avoid:SEALED CELL. AVOID EXPOSURE ABOVE 350F.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT INCINERATE OR EXPOSE BATTERIES TO FIRE.
DISPOSE IN ACCORDANCE WITH ALL FEDERAL, STATE, AND LOCAL
RGULATIONS.
=================== MSDS Transport Information ===================
Transport Information:LETTER TO DICK TRAYLOR FROM CHARLES P. MONAHAN,
OF TRN TECHNICAL, INC DATED JAN 1, 1998 : THIS BATTERY UNDER NORMAL
CONDITIONS OF USE DOES NOT RELEASE MORE THAN SMALL QUANTITIES E.G.
MINUTE OR TRACE A MOUNTS OF A HAZARDOUS CHEMICAL, AND DOES NOT POSE
A PHYSICAL HAZARD OR HEALTH RISK TO EMPLOYEES. FROM WEB SITE: ALL
PANASONIC BR LITHIUM BATTERIES ARE UNREGULATED FOR TRUCK, RAIL,
OCEAN, AND AIR TRANS PORTATION BECAUSE THEY MEET THE REQUIREMENTS
OF 49 CFR 173.185 (B). THE ONLY REQUIREMENTS FOR TRANSPORTING THESE
BATTERIES ARE THEY MUST BE SECURELY PACKAGED TO PREVENT THE
POSSIBILITY OF SHORT-CIRCUI TING.
| 0 | eyes_protection_not_mandatory |
===================== Product Identification =====================
Product ID:DERUSTO RPE SPRAY GRADE, 885 GLOSS BLUE (52559)
CAGE:90300
CAGE:90300
============= Composition/Information on Ingredients =============
Ingred Name:ACETONE (SARA 313) (CERCLA)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 25-30%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15-20%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 10-15%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Ingred Name:KEROSENE (PETROLEUM), HYDROCARBON; (PETROLEUM DISTILLATES)
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 5-15%
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:STODDARD SOLVENT; (MINERAL SPIRITS)
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 1-5%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Ingred Name:TOLUENE (SARA 313) (CERCLA)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3-15%
OSHA PEL:200 PPM
ACGIH TLV:S, 50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ingred Name:VOLATILE ORGANIC COMPOUND LESS WATER LESS EXEMPT
SOLVENT:540-623 G/L.
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Ingred Name:VOLATILE ORGANIC COMPOUND MATERIAL:540-623 (GRAMS/LITER)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY IRRIT EYES, SKIN, NOSE &
RESP TRACT. HARMFUL IF INHALED. HARMFUL/FATAL IF SWALLOWED. IF
INGESTED, THIS PROD MAY CAUSE VOMIT, DIARR & DEPRESSED RESP. ASPIR
OF MATL INTO LUNGS DUE TO VOMIT MAY CAUSE CHEM PNEUM WHICH CAN BE
FATAL. INHAL MAY AFFECT BRAIN/NERV SYS CAUSING HDCH, DIZZ/NAUS.
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:CHRONIC:TOLUENE APPEARS ON NAVY
LISTING OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP
HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG &
EXPOS INFO . RPTS HAVE ASSOC PERM BRAIN & NERV SYS DMG W/PRLNGD &
RPTD OCCUP OVEREXP TO SOLVS. PRLNGD/RPTD CONT W/SKIN CAN CAUSE
DEFAT(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:EYES:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. CONTACT A PHYSICIAN IMMEDIATELY. SKIN:WASH IMMEDIATELY
WITH SOAP AND WATER. INHALATION:REMOVE TO FRESH AIR. CONTACT A
PHYSICIAN IMMEDIAT ELY. INGESTION:DO NOT INDUCE VOMITING.
IMMEDIATELY CONTACT A PHYSICIAN OR REGIONAL POISON CONTROL CENTER
FOR ADDITIONAL TREATMENT.
===================== Fire Fighting Measures =====================
Flash Point:AEROSOL
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CNTNRS MAY EXPLODE IF EXPOSED TO EXTREME
HEAT. ELIM SOURCE OF IGNIT, HEAT, ELEC EQUIP, SPKS & OPEN FLAMES.
DO NOT PUT IN CONT W/OXIDIZING/CAUSTIC MATERIALS.
================== Accidental Release Measures ==================
Spill Release Procedures:DIKE SPILL AREA. USE ABSORBENT MATERIAL OR
SCRAPE UP DRIED MATERIAL AND PLACE INTO CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:STORE AWAY FROM CAUSTICS AND
OXIDIZERS. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP OUT
OF REACH OF CHILDREN.
Other Precautions:KEEP CONTAINERS FROM EXCESSIVE HEAT AND FREEZING. DO
NOT STORE AT TEMPERATURES ABOVE 120F. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING AND INHALING VAPORS MAY BE HARMFUL OR
FATAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF 8-HOUR EXPOSURE LIMIT OR VALUE IS EXCEEDED
FOR ANY COMPONENT, USE AN APPROVED NIOSH/OSHA/MSHA RESPIRATOR.
CONSULT YOUR SAFETY EQUIPMENT SUPPLIER AND THE OSHA REGULATION, 29
CFR 1910.134 FOR RESPIRA TOR REQUIREMENTS.
Ventilation:PROVIDE SUFFICIENT MECH VENT (LOC/GEN EXHST) TO MAINTAIN
EXPOS BELOW PEL & TLV. VAPS ARE HVR/AIR & WILL COLLECT (SUPDAT)
Other Protective Equipment:PROVIDE EYEWASH AND SOLVENT IMPERVIOUS APRON
IF BODY CONTACT OCCURS. BARRIER CREAMS MAY BE USED.
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
SPEC GRAV:0.66-1.04 (H*2O=1). EFTS OF OVEREXP:WHICH MAY LEAD TO
DERMATITIS. OVEREXPOSURE OR MISUSE OF TOLUENE CAN CAUSE LIVER,
KIDNEY AND BRAIN DAMAGE, AS WELL AS CARDIAC ABNORMALITIES. VENT:IN
LOW AR EAS. CHECK ALL LOW AREAS (BASEMENTS, SUMPS, ETC.) FOR VAPOR
BEFORE ENTERING.
================== Physical/Chemical Properties ==================
Vapor Density:>1
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID, VARIOUS COLORS; GASOLINE-LIKE ODOR.
Percent Volatiles by Volume:85-90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FREEZING.
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E. CO*X,
NO*X.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE AND LOCAL
STANDARDS. USE ALL MATERIAL BEFORE DISPOSAL. IF UNABLE TO USE
ENTIRE CONTENTS OF CAN, RELIEVE PRESSURE IN CONTAINER UNTIL IT
EQUALS EXTERNAL PRESSURE.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:893 RECOAT SEALER
CAGE:ACMEA
CAGE:ACMEA
============= Composition/Information on Ingredients =============
Ingred Name:ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CARBINOL
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 88%
Other REC Limits:400 PPM
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
Ingred Name:WEIGHT PER GALLON IN POUNDS: 6.79
RTECS #:9999999WG
Ingred Name:VOL ORGANIC CMPD: 5.96 LBS/GAL
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES/SKIN/RESPIRATORY
SYSTEM. CNS DEPRESSION. PROLONGED SOLVENT MAY CAUSE ADVERSE EFFECTS
TO LIVER/URINARY/REPRODUCTIVE. PERMANENT BRAIN & CNS DAMAGE.
EXTREME OVEREXPOSURE MAY CAUSE UNCO NSCIOUSNESS & POSSIBLY DEATH.
ALCOHOLS & ACETATES CAN BE ABSORBED THROUGH THE SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION:
HEADACHE/DIZZINESS/NAUSEA/COORDINATION LOSS/UNCONSCIOUSNESS/DEATH.
SKIN/EYES: REDNESS/ITCH/BURNING SENSATION. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. IF PROBLEMS REMAIN OR OCCUR
DURING USE, IMMEDIATELY GET MEDICAL ATTENTION. SKIN: WASH W/SOAP &
WATER. REMOVE CONTAMINATED CLOTHING. EYES: FLUSH W/PLENTY OF WATER
FOR 1 5 MINUTES. INGESTION: OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:45F
Lower Limits:0.7%
Upper Limits:12.7%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE.
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP, POSSIBLE AUTOIGNITION, OR
EXPLOSION WHEN EXPOSED TO EXTREME HEAT. FLAMMABLE.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA.
REMVOE W/INERT ABSORBENT.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN ADEQUATE VENTILATION. KEEP
AWAY FROM HEAT, SPARKS, OPEN FLAME. DURING USE & UNTIL ALL VAPORS
ARE GONE; KEEP ARE VENTILATED. DON'T SMOKE.
Other Precautions:EXTINGUISH ALL FLAMES, PILOT LIGHTS & HEATERS. TURN
OFF STOVES/ELECTRIC TOOLS/APPLIANCES & OTHER IGNITION SOURCES.
CONSULT NFPA CODE. USE APPROVED BONDING/GROUNDING PROCEDURES. KEEP
CONTAINER CLOSED W HEN NOT IN USE. DON'T TAKE INTERNALLY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
TLV BY VENTILATION, USE A FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN SANDING/ABRADING DRIED
FILM, USE A NIOSH/MSHA DUST/MI ST RESPIRATOR.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO MATERIALS IS MAINTAINED BELOW APPLICABLE LIMITS.
Work Hygienic Practices:WASH HANDS AFTER USING. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
TRANSFER ONLY TO APPROVED CONTAINERS W/COMPLETE LABELING. KEEP OUF OF
REACH OF CHILDREN. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING
& INHALING THE CONTENTS CAN BE HARMFUL OR FATAL. MAY CONTAIN M
ATERIAL CLASSIFIED AS NUISANCE PARTICULATES WHICH MAY BE PRESENT AT
HAAZARDOUS LEVELS ONLY DURING ABRADING/SANDING FILM.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:178-425F
Vapor Density:>1
Spec Gravity:0.82-1.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:55-92
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT/SPARKS/OPEN FLAMES/PILOT LIGHTS &
OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO2, CO & OXIDES OF METALS IN THE
INGREDIENTS SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:PRODUCT WASTE MAY BE HAZARDOUS AS DEFINED UNDER
THE RCRA. TEST WASTE FOR IGNITABILITY TO DETERMINE THE APPLICABLE
EPA HAZARDOUS WASTE NUMBERS. INCINERATE IN APPROVED FACILITY. DON'T
INCINERATE CLOSED CONTAINER. DISPOSE OF IAW FED/STATE/LOCAL REGS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: GEAR OILS 68, 100, 150, 220, 280, 320, 460
Cage: 5R396
Box: 2197
Resp. Party Other MSDS No.: LUBC0180
Proprietary Ind: Y
=======================================================
Contractor Summary
=======================================================
Cage: 5R396
Box: 2197
=======================================================
Ingredients
=======================================================
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Skin: YES
Effects of Exposure: THE PRODUCT, AS WITH MANY PETROLEUM PRODUCTS, MAY CAUSE
MINOR SKIN, EYE, AND LUNG IRRITATION, BUT GOOD HYGIENIC PRACTICES CAN
MINIMIZE THESE EFFECTS. NORMAL USE OF THIS PRODUCT DOES NOT RESULT IN GENE
RATION OF AN OIL MIST. HOWEVER, IF AN OIL MIST IS GENERATED, OVEREXPOSURE CAN
CAUSE MINOR AND REVERSIBLE IRRITATION TO THE EYES, SKIN, AND ESPECIALLY THE
LUNGS. PROPER PERSONAL PROTECTIVE EQUIPMENT AN D SUFFICIENT VENTILATION CAN
PROVIDE ADEQUATE PROTECTION.
Explanation Of Carcinogenicity: NONE OF THE COMPONENTS PRESENT IN THIS MATERIAL
AT CONCENTRATIONS EQUAL TO OR GREATER THAN 0.1% ARE LISTED BY IARC, NTP, OSHA
OR ACGIH AS A CARCINOGEN.
Signs And Symptions Of Overexposure: THE PRODUCT, AS WITH MANY PETROLEUM
PRODUCTS, MAY CAUSE MINOR SKIN, EYE, AND LUNG IRRITATION, BUT GOOD HYGIENIC
PRACTICES CAN MINIMIZE THESE EFFECTS. NORMAL USE OF THIS PRODUCT DOES NOT
RESULT IN GENE RATION OF AN OIL MIST. HOWEVER, IF AN OIL MIST IS GENERATED,
OVEREXPOSURE CAN CAUSE MINOR AND REVERSIBLE IRRITATION TO THE EYES, SKIN, AND
ESPECIALLY THE LUNGS. PROPER PERSONAL PROTECTIVE EQUIPMENT AN D SUFFICIENT
VENTILATION CAN PROVIDE ADEQUATE PROTECTION.
Medical Cond Aggravated By Exposure: NOT PROVIDED
First Aid: INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN. CALL A PHYSICIAN. SKIN:
WASH SKIN THOROUGHLY W/SOAP & WATER. IF IRRITATION DEVEL OPS/PERSISTS,
CONSULT A PHYSICIAN. EYE: IMMEDIATELY FLUSH EYES W/PLENTY OF WATER FOR AT
LEAST 15 MINS. CALL A PHYSICIAN. INGESTION: MATERIAL POSES AN ASPIRATION
HAZARD. IF SWALLOWED, DO NOT INDUCE VO MITING. IMMEDIATELY GIVE 2 GLASSES OF
WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL A
PHYSICIAN. IF VOMITING OCCURS NATURALLY, HAVE VICTIM LEAN FOREWARD TO REDUCE
THE RISK OF ASPI RATION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: USE APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT DURING
CLEAN-UP. REMOVE SOURCE OF HEAT, SPARKS, AND FLAME. DIKE SPILL. PREVENT
MATERIAL FROM ENTERING SEWERS, WATERWAYS, OR LOW AREAS. RECOVER FREE LIQUID
FOR REUSE OR RECLAMATION. SOAK UP WITH SAWDUST, SAND, OIL DRY OR OTHER
ABSORBENT MATERIAL.
Waste Disposal Methods: TREATMENT, STORAGE, TRANSPORTATION AND DISPOSAL MUST BE
IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE/PROVINCIAL, AND LOCAL
REGULATIONS. RECOVER NONUSABLE FREE LIQUID AND DISPOSE OF IN APPROVED AND PER
MITTED INCINERATIOR. DO NOT FLUSH TO SURFACE WATER OR SANITARY SEWER SYSTEM.
Handling And Storage Precautions: CLOSE CONTAINER AFTER EACH USE. DO NOT
PRESSURIZE, CUT, WELD, BRAZE, SOLDER, GRIND, OR DRILL ON OR NEAR FULL OR
EMPTY CONTAINER. EMPTY CONTAINER RETAINS RESIDUE & MAY EXPLODE IN HEAT OF
FIRE. STORE IA W NFPA RECOMMENDATIONS. STORE IN COOL DRY WELL-VENTILATED
AREA.
Other Precautions: EMPTY DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY BUNGED,
AND PROMTLY SHIPPED TO THE SUPPLIER OR A DRUM RECONDITIONER. ALL OTHER
CONTAINERS SHOULD BE DISPOSED OF IN AN ENVIRONMENTALLY SAFE MANNER. ST ORE
AWAY FROM OXIDIZERS, HEAT, SPARKS, FLAME.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: COC
Flash Point: =210.C, 410.F
Flash Point Text: MIN F/P BY WT
Extinguishing Media: WATER SPRAY, FOAM, DRY CHEMICAL, CO2.
Fire Fighting Procedures: WATER OR FOAM MAY CAUSE FROTHING. USE WATER TO KEEP
FIRE-EXPOSED CONTAINERS COOL. WATER MAY BE USED TO FLUSH SPILLS AWAY FROM
EXPOSURES.
Unusual Fire/Explosion Hazard: PRODUCTS OF COMBUSTION MAY CONTAIN CARBON
MONOXIDE, CARBON DIOXIDE, AND OTHER TOXIC MATERIALS. DO NOT ENTER ENCLOSED OR
CONFINED SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT INCLUDING RESPIRATORY
PROTECT ION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQUIRED EXCEPT IN EMERGENCIES OR WHEN
CONDITIONS CAUSE EXCESSIVE AIRBORNE LEVELS OF MIST OR VAPORS. SELECT
APPROPRIATE NIOSH-APPROVED RESPIRATORY PROTECTIVE EQUIPMENT WHEN EXPOSED TO
SP RAY OR MISTS. PROPER RESPIRATOR SELECTION SHOULD BE DETERMINED BY
ADEQUATELY TRAINED PERSONNEL AND BASED ON THE CONTAMINANT(S), THE DEGREE OF
POTENTIAL EXPOSURE
Ventilation: NORMAL SHOP VENTILATION.
Other Protective Equipment: COVERALLS WITH LONG SLEEVES IF SPLASHING IS
PROBABLE.
Work Hygienic Practices: AVOID BREATHING VAPORS OR MIST. AVOID CONTACT WITH
EYES. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. WASH THOROUGHLY AFTER
HANDLING. WASH CONTAMINATED CLOTHING PRIOR TO REUSE.
Supplemental Safety and Health: NOTE TO PHYSICIAN: ACTIVATED CHARCOAL MIXTURE
MAY BE ADMINISTERED. TO PREPARE ACTIVATED CHARCOAL MIXTURE, SUSPEND 50 GRAMS
ACTIVATED CHARCOAL IN 400 ML WATER AND MIX THOROUGHLY. ADMINISTER 5 ML/KG, OR
350 ML FOR AN AVERAGE ADULT.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V6
B.P. Text: NOT AVAILABLE
Vapor Pres: NIL
Vapor Density: >1
Spec Gravity: 0.87 - 0.90 @60F (16C)
Evaporation Rate & Reference: NIL
Solubility in Water: INSOLUBLE
Appearance and Odor: COLORLESS, AMBER TO BROWN (LIGHT) LIQUID;PETROLEUM (MILD),
PUNGENT(SLIGHT) ODOR
Percent Volatiles by Volume: NIL
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, AND FLAMES.
Materials To Avoid: INCOMPATIBLE OR CAN REACT WITH OXIDIZERS.
Hazardous Decomposition Products: HAZARDOUS GASES OR VAPORS INCLUDING OXIDES OF
CARBON , NITROGEN, SULFUR, & PHOSPHORUS. ODOROUS & TOXIC FUMES MAY FORM IF
STORED AT TEMP >113F FOR EXTENDED PERIODS OF TIME OR IF HEAT SOURCES >250F
USED.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: WILL NOT OCCUR.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: MOUSE SKIN PAINTING STUDIES HAVE SHOWN THAT HIGHLY
REFINED PETROLEUM LUBE OILS SIMILAR TO INGREDIENTS IN THIS PRODUCT HAVE NOT
CAUSED SKIN TUMORS.
=======================================================
Ecological Information
=======================================================
Ecological: NO SPECIFIC DATA AVAILABLE ON THIS PRODUCT.
=======================================================
=======================================================
Transport Information: NOT RESTRICTED
=======================================================
Regulatory Information
=======================================================
Federal Regulatory Information: MATERIAL COVERED UNDER CERCLA PETROLEUM
EXCLUSION. MATERIAL AND/OR CONTENTS LISTED IN TSCA INVENTORY. DOES NOT MEET
HAZARDOUS WASTE CHARACTERISTS UNDER RCRA.
State Regulatory Information: MATERIAL MAY CONTAIN INGREDIENTS KNOWN TO STATE
OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS, OR OTHER REPRODUCTVE HARM. READ
& FOLLOW LABEL DIRECTIONS. NOT SUBJECT TO PENNSYLVANIA WORKER &
COMMUNITY RIGHT TO KNOW ACT.
=======================================================
Other Information
=======================================================
=======================================================
Transportation Information
=======================================================
Trans ID NO: 156294
Product ID: GEAR OILS 68, 100, 150, 220, 280, 320, 460
Review Date: 03/16/2001
Multiple KIT Number: 0
Unit Of Issue: CY
Type Of Container: CYLINDER
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
Product ID: GEAR OILS 68, 100, 150, 220, 280, 320, 460
Cage: 5R396
Company Name: CONOCO INC
Street: 5 GREENWAY PLAZA E
PO Box: 2197
Zipcode: 77252
Label Required IND: Y
Date Of Label Review: 03/16/2001
Status Code: A
Origination Code: F
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: THE PRODUCT, AS WITH MANY PETROLEUM PRODUCTS, MAY CAUSE
MINOR SKIN, EYE, AND LUNG IRRITATION, BUT GOOD HYGIENIC PRACTICES CAN
MINIMIZE THESE EFFECTS. NORMAL USE OF THIS PRODUCT DOES NOT RESULT IN GENE
RATION OF AN OIL MIST. HOWEVER, IF AN OIL MIST IS GENERATED, OVEREXPOSURE CAN
CAUSE MINOR AND REVERSIBLE IRRITATION TO THE EYES, SKIN, AND ESPECIALLY THE
LUNGS. PROPER PERSONAL PROTECTIVE EQUIPMENT AN D SUFFICIENT VENTILATION CAN
PROVIDE ADEQUATE PROTECTION.
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:DAVISON BLUE INDICATING SILICA GEL
Preparer's Name:J.H.CONVEY,MGR.ENVIR.CTRL
CAGE:16210
CAGE:00334
CAGE:16210
============= Composition/Information on Ingredients =============
Ingred Name:SILICA GEL - CONSIDERED A NUISANCE DUST
CAS:63231-67-4
RTECS #:VV7322000
Other REC Limits:NONE SPECIFIED
OSHA PEL:20 MPPCF
ACGIH TLV:10 MG/CUM TOTAL DUST
Ingred Name:COBALT CHLORIDE
CAS:7646-79-9
RTECS #:GF9800000
Other REC Limits:NON SPECIFIED
OSHA PEL:0.1 MG CO/CUM
ACGIH TLV:0.1 MG CO/CUM
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 RAT(ESTIMATED) >31,600 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:COBALT CHLORIDE IS GENERALLY
RECOGNIZED AS SAFE AS A TRACE MINERAL ADDED TO ANIMAL FEED. SILICA
GEL IS A SYNTHETIC AMORPHOUS SILICA NOT TO BE CONFUSED
W/CRYSTALLINE SILICA. EPIDEMIOLOGICAL STUDIES IND ICATE A LOW
POTENTIAL FOR HEALTH EFFECTS. IT IS CONSIDERED A NUISANCE DUST &
ACTS AS A DESICCANT TO HUMAN TISSUE.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENETS ARE NOT
LISTED ON THE IARC, NTP OR OSHA CARCINOGENS LISTS.
Effects of Overexposure:DRYING ACTION PF PRODUCT CAN CAUSE IRRITATION
OF THE MUCOUS MEMBRANES OF THE NOSE & THROAT & IRRITATION OF THE
SKIN. COBALT CHLORIDE CAN CAUSE DERMATITIS AND IRRITATION OF NASAL
PASSAGE AND LUNGS.
Medical Cond Aggravated by Exposure:DAVISON KNOWS OF NO MEDICAL
CONDITIONS ABNORMALLY AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:IF ANY IRRITATION PERSISTS OR SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. OCCASIONALLY LIFTING LIDS. SKIN:WASH
W/SOAP & WATER. INHALED:REMOVE TO FRESH AIR. INGESTED:MATERIAL WILL
PASS THROUGH BODY NORMALLY.
===================== Fire Fighting Measures =====================
Flash Point:NON-FLAMMABLE
Extinguishing Media:MFR GAVE NO INFORMATION OF MSDS.
Fire Fighting Procedures:NON-FLAMMABLE. MFR GAVE NO INFORMATION OF
MSDS.
Unusual Fire/Explosion Hazard:NON-FLAMMABLE. MFR GAVE NO INFORMATION OF
MSDS.
================== Accidental Release Measures ==================
Spill Release Procedures:SWEEP UP OR VACUUM UP.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP TIGHTLY SEALED TO PROTECT
QUALITY.
Other Precautions:WHEN POURING INTO A CONTAINER OF FLAMMABLE LIQUID,
GROUND BOTH CONTAINERS ELECTRICALLY TO PREVENT A STATIC ELECTRIC
SPARK.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF DUSTY CONDITION PREVAIL, WEAR A PROPERLY
FITTED NIOSH-APPROVED DUST RESPIRATOR.
Ventilation:MFR GAVE NO INFORMATION OF MSDS.
Other Protective Equipment:FOR MANUAL HANDLING:WEAR LONG SLEEVES AND
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
NOT KNOWN TO HAVE ANY ADVERSE EFFECTS ON THE AQUATIC ENVIRONMENT. THE
SILICA BASE IS INSOLUBLE AND NONTOXIC. COBALT CHLORIDE MAY LEACH
AWAY IF CONTACTED WITH WATER.
================== Physical/Chemical Properties ==================
HCC:N1
NRC/State Lic Num:NONE
Spec Gravity:2.1
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR BLUE GRANULES, NO ODOR. PH OF 5% SLURRY; 6.5
TO 7.5
Corrosion Rate:UNKNOWNN
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MFR GAVE NO INFORMATION OF MSDS.
Stability Condition to Avoid:MFR GAVE NO INFORMATION OF MSDS.
Hazardous Decomposition Products:MFR GAVE NO INFORMATION OF MSDS.
Conditions to Avoid Polymerization:MFR GAVE NO INFORMATION OF MSDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN AN APPROVED LANDFILL I/A/W FEDERAL,
STATE & LOCAL REGULATIONS. COVER PROMPTLY TO AVOID BLOWING OF DUST.
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:007 PENETRATING STAINS
CAGE:DALWO
CAGE:DALWO
============= Composition/Information on Ingredients =============
Ingred Name:MINERAL SPIRITS-ALIPHATIC HYDROCARBONS
Fraction by Wt: 80%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION. ANEMIA, KIDNEY DAMAGE. NOTICE: REPORTS HAVE ASSOCIATED
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE W/REPEATED/PROLONGED
OVEREXPOSURE TO SOLVENTS. INTENTIONAL MI SUSE BY DELIBERATELY
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL/FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PALE, NAUSEA, DIZZY, WEAK, REDNESS,
TEARING, BLURRED VISION, VOMITING, DIARRHEA. SENSITIZATION.
Medical Cond Aggravated by Exposure:RESPIRATORY ALLERGIES & SKIN
SENSITIZATION MAY BECOME WORSE UPON EXPOSURE TO THE PRODUCT/ITS
INGREDIENTS.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF NEEDED. EYES:
FLUSH W/LARGE AMOUNTS OF WATER. SKIN: THOROUGHLY WASH EXPOSED AREA
W/SOAP & WATER. INGESTION: DONT INDUCE VOMITING, KEEP WARM & QUIET.
OBT AIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F
Lower Limits:1.02
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA W/A FULL FACEPIECE OPERATED IN
PRESSURE-DEMAND/OTHER POSITIVE PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS ARE > THAN AIR & MAY TRAVEL ALONG
THE GROUND TO OTHER IGNITION SOURCES. AUTO-IGNITION TEMP 473F. (SEE
SUPP)
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT. STOP AT SOURCE, DIKE AREA, PUMP LIQUID TO SALVAGE TANK.
======================Handling and Storage ======================
Handling and Storage Precautions:USE ONLY IN WELL VENTILATED AREA.
AVOID STORAGE AT FLASH POINT OF 100F TEMP NEAR FIRE/OPEN FLAME.
Other Precautions:KEEP CLOSURE TIGHT & CONTAINER UPRIGHT TO PREVENT
LEAKAGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:APPROVED CHEMICAL/MECHANICAL FILTERS.
Ventilation:LOCAL EXHAUST/MECHANICAL (GENERAL): RECOMMENDED. EXPLOSION
PROOF.
Other Protective Equipment:WEAR CHEMICAL RESISTANT BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH HANDS BEFORE EATING/USING THE WASHROOM.
Supplemental Safety and Health
FIRE & EXPLOSION CONT'D: NEVER USE WELDING/CUTTING TORCH NEAR CONTAINER
EVEN EMPTY BECAUSE PRODUCT EVEN RESIDUE CAN IGNITE EXPLOSIVELY.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:300F
Vapor Pres:2
Vapor Density:4.9
Spec Gravity:0.89
Solubility in Water:INSOLUBLE
Appearance and Odor:COLOR LIQUID W/PETROLEUM NAPTHA
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, FLAME, IGNITION SOURCES.
Hazardous Decomposition Products:CO, HYDROCARBONS.
==================== Disposal Considerations ====================
Waste Disposal Methods:ALLOW VOLATILE PORTION TO EVAPORATE IN HOOD.
DESTROY BY LIQUID INCINERATION IAW/FEDERAL, STATE & LOCAL
REGULATIONS.
| 1 | eyes_protection_mandatory |
=======================================================
Product ID: AZ-1411 CA MIDTONE BASE AZ-COTE ALL TOPCOATS & PRIMERS
Cage: OADX8
=======================================================
Contractor Summary
=======================================================
Cage: OADX8
=======================================================
Ingredients
=======================================================
Cas: 64741-41-9
% low Wt: 25.
% high Wt: 50.
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Effects of Exposure: MAY BE IRRITATING TO THE EYES & RESPIRATORY TRACT. MAY
CAUSE NERVOUS SYSTEM EFFECTS & DEATH. ANESTHETIC. LOW ORAL & DERMAL
TOXICITY. INGESTION: MINUTE AMOUNTS ASPIRATED INTO THE LUNGS DURING INGESTION
/VOMITING MAY CAUSE MILD TO SEVERE PULMONARY INJURY & POSSIBLY DEATH.
CHRONIC EXPOSURE MAY CAUSE DAMAGE TO THE CNS, RESPIRATORY SYSTEM, LUNGS,
EYES, SKIN, LIVER, GI TRACT, SPLEEN, KIDNEYS & BLOOD. REP EATED/PROLONGED
OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL/FATAL.
Signs And Symptions Of Overexposure: IRRITATION, HEADACHE, DIZZINESS,
DROWSINESS, UNCONSCIOUSNESS, VOMITING.
First Aid: INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. TREAT
SYMPTOMATICALLY. EYES: FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR 15
MINS. SKIN: WIPE OFF W/TOWEL. WASH W/SOAP & WATER. INGESTION: REMOVE
STOMACH CONTENTS BY GASTRIC SUCTION/INDUCE VOMITING ONLY AS DIRECTED BY A
MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. OBTAIN
MEDICAL ATTENTION IN ALL CASES.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE ALL SOURCES OF IGNITION, FLAMES, HOT SURFACES,
ELECTRICAL, STATIC/FRICTIONAL SPARKS. AVOID BREATHING VAPORS. VENTILATE AREA.
USE NON-SPARKING TOOLS. REMOVE W/INERT ABSORBENT.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.
Handling And Storage Precautions: DON'T STORE NEAR HEAT, SPARKS/FLAME.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point: =38.9C, 102.F
Extinguishing Media: CO2, DRY CHEMICAL, FIRE FOAM
Fire Fighting Procedures: WATER IS UNSUITABLE, BUT MAY BE USED TO COOL CLOSED
CONTAINERS.
Unusual Fire/Explosion Hazard: KEEP AWAY FROM HEAT, SPARKS & FLAME.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IN CONFINED AREAS OF POOR VENTILATION, USE CHEMICAL
CARTRIDGE RESPIRATOR/SELF CONTAINED BREATHING APPARATUS.
Ventilation: GENERAL DILUTION/LOCAL EXHAUST IN VOLUME & PATTERN TO KEEP TLV
& LEL OF MOST INGREDIENTS BELOW ACCEPTABLE LIMIT.
Other Protective Equipment: NONE
Work Hygienic Practices: REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES BEFORE
REUSE.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 311-380F
Vapor Density: >1
Evaporation Rate & Reference: SLOWER THAN ETHER
Percent Volatiles by Volume: 53.87-63.82
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HEAT, SPARKS, FLAMES, HOT SURFACES, ELECTRICAL,
STATIC/FRICTIONAL SPARKS
Hazardous Decomposition Products: FIRE, BURNING & WELDING MAY GENERATE CO.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: FIRE, BURNING, WELDING.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
Product ID: AZ-1411 CA MIDTONE BASE AZ-COTE ALL TOPCOATS & PRIMERS
Cage: OADX8
Assigned IND: Y
Company Name: DIAMOND VOGEL PAINT
Street: 1020 ALBANY PLACE SOUTH
Zipcode: 51041
Label Required IND: Y
Date Of Label Review: 09/14/1999
Status Code: A
Origination Code: G
=======================================================
| 1 | eyes_protection_mandatory |
===================== Product Identification =====================
Product ID:117 6262 KODAK READY PRO DENTAL TWIN PACK, PART DEVELOPER
CAGE:19139
CAGE:19139
CAGE:5K871
============= Composition/Information on Ingredients =============
Ingred Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Fraction by Wt: 90-95%
Other REC Limits:NONE RECOMMENDED
Ingred Name:SODIUM SULFITE
CAS:7757-83-7
RTECS #:WE2150000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:HYDROQUINONE (SARA 302/313) (CERCLA)
CAS:123-31-9
RTECS #:MX3500000
Fraction by Wt: 3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG/M3
ACGIH TLV:2 MG/M3; 9596
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Ingred Name:SODIUM BICARBONATE
CAS:144-55-8
RTECS #:VZ0950000
Fraction by Wt: 1-5%
Other REC Limits:NONE RECOMMENDED
Ingred Name:POTASSIUM CARBONATE
CAS:584-08-7
RTECS #:TS7750000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NOOSHA:NO
Health Hazards Acute and Chronic:INHALATION: EXPECTED TO BE LOW HAZARD
FOR RECOMMENDED HANDLING. EYES: CAUSES IRRITATION. SKIN: CAUSES
IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. INGESTION: EXPECTED
TO BE A LOW INGESTION HAZARD.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:IN CONTACT WITH STRONG ACIDS OR IF HEATED,
SULFITES MAY LIBERATE SULFUR DIOXIDE GAS. SULFUR DIOXIDE GAS IS
IRRITATING TO THE RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:SOME ASTHMATICS OR
SULFITE-SENSITIVE INDIVIDUALS MAY EXPERIENCE WHEEZING OR CHEST
TIGHTNESS.
======================= First Aid Measures =======================
First Aid:INHALATION-IF SYMPTOMATIC, REMOVE TO FRESH AIR. GET MEDICAL
ATTENTION IF SYMPTOMS PERSIST. EYES-IMMEDIATELY FLUSH WITH PLENTY
OF WATER FOR AT LEAST 15 MIN. GET MEDICAL ATTENTION.
SKIN-IMMEDIATELY REMO VE CONTAMINATED CLOTHES/SHOES & WASH WITH
SOAP & PLENTY OF WATER. IF SKIN IRRITATION DEVELOPS, GET MEDICAL
ATTENTION. NGESTED-DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL
ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:USE APPROPIATE AGENT FOR ADJACENT FIRE.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
======================Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED.
Other Precautions:AVOID CONTACT WITH EYES, SKIN AND CLOTHING. USE WITH
ADEUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. THE ROUTINE
USE OF A NONALKALINE TYPE OF HAND CLEANER & REGULAR CLEANING OF
WORK SURFACES WILLHELP MINIMIZE SKIN REACTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE SHOULD BE NEEDED.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES/HR)
SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS
Other Protective Equipment:EYE BATH, SAFETY SHOWER, WASHING FACILITIES.
Work Hygienic Practices:IT IS GOOD INDUSTRIAL HYGIENE PRACTICE TO
MINIMIZE EYE CONTACT. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
KEEP OUT OF REACH OF CHILDREN.
================== Physical/Chemical Properties ==================
HCC:B3
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:18 MMHG
Vapor Density:0.6 AIR=1
Spec Gravity:1.08
pH:10.1
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID, COLORLESS, ODORLESS.
Percent Volatiles by Volume:90
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE WITH COMMON MATERIALS AND CONTAMINATS WITH WHICH THE MATERIAL MAY
REASONABLY COME INTO CONTACT.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER.
| 1 | eyes_protection_mandatory |